Power Steering Oil And Oil Filter; Air Bleeding Of Steering Unit - Daewoo Novus M2SEF Manual

Caution
When topping up the oil tank, ensure the
strainer is installed in the filler port. Replen-
ishing oil through the filler port without
strainer will cause foreign matters to come in
the tank.
https://www.truck-manuals.net/
MAX
MIN
MTB0120
MTC0080
MAX
MIN
MTC0090
3-72 INSPECTION AND MAINTENANCE

6) Power steering oil and oil filter

(1) Oil level check
At end of first 1,000km and thereafter every
4,000km operation, keep the front wheels
straight ahead and check oil level with level
mark on oil tank.
(2) Type of oil
Specifications: ATF(DEXRON II-D)
(3) Oil change
Change oil at end of first 1,000km and thereaf-
ter every 48,000km for new vehicle.
Tank capacity
*
•
4x2, 6x4 series : 6L
•
8x4, 10x4 series : 7.3L
•
24ton dump truck : 9L
1. To drain the steering oil, jack up the front
wheels to raise from the ground with the
engine stopped, loosen the two joint bolts
fitted to the upper face of steering unit and
turn the steering wheel slowly in both
direction.
2. Tighten the joint bolts securely and fill the
oil tank to the specified level with the
specifed fluid.
3. After 2~3 minutes, lower the front wheels to
ground, and idle the engine for 2~3 minutes.
4. Recheck the oil level while the engine is
idling and replenish as necessary.
5. After filling, if unusual sound is heard when
the steering wheel is turned, perform air-
bleeding operation.

(4) Air bleeding of steering unit

1. After stopping the engine, jack up the front
wheels clear of the ground and remove the
air bleeder cap installed on the upper face of
the steering unit.