Perkins 5006A-E23TA Operation And Maintenance Manual page 96

96
Index Section
Engine Storage................................................ 28
Level "A" ...................................................... 28
Level "B" ...................................................... 28
Level "C" ..................................................... 28
Engine Valve Lash - Inspect/Adjust (Valves
and Valve Bridges) ........................................ 77
F
Fan Drive Pulley - Check (5008-30 Engine
Only) .............................................................. 77
Fault Logging................................................... 37
Features and Controls..................................... 31
Fire Prevention and Explosion Prevention...... 15
Ether ............................................................ 16
Fire Extinguisher.......................................... 16
Lines, Tubes, and Hoses ............................. 17
Fluid Recommendations (Engine Oil
Specification) ................................................. 48
Engine Oil .................................................... 48
General Lubricant Information..................... 48
Fluid Recommendations (General Coolant
Information) ................................................... 45
General Coolant Information ....................... 45
Fluid Recommendations (General Fuel
Information) ................................................... 48
Refill Capacities for the Fuel System........... 48
Foreword ........................................................... 4
California Proposition 65 Warning ................. 4
Literature Information .................................... 4
Maintenance .................................................. 4
Maintenance Intervals ................................... 5
Operation ....................................................... 4
Overhaul ........................................................ 5
Safety............................................................. 4
Fuel and the Effect from Cold Weather ........... 43
Fuel Conservation Practices ........................... 41
Fuel Injector - Inspect/Adjust........................... 78
Fuel Injector - Replace .................................... 78
Fuel Related Components in Cold Weather ... 43
Fuel Heaters ................................................ 43
Fuel Tanks ................................................... 43
Fuel System - Prime ........................................ 78
Fuel System Primary Filter - Replace ............. 79
Fuel System Primary Filter/Water
Separator - Drain ........................................... 80
Fuel System Secondary Filter - Replace ........ 81
Fuel Tank Water and Sediment - Drain ........... 82
Drain the Water and the Sediment .............. 82
Fuel Storage Tanks...................................... 82
Fuel Tank ..................................................... 82
Fuel Transfer Pump (Lift Pump) - Inspect ....... 82
G
General Hazard Information............................ 10
Containing Fluid Spillage............................. 12
Dispose of Waste Properly .......................... 14
Fluid Penetration ......................................... 12
Inhalation ..................................................... 13
Pressurized Air and Water........................... 12
Static Electricity Hazard when Fueling with
Ultra-low Sulfur Diesel Fuel ....................... 12
H
Hoses and Clamps - Inspect/Replace............. 82
Clamps and V-Band Clamp Torques ........... 89
Clamps and V-Band Locations For 6 Cylinder
Engines ...................................................... 84
Clamps and V-Band Locations For 8 Cylinder
Engines ...................................................... 87
Replace the Hoses and the Clamps ............ 83
I
Important Safety Information............................. 2
J
Jacket Water Heater - Check (If Equipped) .... 89
L
Lifting and Storage .......................................... 28
M
Maintenance Interval Schedule....................... 52
Maintenance Interval Schedule (Engines in
Standby Applications)
Daily or Prior to Starting Stand-by Unit........ 52
Every 1000 Service Hours or 2 Years ......... 52
Every 1500 Service Hours........................... 52
Every 2000 Service Hours........................... 53
Every 4000 Service Hours........................... 53
Every 5 Years............................................... 53
Every 50 Service Hours ............................... 52
Every 500 Service Hours or 2 Years or Prior to
Functional Load Test.................................. 52
Every 6000 Service Hours or 3 Years ......... 53
When Required............................................ 52
Maintenance Recommendations .................... 51
Maintenance Section....................................... 45
M0122761