Philips 32PFL3507/56 Service Manual
  1. Manuals
  2. Brands
  3. Philips Manuals
  4. TV
  5. 32PFL3507/56
  6. Service manual

Philips 32PFL3507/56 Service Manual

Chassis tpm8.31a la
Hide thumbs
Table of Contents

Advertisement

Quick Links

Colour Television
Contents
A 715G5194 PSU 32" & 37" 3500/4000 series
A 715G5173 PSU 3500 series 42" & 46"
3500 series 32"
Published by XjL/MjX/MB/SC 1266 Quality
©
2012
TP Vision Netherlands B.V.
All rights reserved. Specifications are subject to change without notice. Trademarks are the
property of Koninklijke Philips Electronics N.V. or their respective owners.
TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust
earlier supplies accordingly.
PHILIPS and the PHILIPS' Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
Page
2
2
5
9
23
25
34
39
40
41
42
Drawing PWB
43
47-48
49
52-53
54
68-69
70
71
72
73
74
75
76
Printed in the Netherlands
Chassis
TPM8.31A
Subject to modification
EN 3122 785 19320
LA
2012-Jun-08

Advertisement

Table of Contents
loading

Related Manuals for Philips 32PFL3507/56

Summary of Contents for Philips 32PFL3507/56

  • Page 1 Koninklijke Philips Electronics N.V. or their respective owners. TP Vision Netherlands B.V. reserves the right to change products at any time without being obliged to adjust earlier supplies accordingly. PHILIPS and the PHILIPS’ Shield Emblem are used under license from Koninklijke Philips Electronics N.V.
  • Page 2 & Notes: drivers. • Figures can deviate due to the different set executions. Table 2-1 Described Model Numbers and Diversity Mechanics Block Diagrams Schematics 32PFL3507/56 10.1 10.3 10.4 10.5 11.1 32PFL3507/98 10.1 10.3 10.4...
  • Page 3 Technical Specs, Diversity, and Connections TPM8.31A LA EN 3 Connections COMPONENT PC IN VIDEO OUT SPDIF SERV.U VIDEO/Y AUDIO 19320_001_120604.eps 120607 Figure 2-1 Connection overview Note: The following connector colour abbreviations are used 5 - Cinch: Video CVBS - In, Audio - In / 75 ...
  • Page 4 / 10 k - Ground - UART_TX Transmit Directions for Use - UART_RX Receive Directions for use can be downloaded from the following websites: http://www.philips.com/support http://www.p4c.philips.com Chassis Overview Refer to 9. Block Diagrams for PWB/CBA locations. back to 2012-Jun-08 div. table...
  • Page 5 Spare Parts the following points: • Route the wire trees correctly and fix them with the For the latest spare part overview, consult your Philips Spare mounted cable clamps. Part web portal. • Check the insulation of the Mains/AC Power lead for external damage.
  • Page 6 EN 6 TPM8.31A LA Precautions, Notes, and Abbreviation List result in sets which have the same CTN (Commercial Type 6 = play 16 : 9 format, 12 = play 4 : 3 Number; e.g. 28PW9515/12) but which have a different B.O.M. format number.
  • Page 7 6.5 MHz. L' is Band (VESA standard for communication I, L is all bands except for Band I channel and display). Using E-DDC, LG.Philips LCD (supplier) the video source can read the EDID Loudspeaker information form the display.
  • Page 8 SOPS Self Oscillating Power Supply Serial Peripheral Interface bus; a 4-wire synchronous serial data link standard S/PDIF Sony Philips Digital InterFace SRAM Static RAM Service Reference Protocol Small Signal Board Spread Spectrum Clocking, used to reduce the effects of EMI...
