Table of Contents
Advertisement
Quick Links
Serial #
(located on electrical box cover)
Date of Installation
Wiring Type
OWNER'S MANUAL
SERIES 2000
MODEL HT
HEAVY DUTY
BELT DRIVEN TROLLEY OPERATOR
©
COMMERCIAL DOOR OPERATOR
LISTED
®
NOT FOR RESIDENTIAL USE
®
The Chamberlain Group, Inc.
A DUCHOSSOIS ENTERPRISE
845 Larch Avenue
Elmhurst, Illinois 60126
Advertisement
Table of Contents
Related Manuals for Chamberlain 2000 Series
Summary of Contents for Chamberlain 2000 Series
- Page 1 The Chamberlain Group, Inc. A DUCHOSSOIS ENTERPRISE 845 Larch Avenue © Elmhurst, Illinois 60126 OWNER'S MANUAL SERIES 2000 MODEL HT HEAVY DUTY BELT DRIVEN TROLLEY OPERATOR Serial # (located on electrical box cover) COMMERCIAL DOOR OPERATOR Date of Installation LISTED ®...
-
Page 2: Specifications
SPANS AMERICA INSTALLATION AND SERVICE INFORMATION ADDRESS ORDER TO: ARE AVAILABLE 6 DAYS A WEEK THE CHAMBERLAIN GROUP, INC. CALL OUR TOLL FREE NUMBER - 1-800-528-6563 Electronic Parts & Service Dept. HOURS 7:00 TO 3:30 p.m. (Mountain Std. Time) 2301 N. Forbes Blvd., Suite 104... - Page 3 ASSEMBLE TRACK AND OPERATOR WARNING CAUTION KEEP DOOR BALANCED. STICKING OR BINDING DO NOT CONNECT ELECTRIC POWER UNTIL DOORS MUST BE REPAIRED. DOORS, DOOR INSTRUCTED TO DO SO. SPRINGS, CABLES, PULLEYS, BRACKETS AND THEIR HARDWARE MAY BE UNDER EXTREME TENSION AND CAN CAUSE SERIOUS PERSONAL INJURY OR DEATH.
- Page 4 INSTALL OPERATOR CAUTION: AT LEAST TWO PERSONS AND A STRONG, SAFE WORKING PLATFORM ARE REQUIRED FOR THE INSTALLATION OF OPERATOR. FIGURE 2 CAUTION TO AVOID DAMAGE TO DOOR AND OPERATOR, Building Support MAKE ALL DOOR LOCKS INOPERATIVE. SECURE LOCK(S) IN "OPEN" POSITION. Vertical IF THE DOOR LOCK NEEDS TO REMAIN Centerline...
- Page 5 9. Raise operator straight up until the door can be COIL CORD (OPTIONAL) raised to the full open position. See Figure 5. REFER TO (A) IN ILLUSTRATION Temporarily secure to ceiling or rafters with rope Connect operator end of coil cord to junction box (not or other suitable means.
- Page 6 CONNECT OPERATOR TO POWER SUPPLY AND INSTALL CONTROL STATION WARNING WARNING DISCONNECT POWER AT THE FUSE BOX BEFORE INSTALL THE CONTROL STATION WHERE THE PROCEEDING. DOOR IS VISIBLE, BUT AWAY FROM THE DOOR AND ITS HARDWARE. IF CONTROL STATION CANNOT BE OPERATOR MUST BE PROPERLY GROUNDED AND INSTALLED WHERE DOOR IS VISIBLE, OR IF ANY CONNECTED IN ACCORDANCE WITH LOCAL...
-
Page 7: Emergency Disconnect System
EMERGENCY DISCONNECT SYSTEM WARNING DOOR ARM IS RELEASED FROM TROLLEY WHEN Header Trolley Bracket EMERGENCY DISCONNECT OPENS. Track TO AVOID BEING STRUCK BY DOOR ARM, DO NOT STAND UNDER THE ROPE OR DOOR ARM WHEN PULLING THE EMERGENCY RELEASE. Clevis Emergency TO DISCONNECT Chain... -
Page 8: Adjust Clutch
SPANS AMERICA INSTALLATION AND SERVICE INFORMATION ADDRESS ORDER TO: ARE AVAILABLE 6 DAYS A WEEK THE CHAMBERLAIN GROUP, INC. CALL OUR TOLL FREE NUMBER - 1-800-528-6563 Electronic Parts & Service Dept. HOURS 7:00 TO 3:30 p.m. (Mountain Std. Time) 2301 N. Forbes Blvd., Suite 104... - Page 9 1A3989, 1A4045, 1A4046 & 1A4047 BRAKE INSTALLATION & ASSEMBLY PARTS WARNING Clutch TO AVOID SERIOUS PERSONAL INJURY OR DEATH Pulley FROM ELECTROCUTION, DISCONNECT Cotter Shaft ELECTRICAL POWER TO OPERATOR BEFORE PROCEEDING. 3/4" Washer 1. Install brake drum on clutch pulley shaft as 3/4"...
