Preparing For Operation - North Star M165920S Owner's Manual

Position Position generator in accordance with the instructions given in "Installation
generator & Initial Set-up, Step 4: Select a Suitable Site" of this manual.
Operate outside only, on dry, level ground with adequate clearance and
ventilation.
Ground Make sure the generator is grounded in accordance with instruction given
generator in "Installation & Initial Set-up, Step 5: Grounding the Generator" of this
manual.
Perform Make sure that any regular maintenance has been performed as prescribed
scheduled in this manual in the "Maintenance & Repair" section.
maintenance as
needed
Check/add oil Check the oil level using the dipstick and add oil as needed.
Using a funnel, add oil up to the FULL mark on the dipstick with the
recommended oil type for your engine and expected ambient conditions.
(See engine Owner's Manual for oil type and capacity, and more detailed oil
check/fill instructions.)
Notes:
o Low oil shutdown feature prevents the generator from starting without
o Engine is shipped without oil. You must add oil before first use.
IMPORTANT:
Under long, continuous-run operating conditions, be prepared to:
Check/fill Check the gasoline level in the generator's tank. If needed, fill tank with
gasoline tank fresh unleaded gasoline from a portable container, after first reading the
warnings and instructions below.
Operation (cont'd)

2. Preparing for Operation

WARNING: Carbon monoxide poisoning hazard
Generators give off carbon monoxide exhaust, a poisonous gas that can
kill. You CANNOT smell it, see it, or taste it. ONLY run generator
OUTDOORS and away from air intakes. NEVER run generator inside
any enclosed or semi-enclosed spaces, including homes, garages,
basements, sheds, boxes, pick-up truck beds, RVs, or boats. These spaces
can trap poisonous gases, EVEN if you run a fan or open windows.
Carbon monoxide exhaust is given off whether you are using gasoline,
natural gas, or propane to power the generator.
WARNING: Electric shock hazard
Always ensure generator is properly grounded to prevent electrical
shock.
1. Refer to the engine owner's manual for engine maintenance instructions.
2. Make sure battery is charged. Charge as needed according to your battery
manufacturer's instructions.
WARNING: Burn hazard
Never open oil port while engine is running. Hot oil can spray over
face and body.
sufficient oil.
• Check engine oil level every time you refuel the engine.
• Change oil after the first 20 operating hours, and at least every 100
operating hours thereafter, or as directed in engine owner's manual.
23