  • Page 9 Mechanical Instructions TPM8.31A LA EN 9 4. Mechanical Instructions Index of this chapter: Notes: 4.1 Cable Dressing • Figures below can deviate slightly from the actual situation, 4.2 Service Positions due to the different set executions. 4.3 Assembly/Panel Removal 4.4 Set Re-assembly Cable Dressing 19320_100_120608.eps 120530...
  • Page 10 EN 10 TPM8.31A LA Mechanical Instructions 19320_101_120608.eps 120530 Figure 4-2 Cable dressing 42" 19320_102_120608.eps 120530 Figure 4-3 Cable dressing 46" back to 2012-Jun-08 div. table...
  • Page 11 Mechanical Instructions TPM8.31A LA EN 11 Service Positions care that these always support the cabinet and never only the For easy servicing of a TV set, the set should be put face down display. Caution: Failure to follow these guidelines can on a soft flat surface, foam buffers or other specific workshop seriously damage the display! tools.
  • Page 12 EN 12 TPM8.31A LA Mechanical Instructions 4.3.3 Small Signal Board (SSB) 4.3.8 LCD Panel Refer to Figure 4-5 for details. 1. Remove the SSB, PSU, Keyboard control panel and Caution: it is mandatory to remount all different screws at their speakers as described earlier.
  • Page 13 Service Modes, Error Codes, and Fault Finding TPM8.31A LA EN 13 5. Service Modes, Error Codes, and Fault Finding Index of this chapter: Life Timer 5.1 Test Points During the life time cycle of the TV set, a timer is kept (called 5.2 Service Modes “Op.
  • Page 14 EN 14 TPM8.31A LA Service Modes, Error Codes, and Fault Finding – Automatic user menu time-out (menu switches controls will not have I+ button, but an “INFO” button back/OFF automatically. instead. – Auto Volume levelling (AVL). How to Exit SDM How to Activate SDM •...
  • Page 15 Service Modes, Error Codes, and Fault Finding TPM8.31A LA EN 15 Main Menu Sub-menu 1 Sub-menu 2 Description Initialize NVM Press [OK] to Initialize NVM To initialize a (corrupted) NVM. Be careful, this will erase all settings. immediately EDID Write Enable Press [OK] to enable EDID Enable EDID writable writable immediately...
  • Page 16 EN 16 TPM8.31A LA Service Modes, Error Codes, and Fault Finding Default value Item Item value 32" 42" 46" Description ADC_GAIN_B Blue ADC gain ADC_OFFSET_R Red ADC offset ADC_OFFSET_G Green ADC offset ADC_OFFSET_B Blue ADC offset GAMMA_TABLE GAMMA_TABLE E-Fuse E-fuse mode ORT_MODE ORT mode RESET_PBS_PWD...
  • Page 17 Service Modes, Error Codes, and Fault Finding TPM8.31A LA EN 17 5.2.5 Customer Service Mode (CSM) customer wants to make use of the HDMI functionality, the SSB has to be replaced. Purpose The Customer Service Mode shows error codes and How to Navigate information on the TV’s operation settings.The call centre can By means of the “CURSOR-DOWN/UP”...
  • Page 18 EN 18 TPM8.31A LA Service Modes, Error Codes, and Fault Finding Stepwise Start-up Standby Soft Mode Command Received, Switch previously in Standby Off(Mains Soft Mode (Power tact Standby Power Plug) switch) Digital Digital background background tasks started tasks completed TV Wakeup commands Received Standby...
  • Page 19 A description on how to upgrade the main 1. ComPair helps to quickly get an understanding on how to software can be found in the DFU or on the Philips website. repair the chassis in a short and effective way.
