Page 1
Service Manual ViewSonic N3235w-2M Model No. VS11770-2M 32” LCD TV (N3235w-2M_SM Rev. 1a Apr. 2008) ® ViewSonic 381 Brea Canyon Road, Walnut, California 91789 USA - (800) 888-8583...
Page 2
Further, ViewSonic reserves the right to revise this publication and to make changes from time to time in the contents hereof without obligation of ViewSonic to notify any person of such revision or changes.
(IEC60950 or UL1950), or be applied exemption. (14) The LCD module is designed so that the CFL in it is supplied by Limited Current Circuit (IEC60950 or UL1950). Do not connect the CFL in Hazardous Voltage Circuit. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 5
Do not touch the surface that may cause “Mura” of the polarizer. Take out the monitor with cushions Taking out the monitor by grasping the LCD panel. That may cause “Mura” ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 6
Place the monitor on a clean and soft foam pad. Placing the monitor on foreign objects. That could scratch the surface of the panel or cause “Mura” ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Typical. 0.35 V Audio Characteristics: AF Output Level Measured via LP 20 kHz Typical. 0.35Vrms Filter, RMS Decoder, 75us De-emphasis 10% (max.) 44 dB (min.) Compatible system TUNER NTSC/ATSC Compatible system AV NTSC M ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 8
50 ± 3 Hz, 60 ± 3 Hz Input Frequency Range Input Current 3.0A @ 115VAC // 1.5A @ 230VAC Power Supply Inrush Max in < 80A (with fully loaded power supply) at 230Vac ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 9
5. Firmware & OSD The product firmware of VS11770-2M shall have a firmware version of V:P01 or later version. Any changes/revisions afterward shall also be pre-approved by ViewSonic in written. For VS11770-2M, its firmware shall have a built-in frequency table for NTSC/ATSC off-air TV/CATV, Closed-Caption, and with MTS implementation.
Page 10
Power Key - PANTONE 032C (RED) Color Key Pads – PANTONE 11C & PANTONE 5C(Cool Gray) Texts Printed on Front Cover and Key Pads - PANTONE 427C, PANTONE 433C(Black) VS key-code & protocol Protocol ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 11
Sample Sample of textured color chips, plastic material specification, and Material Safety Data Sheets shall be submitted to ViewSonic prior to Mass Production Release. In addition, all exterior surfaces shall have uniform texture/color. The maximum acceptable gap between the buckets to bezel plastic pieces shall be within 1.5 mm.
Power LED Indicator Lights up in blue when the TV is turned on. Lights up in amber when the TV is in standby mode. Remote Control Receiver Receives IR signals from the remote control. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 13
Connect the S-Video cable from the compatible device to this connector on the rear panel of the LCD TV. Air/Cable input jack Connect the coaxial (RF) connector from Antenna/ Cable/ Digital cable. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 14
If both are connected, S-Video signal has priority. N3235w / N3735w --- VIDEO: S-Video input [8] --- AUDIO: AV/ S-Video signal Audio input [13] N2635w --- VIDEO: S-Video input [8] --- AUDIO: AV/ S-Video signal Audio input [21] ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 16
( For China area ) ( For Hong Kong area ) ( For China area ) ( For Hong Kong area ) ( For China area ) ( For Hong Kong area ) ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 17
Press to display the Electronic Program Guide (EPG). It contains the program information for the channel you’re watching. * The picture here shows an example of the GUIDE screen in a DTV source. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 18
Press to turn the OSD (On-Screen Display) menu on. When in OSD menu, press to exit or return to the previous page. Note: As for N2635w-2M, there are no FREEZE, ZOOM, and WIDE keys. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 19
Skip Scan at this step, you can still perform channel scan in Menu. 4. The channel scanning now starts. To interrupt scanning, press MENU at any time. 5. After you complete the Initial Setup, press ENTER to exit the wizard. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 20
(It shows all or some of the information about Input, Channel, Resolution, Audio Type, etc., depending on what input source it is in) *The picture here shows an example of the INFO screen in a DTV source. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 21
2. Press ▲ or ▼ to select the required input source between TV, AV, S-Video, YPbPr 1, YPbPr 2, VGA, HDMI 1, or HDMI 2. 3. To confirm the selection, press ENTER. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 22
4. Press ▲ or ▼ to select the control with II►, such as “Color Temperature”, “Auto Adjust”, “VGA”, “Auto Scan”, “Channel Skip”, “Time Setup”, “Close Caption”, “Memory Recall”, then press ENTER or ► to perform the function or enter detailed settings. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 23
