Table of Contents
Advertisement
Maintenance
Note: Determine the left and right sides of the machine from the normal operating position.
Recommended Maintenance Schedule(s)
Maintenance Service
Interval
After the rst 2 operating
hours
Before each use or daily
Every 25 hours
Before storage
Yearly
Important: Refer to your Engine Operator's Manual for additional maintenance procedures.
Preparing for Maintenance
1. Stop the engine and wait for all moving parts to stop.
2. Disconnect the spark plug wire from the spark plug
and hook it onto the retaining post (Figure 29) before
performing any maintenance procedure.
Figure 29
1. Spark plug retaining post
3. After performing the maintenance procedure(s),
connect the spark plug wire to the spark plug.
Important: Before tipping the mower to change
the oil or replace the blade, allow the fuel tank to
run dry through normal usage. If you must tip the
mower prior to running out of fuel, use a hand fuel
pump to remove the fuel. Always tip the mower
onto its side, with the air filter up.
Maintenance Procedure
• Change the engine oil.
• Check the engine oil level.
• Ensure that the engine stops within 3 seconds after releasing the blade control
bar.
• Clean grass clippings and dirt from under the mower.
• Charge the battery.
• Empty the fuel tank before repairs as directed and before annual storage.
• Replace the air lter (more frequently in dusty operating conditions).
• Change the engine oil.
• Lubricate the wheel gears.
• Replace the blade or have it sharpened (more frequently if the edge dulls quickly).
• Refer to your Engine Operator's Manual for any additional yearly maintenance
procedures.
Tipping the mower may cause the fuel to leak.
Gasoline is flammable, explosive and can cause
personal injury.
Run the engine dry or remove the gasoline with a
hand pump; never siphon.
Replacing the Air Filter
Replace the air filter yearly; replace it more frequently in
dusty operating conditions.
1. Refer to Preparing for Maintenance.
2. Rotate the air filter cover to remove it (Figure 30).
Figure 30
3. Replace the air filter.
4. Install the cover.
12
Advertisement
Table of Contents