  • Page 20 EN 20 TPM8.31A LA Service Modes, Error Codes, and Fault Finding • FUS_clustername_version.zip: Contains the “autorun.upg” which is needed to upgrade the TV main software and the software download application. • NVM_clustername_version.zip: Default NVM content. Must be programmed via ComPair. 5.5.7 How to Copy NVM Data to/from USB When copying data to and from a USB memory stick, the folder...
  • Page 21 Service Modes, Error Codes, and Fault Finding TPM8.31A LA EN 21 – ERROR: 034 013 000 000 000: Error code 13 was Fault Finding and Repair Tips detected first and error code 34 is the last detected Note: (newest) error •...
  • Page 22 EN 22 TPM8.31A LA Service Modes, Error Codes, and Fault Finding 5.8.10 Display option code Attention: In case the SSB is replaced, always check the Panel Code in CSM, even when picture is available. Performance with the incorrect display option code can lead to unwanted side-effects for certain conditions.
  • Page 23 Alignments TPM8.31A LA EN 23 6. Alignments Index of this chapter: In case you have a colour analyser: 6.1 General Alignment Conditions • Measure with a calibrated (phosphor- independent) color 6.2 Hardware Alignments analyser (e.g. Minolta CA-210) in the centre of the screen. 6.3 Software Alignments Consequently, the measurement needs to be done in a 6.4 Option Settings...
  • Page 24 EN 24 TPM8.31A LA Alignments Option Settings 6.5.1 SSB Indentification 6.4.1 Introduction SSB’s of this chassis are identified by a “715” code on the SSB. 715Axxxx-Nnn-MMM-OOOO • 715 main category, Printed Wiring Board The microprocessor communicates with a large number of I •...
  • Page 25 Circuit Descriptions TPM8.31A LA EN 25 7. Circuit Descriptions Index of this chapter: 7.1 Introduction 7.2 Power Supply 7.3 SSB Power Management 7.4 Circuit Description 7.5 Front-End Analogue and reception 7.6 HDMI 7.7 Video and Audio Processing - MT5301B Notes: •...
  • Page 26 EN 26 TPM8.31A LA Circuit Descriptions 7.1.3 SSB Cell Layout AUDIO CLASS DC/DC AV OUT TUNER AV IN MT5301B HDMI DDR2 Analog Input SPDIF Video IN SPDIF Component 19320_200_120608.eps 120530 Figure 7-1 SSB layout cells (top view) back to 2012-Jun-08 div.
  • Page 27 This part is available in The following displays can be distinguished: the regular market. • CCFL/EEFL backlight: power board is a conventional IPB Consult the Philips Service web portal for the order codes of the • LED backlight: boards. –...
  • Page 28 EN 28 TPM8.31A LA Circuit Descriptions 7.2.3 Connector overview Connector 32PFL3507 42PFL3507 46PFL3507 Connector number CN8101 CN9302 CN8501 CN8502 CN902 CN8502 CN902 Description to panel to SSB to panel to panel to SSB to panel to SSB VLED P_OK VLED VLED P_OK VLED...
  • Page 29 Circuit Descriptions TPM8.31A LA EN 29 • +5V-STANDBY, permanent voltage for the Stand-by controller, LED/IR receiver and controls; connector CN701 DVDD3V3 pin 11 and 12. U403 R473 NC28 4K7 1/16W 5% • +12V, input from the power supply for panel and tuner; NC27 NC26 R472...
  • Page 30 EN 30 TPM8.31A LA Circuit Descriptions 7.4.3 NVM (U405) 3V3SB 5VSB The system NVM is a 128 KB IC. It contains all system settings. 3V3SB R469 0R05 1/16W R470 NC 1K 1/10W 1% CN402 DVDD3V3 NC CONN R467 NC\5K1 1/16W 5% 5VSB R461 R462...