ENTER button to enter “Channel Skip” setting. 3. Press ▲ or ▼ to select the channel you want to skip, and check or uncheck it with ENTER button. 4. Press MENU to exit. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 24
To perform custom digital caption style settings, select “Digital Caption Style” to “Custom”, then use ▲ or ▼ to select desired controls, ◄ or ► to adjust detailed settings. 4. Press MENU to exit. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 25
A (all types of content) D (sexsual dialog) L (adult language) S (sexual situations) V (violence) FV (fantasy violence) 2. Press ENTER to set or reset each area. 3. Press MENU to exit. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 26
16 ans+ (not appropriate for children of less than 16 years) 18 ans+ (reserved to adults) 2. Press ENTER to set or reset the rating level. 3. Press MENU to exit. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 27
1. Press ▲ or ▼ to select “Input Block”, then press ▲ or ▼ to select the input source from which you want to block. 2. Press ENTER to block or unblock the input source. 3. Press MENU to exit. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 28
2. Press ▲ or ▼ to select the “Setup” menu. 3. Press ENTER or ► to enter “Setup” menu. 4. Press ▲ or ▼ to select “Memory Recall”, then press ENTER to restore the factory default setting. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 29
TV channels. Auto Scan: To auto scan TV and DTV channels. • Channel Skip: To skip channels. • MTS: To select audio mode. • Audio Language: To select available audio language. • ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 30
- Window Color: To select window color. - Window Opacity: To select window opacity. DCR: To turn on/off the DCR (Dynamic Contrast Ratio) • function. Memory Recall: To restore the factory default settings. • ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 31
If you forget your initial password,you can press"3660"to resume. "MENU" Lock & Un-lock: Pressing "Vol+" and "Vol-" from Front Panel Keys. "POWER" Lock & Un-lock: Pressing "Vol+" and "MENU" from Front Panel Keys. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
New advanced motion adaptive de-interlacer converts accordingly the interlace video into progressive one with overlay of a 2D Graphic processor. Advanced full function color processing with fully 10-bit path provides high quality video contents. Independent two ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 33
It incorporates a processor for system control. The processor issues instructions to control the peripheral via I²C. DDR SDRAM is externally connected to the MT538x, the unified memory allows all internal decoders can share data, which reduces external memory types and capacities. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 34
The serial audio signals that coming from MT8292 are put into MT538x for DSP and audio effect processing. The serial audio signals output from MT538x go into the MT8292 for doing digital-to-analog conversion and then put analog audio signals into the IC TFA9815. Two DAC ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 35
-127 dB to +12 dB and digital de-emphasis function. The IC TFA-9815 is a class-D amplifier that can be output power of 10Watts per channel on a 6-ohm load speaker when using a 12V power supply operation. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
4.After adjusting, switch to FULL WHITE and check the value of each color. Preset color for N3235W2M x=0.283±0.030 y=0.298±0.030 1.4.3 Power Consumption Check ( VGA MODE ) A. TIMING: 1360 x 768@60Hz ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 37
After final QC step, we must to erase all saved changes again and restore the factory defaults. You should do “Memory Recall” again. Turn off the LCD TV by pressing “Power” button. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 40
B.CHANNEL36: Check whether the color of the color bar is normal. C.CHANNEL69: Turn RF attenuator and check the critical point of the change of the image’s S/N is under LEVEL<45~85> dBu, regards as normally. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 41
16.666ms 13.328ms 16.666ms V TOTAL 12.800ms 15.880ms 12.795ms 15.880ms V DISPLAY 0.448ms 0.600ms 0.466ms 0.600ms V B-Porch 0.064ms 0.124ms 0.050ms 0.124ms Vs Width 0.000ms 0.000ms 0.000ms 0.000ms V Border H/V Sync Interlace ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 42
H B-Porch 1.310us 1.037us H Width 0.000us 0.000us H Border 16.662ms 16.661ms V TOTAL 16.097ms 16.005ms V DISPLAY 0.377ms 0.594ms V B-Porch 0.126ms 0.047ms Vs Width 0.00ms 0.00ms V Border H/V Sync Interlace ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 43
DDC Card RS-232 cable Barcode Reader VGA Cable N3235W2M LCD TV DDC Card RS-232 Cable VGA Cable Barcode Reader 2.2 Setup Procedure 2.2.1 Connect VGA Card and DDC Card with RS-232 cable. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 44
2.2.4 Connect Power Cord to N3235W2M LCD TV. 2.2.5 Press ‘MENU’and ‘ENTER’ at the same time, then go into the BURN IN MODE. 2.3 DDC Key In Procedure 2.3.1 run DDC exe 2.3.2 Choose model number the ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 45
