Changing The Brake Fluid; Checking The Front Brake Lever Free Play - Yamaha YFM35RX Owner's Manual

G
Be careful that water does not enter the brake
fluid reservoir when refilling. Water will signifi-
cantly lower the boiling point of the fluid and may
result in vapor lock.
G
Brake fluid may deteriorate painted surfaces or
plastic parts. Always clean up spilled fluid imme-
diately.
G
As the brake pads wear, it is normal for the brake
fluid level to gradually go down. However, if the
brake fluid level goes down suddenly, have a
Yamaha dealer check the cause.
EBU24290

Changing the brake fluid

Have a Yamaha dealer change the brake fluid at
the intervals specified in the NOTE after the peri-
8
odic maintenance and lubrication chart. In addi-
tion, have the oil seals of the master cylinders and
calipers as well as the brake hoses replaced at the
intervals listed below or whenever they are dam-
aged or leaking.
G
Oil seals: Replace every two years.
G
Brake hoses: Replace every four years.
EBU24390

Checking the front brake lever free play

The brake lever free play must be checked at the
intervals specified in the periodic maintenance and
lubrication chart. The brake lever should have a
free play of zero mm (zero in) as shown. If the free
play is incorrect, have a Yamaha dealer check the
brake system.
1. Brake lever free play
EWB02070
WARNING
Operating with improperly serviced or adjust-
ed brakes could cause loss of braking ability,
which could lead to an accident.
After servicing:
G Make sure the brakes operate smoothly and
that the free play is correct.
8-24