  • Page 31 Circuit Descriptions TPM8.31A LA EN 31 G9084TU3U +12V FB1102 TO-263T U7007 R1176 5V_TUNER R1175 15 OHM +-5% 1/4W VOUT 0R05 1/4W 120R/3000mA R1171 15 OHM +-5% 1/4W C1164 R1173 R1172 15 OHM +-5% 1/4W C1141 C1144 C1162 C1163 1K 1/10W 1% 100N 16V 100N 16V 100N 16V...
  • Page 32 EN 32 TPM8.31A LA Circuit Descriptions 7.4.8 Audio Mute circuit This circuit will provide a “high-to-low” pulse when the +5 V SSB power line goes low. This will trigger the related audio mute circuit, preventing the audio circuit making uncontrolled sounds.
  • Page 33 Circuit Descriptions TPM8.31A LA EN 33 HDMI In this platform, the TMDS361B HDMI multiplexer is implemented. It supports up to 3 HDMI ports to be switched to a single SOC. In this chassis 2 HDMI ports are implemented. Refer to figure 7-14 HDMI input configuration for the application.
  • Page 34 EN 34 TPM8.31A LA IC Data Sheets 8. IC Data Sheets This chapter shows the internal block diagrams and pin configurations of ICs that are drawn as “black boxes” in the electrical diagrams (with the exception of “memory” and “logic” ICs).
  • Page 35 IC Data Sheets TPM8.31A LA EN 35 Pinning information FSRC_WR 192 AVDD33_XTAL_STB GPIO14 191 XTALI VCC3IO 190 XTALO AVDD12_VPLL 189 AVDD33_DEMOD AE5P 188 AVSS33_DEMOD AE5N 187 AVSS12_DEMOD AE4P 186 AVDD33_IFPGA AE4N 185 ADCINN_DEMOD AE3P 184 ADCINP_DEMOD AE3N 183 AVDD12_DEMOD AECKP 182 AVDD33_CVBS AECKN 181 CVBS0P...
  • Page 36 EN 36 TPM8.31A LA IC Data Sheets Diagram 10-3-14 Audio Amplifier & Headphone Out B14, STA339BWTR (IC U602) Block diagram Protection current/thermal Channel interface Channel Logic Power control Volume control Channel STA339BW Regulators Channel Bias Digital DSP Power Pinning information GND_SUB VDD_DIG GND_DIG...
  • Page 37 IC Data Sheets TPM8.31A LA EN 37 Diagram 10-3-14 Audio Amplifier & Headphone Out B14, STA515W13TR (IC U603) Block diagram STA515W13TR LeftA INL[1:2] OUTPL ‰ -Bridge INR[1:2] Logic I/F and Decode LeftB PWRDN OUTNL ‰-Bridge TRI-STATE Protection RightA FAULT OUTPR Circuitry TWARN ‰...
  • Page 38 EN 38 TPM8.31A LA IC Data Sheets Diagram 10-3-5 HDMI & HDMI Switch B05, TMDS361BPAGR (IC U501) Block diagram Dx+_1 TMDS Rx w/ AEQ Dx–_1 CLK+_1 TMDS Rx CLK–_1 Clock Detect VSadj SCL1 Dx+_SINK TMDS Tx Dx–_SINK SDA1 CLK+_SINK TMDS Tx CLK–_SINK Dx+_3 TMDS Rx...
  • Page 39 Block Diagrams TPM8.31A LA EN 39 9. Block Diagrams Wiring diagram 3500 32" WIRING DIAGRAM 32" (3500) Board Level Repair Component Level Repair Only for authorized workshops to panel CN8101 CN701 MAIN POWER SUPPLY (1054) (1053) CN01 COMPONENT PC IN VIDEO OUT SPDIF SERV.U...
  • Page 40 Block Diagrams TPM8.31A LA EN 40 Wiring diagram 3500 42" WIRING DIAGRAM 42" (3500) Board Level Repair Component Level Repair Only for authorized workshops TO PANEL CN8501 CN8502 CN701 MAIN POWER SUPPLY (1054) (1053) CN901 CN01 COMPONENT PC IN VIDEO OUT SPDIF SERV.U VIDEO/Y...
  • Page 41 Block Diagrams TPM8.31A LA EN 41 Wiring diagram 3500 46" WIRING DIAGRAM 46" (3500) Board Level Repair Component Level Repair Only for authorized workshops CN8502 MAIN POWER SUPPLY CN701 (1054) (1053) CN01 CN901 COMPONENT PC IN VIDEO OUT SPDIF SERV.U VIDEO/Y AUDIO TO PANEL...
  • Page 42 Block Diagrams TPM8.31A LA EN 42 Block Diagram 3500 SPI FLASH NAND FLASH DDR2 1 Gb 64 Mb 256 Mb LCD PANEL T-CON LVDS (50/60 Hz) Analog IF+/- ATV _RF TUNER DEMOD F86WT-17-E PC IN 24C02 YPbPr CVBS VIDEO ( By CVI Y connector) MT5301B HDMI 1.3 HDMI1...
