Mayco series concrete pump deutz bf4l914 diesel engine (152 pages)
Summary of Contents for MULTIQUIP QP2TH
Page 1
OPERATION AND PARTS MANUAL MODEL QP2TH TRASH PUMP (HONDA GX160K1QX2/GX160U1QX2/GX160UT2QX2 GASOLINE ENGINE) Revision #5 (01/29/14) To find the latest revision of this publication, visit our website at: www.multiquip.com THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
Engine Service Parts ........34-35 Terms And Conditions Of Sale — Parts ....36 NOTICE Specifications and part numbers are subject to change without notice. PAGE 4 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
All orders are treated as Standard Orders and will ship the same day if received prior to 3PM PST. WE ACCEPT ALL MAJOR CREDIT CARDS! QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 5...
COULD result in DEATH or SERIOUS INJURY. CAUTION Indicates a hazardous situation which, if not avoided, COULD result in MINOR or MODERATE INJURY. NOTICE Addresses practices not related to personal injury. PAGE 6 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
Page 7
Also, know the phone numbers of the nearest ambulance, doctor and fi re department. This information will be invaluable in the case of an emergency. QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 7...
Page 8
Allow these parts to cool comes into contact with hot engine parts or sparks from before servicing equipment. the ignition system. PAGE 8 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
Page 9
DO NOT lift machine to unnecessary heights. seek medical attention. ALWAYS tie down equipment during transport by securing the equipment with rope. QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 9...
Page 10
Recyclers and manufacturers alike promote the process of recycling metal. Using a metal recycling center promotes energy cost savings. PAGE 10 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
Discharge Line : 2 inch METERS FT 23.3 FT 16.7 FT 10 FT 3.3 FT U.S GALLONS PER MINUTE LITERS PER MINUTE Figure 2. QP2TH Performance Curve PAGE 12 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
In general always place the pump as close to the water as possible. 8,000 (2,438) 10,000 (3,048) PUMP SUPPORT The pump should always be placed on solid stationary QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 13...
PUMP COMPONENTS Figure 3 shows a typical application using the QP2TH centrifugal pump. Please note that this pump is intended for the removal of clean water. Figure 3. QP2TH Pump Application 1. Pump — The model QP2TH is a 2-inch trash pump 7.
5. Fuel Valve Lever — OPEN to let fuel flow, CLOSE to stop the flow of fuel. QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 15...
3. When refueling, be sure to use a strainer for filtration. DO NOT top-off fuel. Wipe up any spilled fuel immediately! PAGE 16 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
Remove any twists or sharp strainer above water for long periods can damage the bends from hose which may block the flow of water. pump. QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 17...
OPEN position (Figure 13) as the engine warms up. If the engine has not started repeat steps 1 through 6. Figure 9. Engine Choke Lever (Closed) PAGE 18 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
Page 19
1. Move the throttle lever quickly to the IDLE position, and place the engine ON/OFF switch in the OFF position. ALWAYS run engine at full speed while pumping. QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 19...
This prevents backflow and allows for faster priming when the engine is restarted. PAGE 20 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
Refer to the HONDA shop Manual for service procedures. 3. For commercial use, log hours of operation to determine proper maintenance intervals. NOTICE Refer to manufacturer engine manual for specific servicing instructions. PAGE 22 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
Page 23
Table 5. Engine oil capacity is 1.16 quarts (1.1 liters). DO NOT over fill. 4. Install drain bolt with sealing washer and tighten securely. Figure 21. Engine Air Cleaner Figure 20. Engine Oil (Draining) QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 23...
Page 24
5. If the spark arrester is damaged and has breaks or holes, replace with a new one. 6. Reinstall the spark arrester and muffler protector in reverse order of disassembly. Figure 22. Spark Arrester Removal PAGE 24 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
(new or used) through the discharge opening on the pump and crank the engine several times. This will prevent excessive corrosion and also keep the mechanical seal lubricated. QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 25...
Engine overheats. Exhaust or muffler clogged with carbon. Clean or replace muffler. Replace spark plug with correct Spark plug heat value incorrect? type spark plug. PAGE 26 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
Impeller does not turn: Adjust clearance by removing shim from Impeller and volute binding? pump is hard to start. behind impeller. Defective engine? See Engine Owner's Manual. QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 27...
“Remarks” Column. assembly/kit that can be purchased, or is not available for sale through Multiquip. PAGE 28 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
1....17620Z4M000 ....CAP, WITH GASKET FUEL FILLER, GX160UT2QX2 NOTICE Part numbers on this Suggested Spare Parts list may supersede/replace the part numbers shown in the following parts lists. QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 29...
PUMP ASSEMBLY PAGE 30 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
Page 31
Replacement of impeller requires two o-rings, so it is necessary to order one additional o-ring. QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 31...
Page 32
PUMP ASSEMBLY PAGE 32 — QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14)
Page 33
ENGINE, HONDA 5.5 HP ........1....S/N 2TH-3428 AND BELOW GX160U1QX2 ENGINE, HONDA 5.5 HP ........1....S/N 2TH-3429 TO 2TH-13438 GX160UT2QX2 ENGINE, HONDA 5.5 HP ........1....S/N 2TH-13439 AND ABOVE QP2TH TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #5 (01/29/14) — PAGE 33...
Page 39
QP2TE, QP2TH and QP2TZ Trash Pumps Impeller Replacement Kit The following instructions are intended to assist the user in the removal of the old style impeller and installing a new easily removable impeller. Please read all assembly instructions before installing the kit.