Table of Contents
Advertisement
Innovative Hearth Products
DRT63ST-B Power-Vent Direct-Vent Fireplaces
TABLE OF CONTENTS
Safety and Your Fireplace ................... 2
Packaging ................................................... 4
Introduction ................................................ 4
Approved Vent Components .................... 4
General Information .................................... 4
Misc. Codes/Standards ........................... 6
Inputs and Efficiencies ............................ 6
Gas Supply Pressure Requirements ........ 6
Orifice Sizes ............................................ 6
Gas Valve Diagram ................................. 6
Massachusetts Requirements ................. 7
Cold Climate Insulation ............................... 7
Manufactured Home Requirements ............ 7
Location ...................................................... 7
Vent Termination Clearances ...................... 8
Hearth Extensions (Optional) ...................... 10
Minimum Clearances to Combustibles ........ 11
Pre-Installation Steps .................................. 12
Typical Installation Sequence ..................... 12
Detailed Installation Steps ........................... 12
Finishing Requirements .............................. 32
Warnings ..................................... 34
Installation Accessories .............................. 35
Important Safety Information ................... 37
Maintenance Notices ............................... 38
Appliance Operation Notices ..................... 38
Warranty Information....................................38
Operation and Care of Your Appliance ....... 40
Maintenance ............................................... 43
and Modesty Panel ..................................... 44
Ordering Replacement Parts ...................... 45
Wiring Diagram .......................................... 45
Accessory Components.............................. 46
Operating (Lighting) Instructions .............. 47
System........................................................ 50
Troubleshooting Power Vent System ......... 51
Replacement Parts List .............................. 52
Warranty ..................................................... 57
4
PACKAGING
• Fireplace Components:
(1) Literature Kit (this manual)
(1) Remote Control Kit
(1) Log Set
(1) Vent Restrictor Assembly
(1) bag Platinum Glowing Embers
(4) bags Volcanic Stone
(1) ea. Door Modesty Shield
(2) Barriers
• Power Vent Components:
(1) ea. Power Vent Termination
(1) ea. Termination Adaptor
(1) ea. Horizontal Firestop Assembly
(1) ea. Vacuum Hose
(1) ea. 11/32" Hose Clamp
(1) ea. Strain Relief
(1) ea. Bushing
(4) ea. 1/4" Insulated Male Terminals
(2) ea. #10 Ring Terminals
• Panel Kit (sold separately; REQUIRED for all
fireplace models) - one of the following kits:
- Architectural Stone Ceramic
- Venetian Tile Ceramic
- Buff Herringbone Ceramic
- Buff Rustic Ceramic
- Black Rustic Ceramic
- Black Porcelain
• Outdoor Kit (sold separately; REQUIRED for
indoor/outdoor installations)
NOTE: If the barrier becomes damaged,
the barrier shall be replaced with the
manufacturer's barrier for this appliance.
FOR USE WITH BARRIER(S) PART NO(S).
J7422 (40" MODELS).
INTRODUCTION
The See-Through Power Vent is a direct-vent,
sealed combustion gas fireplace designed
for either indoor/indoor or indoor/outdoor
residential applications (including screened
porches and lanais).
NOTE: INDOOR/OUTDOOR INSTALLATIONS
REQUIRE AN OUTDOOR INSTALLATION KIT
(SOLD SEPARATELY).
These appliances are designed to operate on
natural gas. The system is switchable between
standing and intermittent pilot modes.
External electrical power is required to operate
these units.
NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
General Information
901140-00, 01/2021
Approved Vent Components
These fireplaces are designed, tested and listed
for operation and installation with the following
vent components only:
• Secure Vent
Direct-Vent System Compo-
®
nents,
• Secure Flex
Flexible Vent Components, and
®
• Z-FLEX
Model GA Venting Systems listed
®
to UL1777 and ULCS635 manufactured by
Flexmaster Canada Limited.
Use only the correct size venting (4-1/2" inner
and 7-1/2" outer).
These approved vent system components are
labeled for identification. DO NOT use any
other manufacturer's vent components with
these fireplaces.
GENERAL INFORMATION
WARNING
Young children should be carefully
supervised when they are in the
same room as the appliance. Tod-
dlers, young children and others
may be susceptible to accidental
contact burns. A physical barrier
is recommended if there are at risk
individuals in the house. To restrict
access to a fireplace or stove,
install an adjustable safety gate to
keep toddlers, young children and
other at risk individuals out of the
room and away from hot surfaces.
AVERTISSEMENT
Les jeunes enfants devraient être
surveillés étroitement lorsqu'ils
se trouvent dans la même pièce
que l'appareil. Les tout petits,
les jeunes enfants ou les adultes
peuvent subir des brûlures s'ils
viennent en contact avec la sur-
face chaude. Il est recommandé
d'installer une barrière physique si
des personnes à risques habitent
la maison. Pour empêcher l'accès
à un foyer ou à un poêle, installez
une barrière de sécurité; cette
mesure empêchera les tout petits,
les jeunes enfants et toute autre
personne à risque d'avoir accès à
la pièce et aux surfaces chaudes.
Advertisement
Table of Contents
Troubleshooting