  • Page 43 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 43 10. Circuit Diagrams and PWB Layouts 10.1 A 715G5194 PSU 32" & 37" 3500/4000 series 10-1-1 AC Side AC Side F9902 FB9901 T4.0AH/250V SG9901 C9905 SG9903 NR9902 SPG-201M-LF 470PF 250V SPG-201M-LF BEAD COLD FUSE-NC...
  • Page 44 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 44 10-1-2 IC8102 COMP C8119 1UF 16V COMP D8102 L8102 +12V2 ISET +24V1 VLED R8101 LED2 10K 1/8W 1% PF7700S C8108 L8101 SR510-22 150UF 35V 25UH R8121 C8125 R8120 100K R8122 C8109 R8109 12UF 160V 100K...
  • Page 45 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 45 10-1-3 Main Power Main Power B+_main COLD R9104 R9147 100 OHM 1/4W 2Mohm 1/4W +/-1%-NC R9103 100 OHM 1/4W B+_main R9105 +12V R9148 100 OHM 1/4W 2Mohm 1/4W +/-1%-NC +12V1 T9101 C9108 C9103 D9102...
  • Page 46 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 46 10-1-4 Standby Standby FB9304 C9137 C9139 CN9301 CN9303 BEAD +24V 470PF 250V-NC 220PF 250V COLD R9319 D9306 47 OHM 1/4W SJPW-T4VL-NC C9301 B+_main R9303 1.5NF FB9301 0.1R 47 OHM 1/4W R9302 R9304 BEAD 47 OHM 1/4W...
  • Page 47 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 47 10-1-5 Power layout top GND4 GND3 CN9301 CN8101 CN8102 L8102 CN9303 D8102 J937 J924 J938 J925 C8128 C8125 L8101 J939 C9101 J940 J927 R8116 C8132 J928 C8129 L9102 C8108 L9101 C9107 ZD9107 J922 J951...
  • Page 48 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 48 10-1-6 Power layout bottom R8121 R9141 R9143 C9111 R9140 RJ911 R8106 R9139 R8107 R8110 R9144 R8103 R8118 R9145 R8124 R8123 R9142 R9324 R9146 RJ905 R9165 R9138 R9166 R8109 R8112 R8101 R9159 R8104 R8134 R9161...
  • Page 49 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 49 10.2 A 715G5173 PSU 3500 series 42" & 46" 10-2-1 A01 Power circuit Power circuit D9802 IN5408G-10 FB9801 RV9902 BEAD R9330 TVR14561KFAOZF R9329 T9301 47 OHM 1/4W D9801 C9172 0.47R R9331 L9801 FMNS-1106S 2.2nF 630V...
  • Page 50 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 50 10-2-2 A02 2.24 V to VLED (DC/DC) 2.24 V to VLED (DC/DC) 24V-LED VLED D8120 MBRF10150CT R8154 R8155 C8118 C8108 100K 100K R8156 L8101 100UF 100V 100UF 100V 100K 25UH Q8101 R8145 TK25A10K3 220K +-1% 1/4W...
  • Page 51 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 51 10-2-3 A03 LED Driver LED Driver IC8501 IC8502 IC8503 LED-COMP COMP COMP LED-COMP COMP LED-COMP 12V_LED ISET LED-1 12V_LED ISET 12V_LED ISET R8501 LED-6 LED-2 C8501 R8502 R8503 5K6 +-1% 1/8W C8502 C8503 PF7700S...
  • Page 52 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 52 10-2-4 Power layout top GND4 GND3 H9801 CN8504 CN8503 J8501 J8106 CN8501 CN8502 J8503 HS9101 L8101 J9117 J8508 J8509 J8512 H9803 H9802 H9804 D8120 Q8101 H9805 J8522 J8521 C8121 J8525 J9105 J9118 J8528 J9114...
  • Page 53 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 53 10-2-5 Power layout bottom R8147 R8145 R8144 R8141 IC8501 C8106 C8122 ZD8103 MH9808 C8119 C8123 R8148 C8124 MH9809 IC8103 C8113 C8111 C8517 RJ8101 R8163 IC8509 C8105 IC8515 IC8507 IC8504 IC8503 R8158 D8118 R8161 R9172...
  • Page 54 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 54 10.3 B 715G4611 SSB 10-3-1 PSU & Inverter Interface PSU & Inverter Interface Brightness Adjust 5V_SW 3V3_BUCK DVDD3V3 R708 R709 NC\2.2K 1/16W 1K 1/16W 5% R746 4K7 1/16W 5% R710 BRI_ADJ 0R05 1/16W R752 C708...
