Oil Pump; Final Gear Oil - Suzuki UG110 2021 Service Manual

2-8 PERIODIC MAINTENANCE
• Start the engine, turn the throttle stop screw 2 and set the
engine idle speed as follows.
4 Engine idle speed: 1 800 ± 200 r/min

OIL PUMP

Inspect initially at 1 000 km (1 month) and every 6 000 km
(6 months) thereafter.
The engine oil is fed by the oil pump to the engine. The amount
of oil fed to it is regulated by engine speed and the oil pump
control lever which is controlled by the amount of throttle open-
ing.
Check the oil pump in the following manner to confirm corret
operation for throttle grip full opening position.
• Remove the trunk. (75-6)
• Turn the throttle grip full open.
• Check whether the red mark 1 on the oil pump control lever is
aligned with the index mark 2 when the throttle grip is posi-
tioned as above.
• If the marks are not aligned, loosen the locknut 3 and turn the
adjuster 4 in or out to align the marks.
• After alining the marks, tighten the locknut.
5
Oil pump cable adjustment must be done after throttle
cable adjustment.

FINAL GEAR OIL

Inspect initially at 1 000 km (1 month) and every 12 000
km (12 months) thereafter.
• Remove the final gear oil level bolt 1 and inspect the oil level.
If the oil level is below the brim of the final gear oil level hole,
add oil until it runs out from the level hole.
Final gear oil viscosity and classification: SAE 10W/40
• Tighten the final gear oil level bolt 1 to the specified torque.
" Final gear oil level bolt: 12 N . m (1.2 kgf . m)