2.3.3 Press “ENTER” key. 2.3.4 Press “F4” key and Input bar code ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 46
2.3.5 Press “ENTER” key, then the successful picture is as follows. “DDC DOWNLOED OK! 2.3.6 Exit program. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 47
3.1 Equipment Needed N3235W2M LCD TV RS-232 cable Barcode Reader HDMI Cable N3235W2M LCD TV RS-232 Cable HDMI Cable Barcode Reader 3.2 Setup Procedure 3.2.1 Connect HDMI Card and DDC Card with RS-232 cable. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 48
3.2.3 Connect DDC Card and N3235W2M LCD TV with HDMI Cable. 3.2.4 Connect Power Cord to N3235W2M LCD TV. 3.3 DDC Key In Procedure 3.3.1 Run DDC.exe 3.3.2 Choose model number then ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 49
3.3.3 Press “ENTER” key. 3.3.4 Press “F4” key. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 50
3.3.5 Input bar code 3.3.6 Press “ENTER” key, then the successful picture is as follows. “DDC DOWNLOED 3.3.7 Exit program ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 51
USB Device detected and follow Windows comments to finish the Driver install. 4.4 Execute the Mtktool to start download the file. The Mtktool program will be upgraded if necessary. "MtkTool Auto BaudRate.exe" 4.5 The Mtktool Operat 4.5.1 Select Platform : MT538X ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 52
4.5.2 Select COM port. Depends on the COM port assigned in System Device Manager (Refer below right). 4.5.3 Select Baud Rate. 115200x 8 (Suggestion) ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 53
4.5.4 Enable the USB Bridge. 4.5.5 Browsing the File to download. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 54
2. You can slow down the baud rate if some Flash memory can not works properly in high-speed download. 3. Please call the Media Tek contact window if any problem found like unsupported Flash Type or fail to download. ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 55
1.4 Place the LCD TV into the carton and then Put the other cushions on the LCD TV, put all the accessories into the carton. At last, close the carton and seal it with tape. (Figure 4) 1.Power Cord 2.User’s Guide 3.Remote control 4.Guarant Card 5.Battery Figure 3 Figure 4 ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 57
Rear Cover 2. Disassembly of Main Board , Power Board , Switch Board ,Key Pad Board , IR Board ,Front Cover and Panel Unit. 2.1 Unscrew 11 screws to remove Front Cover . ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 58
Front Cover Switch Board IR Board Key Board 2.2 Unscrew 2 screws to remove Dust Cover. Dust Cover ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 59
2.3 Unscrew 14 screws to remove Shield Plate. Shield Plate 2.2. Unscrew 19 screws to remove METAL FITTG-I/O-Down. METAL FITTG-I/O-Down ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 60
2.4. Unscrew 4 screws and disconnect the wires to remove Main Board. Main Board 2.5. Unscrew 5 screws and disconnect the wires to remove Power Board. Power Board ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
Page 61
2.6. Unscrew 4 screws to remove Panel Bracket and Panel Unit Panel Bracket Panel Unit ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
11.3K/1% POWER +1V2 FOR MT5380 (ANALOG) C520 FP6736 R0402 33nF SOT-23-6 C0402 Vout = 1.25 x ( 1 + Rb / Ra ) GNDPAD8X GNDPAD8X GNDPAD8X POWER SUPPLY +30V FOR SAMSUNG TUNER ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...
All revised RSPLs with newly added items or any change made should be highlighted and correlated with the ECN/ECR approved by ViewSonic Corporation. This is to eliminate repeated cross checks of each item between this version and prior versions. ViewSonic Corporation...
Page 87
BOM LIST ( N3235w-2 ) ViewSonic Model Number: VS11770-2M Rev: 1a Serial No. Prefix: QZV Item ViewSonic P/N Ref. P/N Description Location Universal number# Q'ty C103 2345710496P CS 0402/Y5V/16V 0.1u Z T CAP CHIP 2345710496P CS 0402/Y5V/16V 0.1u Z T...
Page 88
Item ViewSonic P/N Ref. P/N Description Location Universal number# Q'ty 2345710496P CS 0402/Y5V/16V 0.1u Z T CAP CHIP C264 C265 2345710496P CS 0402/Y5V/16V 0.1u Z T CAP CHIP 2345710496P CS 0402/Y5V/16V 0.1u Z T CAP CHIP C266 2345710496P CS 0402/Y5V/16V 0.1u Z T...
Page 89
Item ViewSonic P/N Ref. P/N Description Location Universal number# Q'ty 2347610696P CS 0805/Y5V/16V 10u Z T CAP CHIP C398 C399 2347610696P CS 0805/Y5V/16V 10u Z T CAP CHIP 2345122296P CS 0402/X7R/50V 2200p K T CAP CHIP C400 2347610696P CS 0805/Y5V/16V...
Page 99
2055636091P N3235W-2M VS11770-2M SMALL LABEL 6P05 1087 2055617101P 10*20 HI-POT TESTED OK LABEL 6P13 1088 M-LB-0813-0530 6P50 2055135398P N3235W-2M VS11770-2M CMO USA LABEL 1089 2028557202P ABS 94HB BLACK NECK 5B01 1090 HW-00008151 2071875401P JC328VE SECC T=1.2 STAND BRACKET FIX 5B02...
Page 100
Company: Add: Tel: Fax: E-mail: After completing this form, please return it to ViewSonic Quality Assurance in the USA at facsimile 1-909-839-7943. You may also e-mail any suggestions to the Director, Quality Systems & Processes (marc.maupin@viewsonic.com) ViewSonic Corporation N3235w-2M Confidential - Do Not Copy...