  • Page 55 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 55 10-3-2 DC-DC BUCK & LDO Regulator DC-DC BUCK & LDO Regulator 4,6,7,8,9,10,11,12,13,14,15,16,17,18,19,20,21,22 Power MOSFET Switch 5V_SW OPWRSB OPWRSB 3V3 Main Power : 3V3_BUCK 5VSB 5V_SW FB707 FB715 DVDD3V3 System Power Control 3V3_BUCK FB716 120R/6000mA...
  • Page 56 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 56 10-3-3 VGA & PC Line-in VGA & PC Line-in 4,5,7,8,9,10 ,11 ,12 ,13 ,14 ,15 ,16 ,17 ,18 ,19 ,20 ,21 ,22 30R/700mA FB108 R158 68R 1/16W 5% C118 10N 50V VGA Input VGA SYNC Slicer V GA COM...
  • Page 57 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 57 10-3-4 CVI, AV (side) & Audio-in Multiplexer CVI, AV (side) & Audio-in Multiplexer 4,5,6,8,9,10,11,12,13,14,15,16,17,18,19,20,21,22 CVBS R214 R214 R213 R213 C155 C155 CVBS AV2_CVBS CVI_R_IN1 CVI_R_IN1 0R05 1/16W 0R05 1/16W C156 C156 68R 1/16W 5% 68R 1/16W 5% 47nF 16V...
  • Page 58 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 58 10-3-5 HDMI & HDMI Switch HDMI & HDMI Switch 5V_SW HD5V_A 4,5,6,7,9,10,11,12,13,14,15,16,17,18,19,20,21,22 5V_SW 5VDD HDMI A FB501 FB501 R514 R514 1K 1/16W 5% 1K 1/16W 5% PWR5V_A 5VDD RX1_CB M_RX1_CB 120R/3000mA 120R/3000mA RX1_C M_RX1_C...
  • Page 59 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 59 10-3-6 Half NIM Tuner Half NIM Tuner FB720 FB720 FB724 FB724 G9084TU3U +12V FB1102 FB1102 TO-263T U7007 U7007 R1176 R1176 5V_TUNER NC\120R/3000mA NC\120R/3000mA NC\120R/3000mA NC\120R/3000mA R1175 R1175 15 OHM +-5% 1/4W 15 OHM +-5% 1/4W L1102 L1102...
  • Page 60 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 60 10-3-7 USB1 & USB2 USB1 & USB2 5V_USB 5V_SW VUSB_5V NC\120R/3000mA NC\120R/3000mA FB307 FB307 4,5,6,7,8,9,10,12,13,14,15,16,17,18,19,20,21,22 C311 C311 10U 16V 10U 16V USB_DM1 USB_DM1 USB_DP1 USB_DP1 USB_PWR_OCP1 USB_PWR_OCP1 12 USB_DM0 USB1 USB_DM0 VUSB_5V USB_DP0 USB_DP0...
  • Page 61 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 61 10-3-8 MT5301B MT5301B 4,5,6,7,8,9,10,11,13,14,15,16,17,18,19,20,21,22 DDRV DRAM IO Power DDRV C412 C412 C406 C406 C407 C407 C408 C408 C409 C409 C410 C410 C411 C411 10U 10V 10U 10V 100N16V 100N16V 100N16V 100N16V 100N16V 100N16V 100N16V...
  • Page 62 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 62 10-3-9 SoC Peripheral SoC Peripheral DVDD3V3 NOR Flash Strapping 3V3SB 3V3SB DVDD3V3 DVDD3V3 R456 R456 R455 R455 R474 R474 R476 R476 R478 R478 4K7 1/16W 5% 4K7 1/16W 5% NC\4K7 1/16W 5% NC\4K7 1/16W 5% U404 U404...
  • Page 63 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 63 10-3-10 DDR2 DDR2 4,5,6,7,8,9,10,11,12,13,15,16,17,18,19,20,21,22 DDR2#1-64Mx16-1066MHz U402 U402 RDQ0 RDQ0 RDQ1 RDQ1 RDQ0 B_A0 RDQ2 RDQ2 RDQ1 B_A1 RDQ3 RDQ3 Damping & Termination for CLK RDQ2 B_A2 RDQ4 RDQ4 RDQ3 B_A3 RDQ5 RDQ5 RDQ4 B_A4...
  • Page 64 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 64 10-3-11 LVDS, JTAG & UART LVDS, JTAG & UART 4,5,6,7,8,9,10,11,12,13,14,16,17,18,19,20,21,22 LVDSVDD FHD 8/10-Bit LVDS Connector >=26" FB105 FB105 JTAG (ICE) Debug TX_AE0P TX_AE0P TX_AE0N TX_AE0N Panel_12V_5V TX_AE1P TX_AE1P 120R/6000mA 120R/6000mA TX_AE1N TX_AE1N C113 C113...