- Page 10 SINGLE PHASE WIRING DIAGRAM SINGLE PHASE WIRING DIAGRAM (For PC Board #14D0379) (For P.C. Board #14D0379) The Chamberlain Group, Inc. Brown Wiring Diagram Standard Duty 1Ø SENSING AUXILARY LIMIT DEVICE LIMIT (Reference Label 132B2041B) SWITCH SWITCH 4/28/91 - 6/1/91 - 6/11/91 - 6/15/91...
- Page 11 SINGLE PHASE SCHEMATIC DIAGRAM SINGLE PHASE SCHEMATIC DIAGRAM (For P.C. Board #14D0379) (For P.C. Board #14D0379) Neutral 115v 1Ø Hot 115v 1Ø White Black Single Phase Overload Protector Orange Yellow 115 Vac Only Orange P1-4 P1-1 MOTOR Blue Brake (If Req'd) Black Orange * NOTE: Remove Jumper...
- Page 12 THREE PHASE WIRING DIAGRAM (For P.C. Board #14D3079) THREE PHASE WIRING DIAGRAM (For PC Board #14D0379) Brown AUXILARY SENSING LIMIT DEVICE LIMIT SWITCH SWITCH OPEN CLOSE LIMIT LIMIT SWITCH SWITCH Yellow Gray Gray Blue Blue Orange Brown Brown Brown Orange Blue Orange Blue...
- Page 13 THREE PHASE SCHEMATIC DIAGRAM (For P.C. Board #14D0379) Hot 3Ø Hot 3Ø Hot 3Ø White Orange Three Phase Overload Relay (3/4 HP to 2 HP Only) Orange Yellow Orange P1-4 P1-1 MOTOR Brake Blue Req'd) Black Orange Place Jumper Between 3 & 4 If 3Ø...
- Page 14 WIRING KITS TYPE STATION B2, C2, D1, E2, T D1, E2 3 Button Function: Momentary contact to open, close and stop, plus wiring for sensing device to reverse and auxiliary devices to open and close with open override. B2, T, B2, C2, E2 T, TS B2, C2,...
- Page 15 NEMA MOTOR WIRING DIAGRAMS he Chamberlain Group, Inc. NEMA Motor Wiring Diagrams NEMA MOTOR WIRING DIAGRAMS /1/92 SINGLE VOLTAGE 1 PHASE 1/3 & 1/2 H.P. 115 V only 115V 115V 230V Motor Motor Motor T2 White Black T1 - Blue...
- Page 16 ILLUSTRATED PARTS – ELECTRICAL BOX...
- Page 17 ELECTRICAL BOX PARTS LIST ITEM PART NO. DESCRIPTION FOR HT & HJ SERIES 1B3727 Terminal Assy. 3-Lug 41K4304 Switch Bracket Assy. (Aux. & Sensing) 1B3796 Ltd. Shaft-Sprocket Assy. 1B3938 Cover & Hinge Assy. 1C3937 Electric Box Assy. 1D4017 Wire Harness 11A012 Flanged Sleeve Bearing 41K4303...
- Page 18 ILLUSTRATED PARTS - OPERATOR MODEL HT ILLUSTRATED PARTS – OPERATOR MODEL HT...
- Page 19 REPAIR PARTS FOR MODEL HT ITEM PART NO. DESCRIPTION Electrical Box Assy. (See detail) 1B4062 Motor Cable Assy. Motor See Chart 1C3972 Motor Plate Assy. 1A3971 Chain Assy. (49 Pitches) 81C151 Sprocket-Hub Assy. 13-3/4 See Chart L-Rail 1B4001 Trolley Assy. 1C3992 1 Bracket Assy., #48 Chain 1C3993...
-
Page 20: Control Connection Diagram
TIMER DEFEAT SWITCH REMOVE JUMPER TIMER 2 OR MORE WIRING TYPES - B2, C2, D1, E2, T & TS WIRING TYPES - ALL WIRING TYPES - T & TS ©1992, The Chamberlain Group, Inc. Printed in Mexico 114A1663 All Rights Reserved 114A1663A...