  • Page 65 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 65 10-3-12 IR & Keypad Interface IR & Keypad Interface 4,5,6,7,8,9,10,11,12,13,14,15,17,18,19,20,21,22 3V3SB_2 R201 R201 LED_RED_OFF# LED_RED_OFF# 12 5VSB 5VSB_2 3V3SB 3V3SB_2 1MOHM 1/16W +/-5% 1MOHM 1/16W +/-5% FB201 FB201 FB202 FB202 R202 R202 ADC_KEY OIRI...
  • Page 66 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 66 10-3-13 AV Out & SPDIF Out AV Out & SPDIF Out CVBS OUT AV_OUT (CVBS +R/L) RCA JACK RCA JACK L101 L101 MONITOR_OUT R191 R191 0R05 1/16W 0R05 1/16W R193 R193 0R05 1/16W 0R05 1/16W 1.8 uH...
  • Page 67 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 67 10-3-14 Audio Amplifier & Headphone Out Audio Amplifier & Headphone Out +24V NC\PMBS3904 NC\PMBS3904 R720 R720 R721 R721 Q705 Q705 NC\56KOHM 1/16W NC\56KOHM 1/16W R719 R719 NC\56KOHM 1/16W NC\56KOHM 1/16W R722 R722 NC\10K 1/16W 5% NC\10K 1/16W 5%...
  • Page 68 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 68 10-3-15 SSB layout top CN701 C736 C732 C669 C311 C640 R735 C733 FB613 R635 C621 R710 FB725 D304 R636 R708 C731 R626 R318 R709 U703 Q702 R317 C7006 D303 Q703 C7005 U602 C7004 C620...
  • Page 69 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 69 10-3-16 SSB layout bottom C625 C623 C643 C641 C661 C675 C660 C676 C1115 C1112 C1122 C1118 C1117 C1120 C1116 C1113 R1189 R1187 R1138 Q1104 R1139 R1169 C444 R458 U404 R460 R456 R459 R457 C452...
  • Page 70 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 70 10.4 J 715G5471 IR/LED 3500 series 10-4-1 IR/LED Board IR/LED panel LED201 033G8032 5F HR LED_R R202 220 OHM 1/10W BLUE LED_B R203 220 OHM 1/10W CN201 U201 R201 15K 1/10W IRM-H638M3/TR2 C201 CONN...
  • Page 71 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 71 10-4-2 IR/LED Board layout Layout IR/LED Board (Top Side) Layout IR/LED Board (Bottom Side) 2012-02-01 IR/LED board 715G5471 layout top/bottom 19320_512_120608.eps 120530 back to 2012-Jun-08 div. table...
  • Page 72 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 72 10.5 E 715G5298 Keyboard 3500 series 10-5-1 Keyboard Keyboard SW01 VOL+ TACT SW FWRD H1.5MM 7K5 1/8W +/-1% SW02 VOL- TACT SW FWRD H1.5MM 2K7 1/8W 1% SW03 TACT SW FWRD H1.5MM 1K8 +/-1% 1/8W CN01 SW04...
  • Page 73 Circuit Diagrams and PWB Layouts TPM8.31A LA EN 73 10-5-2 Keyboard layout Layout Keyboard (Top Side) CN01 Layout Keyboard (Bottom Side) 2011-09-02 Keyboard 715G5298 layout top/bottom 19320_514_120608.eps 120606 back to 2012-Jun-08 div. table...
  • Page 74 Styling Sheets TPM8.31A LA EN 74 11. Styling Sheets 11.1 3500 series 32" 3500 series 32" 1053 1050 0041 1057 0031 1054 1185 0050 1185 0030 1056 Pos No. Description Remarks 0030 Base assembly 0031 Front bezel 0041 Rear cover 0050 Cover stand 1050...
  • Page 75 Styling Sheets TPM8.31A LA EN 75 11.2 3500 series 42" 3500 series 42" 1053 1054 0041 0031 1185 0030 1185 1050 1057 1056 Pos No. Description Remarks 0030 Base assembly 0031 Front bezel 0041 Rear cover 1050 Display panel 1053 Panel SSB 1054 Power Supply Unit...
  • Page 76 Styling Sheets TPM8.31A LA EN 76 11.3 3500 series 46" 3500 series 46" 1053 1054 0041 0031 1185 0030 1185 1050 1057 Pos No. Description Remarks 0030 Base assembly 1056 0031 Front bezel 0041 Rear cover 1050 Display panel 1053 Panel SSB 1054 Power Supply Unit...

This manual is also suitable for:

32pfl3507/9832pfl35075/9842pfl3507/5642pfl3507/9842pfl3507s/9846pfl3507/56 ... Show all

Table of Contents