Table of Contents
Advertisement
Quick Links
The''e-SPEC''mark symbolizes environmentally
responsible technologies applied to Honda power
equipment, which contains our wish to ''preserve
nature for generations to come.''
00X4M-Z30-6000̲EG5000CX̲トビラ.indd1 1
00X4M-Z30-6000̲EG5000CX̲トビラ.indd1 1
EG4000CX · EG5000CX
Honda
EU20i
EG6500CX · EG6500CXS
OWNER'S MANUAL
Original instructions
MANUEL DE L'UTILISATEUR
MANUAL DE EXPLICACIONES
Manual original
Notice originale
BEDIENUNGSANLEITUNG
Originalbetriebsanleitung
MANUAL DE EXPLICACIONES
Manual original
2010/08/25 9:42:55
2010/08/25 9:42:55
Advertisement
Table of Contents
Related Manuals for Honda EG4000CX
Summary of Contents for Honda EG4000CX
- Page 1 MANUEL DE L’UTILISATEUR MANUAL DE EXPLICACIONES Notice originale Manual original BEDIENUNGSANLEITUNG Originalbetriebsanleitung MANUAL DE EXPLICACIONES Manual original The‘‘e-SPEC’’mark symbolizes environmentally responsible technologies applied to Honda power equipment, which contains our wish to ‘‘preserve nature for generations to come.’’ 00X4M-Z30-6000̲EG5000CX̲トビラ.indd1 1 00X4M-Z30-6000̲EG5000CX̲トビラ.indd1 1 2010/08/25 9:42:55 2010/08/25 9:42:55...
- Page 2 10/07/13 15:27:19 42Z30600_002...
-
Page 3: Table Of Contents
10/07/13 15:27:23 42Z30600_003 CONTENTS SAFETY ....................... PRE-OPERATION CHECK ................ENGINE OIL LEVEL ................. FUEL LEVEL ..................... AIR CLEANER ..................BATTERY SERVICE (electric starter type only) ........STARTING THE ENGINE ................Oil Alert System ..................Automatic Engine Stop Function ............Oil Alert Function ................ -
Page 4: Safety
10/07/13 15:27:43 42Z30600_004 SAFETY DO NOT USE INSIDE HOUSE! DO NOT USE IN WET CONDITIONS! Do not use in the rain or snow. Do not use near a pool or sprinkler system. Do not use when your hands are wet. KEEP THE GENERATOR DRY. - Page 5 10/07/13 15:28:10 42Z30600_005 SAFETY KEEP AWAY FROM FLAMMABLE MATERIALS! WHEN REFUELING: STOP ENGINE! DO NOT SPILL! NO SMOKING!
-
Page 6: Pre-Operation Check
10/07/13 15:28:18 42Z30600_006 PRE-OPERATION CHECK ENGINE OIL LEVEL Check the engine oil level with the generator on a level surface and the engine stopped. Recommended oil: 4-STROKE MOTOR OIL SAE 10W-30 API Service category SE or later Remove the oil filler cap/dipstick and check the oil level. If the oil level is low, add the recommended oil to the edge of the oil filler neck. -
Page 7: Fuel Level
10/07/13 15:28:25 42Z30600_007 PRE-OPERATION CHECK FUEL LEVEL Never use an oil/gasoline mixture or dirty gasoline. Fuel tank capacity: 24.0 L Check the fuel level. If the fuel level is low, fill the fuel to the upper level. FUEL TANK CAP UPPER LEVEL MARK (RED) UPPER LEVEL FUEL GAUGE... -
Page 8: Air Cleaner
10/07/13 15:28:32 42Z30600_008 PRE-OPERATION CHECK AIR CLEANER Remove the air cleaner cover taking care not to damage it. Unsnap the air cleaner cover clips and pull the air cleaner cover. Free the hooks from the setting pins. Remove to the right side of the frame pipe. HOOK SETTING PIN CLIP... - Page 9 10/07/13 15:28:39 42Z30600_009 PRE-OPERATION CHECK Reinstall the air cleaner cover. Place the air cleaner cover over the air cleaner case. Set the hooks to the setting pins securely. Push the air cleaner cover to lock the clips. HOOK AIR CLEANER CASE SETTING PIN CLIP AIR CLEANER COVER...
-
Page 10: Battery Service (Electric Starter Type Only)
10/07/13 15:28:47 42Z30600_010 PRE-OPERATION CHECK BATTERY SERVICE (electric starter type only) Your generator’s engine charging system charges the battery while the engine is running. However, if the generator is only used periodically, the battery must be charged monthly to maintain the battery service life. - Page 11 If rapid loss of battery fluid is experienced, or if your battery seems to be weak causing slow operation of the starter motor, see your authorized Honda generator dealer. Locate the battery. Check the battery fluid level with the generator on a level surface.
-
Page 12: Starting The Engine
10/07/13 15:29:01 42Z30600_012 STARTING THE ENGINE Make sure that the AC circuit breaker is in the OFF position. SH, MH, RH, KH types LDH type AC CIRCUIT BREAKER Turn the fuel valve lever to the FUEL VALVE LEVER ON position. Move the choke knob to the CHOKE KNOB CLOSED position. - Page 13 10/07/13 15:29:10 42Z30600_013 STARTING THE ENGINE Start the engine. Using the electric starter: Turn the engine switch to the START START position, and hold it there until the engine starts. When the engine starts, release the key, allowing the switch to return to the ON position.
-
Page 14: Oil Alert System
10/07/13 15:29:20 42Z30600_014 STARTING THE ENGINE If the choke knob was moved to the CLOSED position, move to the OPEN position as the engine warms up. OPEN CHOKE KNOB Oil Alert System The Oil Alert system is designed to prevent engine damage caused by an insufficient amount of oil in the crankcase. -
Page 15: Generator Use
To keep the generator always in top mechanical and electrical condition, observe the following. Combined load of the connected apparatus must not exceed the rated capacity of the generator. Rated capacity: EG4000CX 3.2 kVA (MH, RH, KH types) 3.6 kVA (LDH type) EG5000CX 4.0 kVA... - Page 16 10/07/13 15:29:36 42Z30600_016 GENERATOR USE Turn the AC circuit breaker to the ON position. Confirm that the appliance to be used is switched off, and plug in the appliance. SH, RH, KH types MH type AC CIRCUIT BREAKER AC CIRCUIT BREAKER PLUG PLUG LDH type...
- Page 17 10/07/13 15:29:41 42Z30600_017 GENERATOR USE Turn on the equipment to be used. An overloaded AC circuit will switch off the AC circuit breaker. If this happens, reduce the load on the circuit, and wait a few minutes before switching on. SH, MH, RH, KH types LDH type AC CIRCUIT BREAKER...
-
Page 18: Ac Receptacle Selection
Total Current Available: SH type: 20.5 A (EG5000CX) 25.0 A (EG6500CX·EG6500CXS) RH, KH types: 14.5 A (EG4000CX) 18.2 A (EG5000CX) 22.7 A (EG6500CX·EG6500CXS) Receptacles Available power 20 A 20 A MH type RECEPTACLE No.1... - Page 19 Make sure the load on any receptacle does not exceed its available power RECEPTACLE No.5 shown below and the total load does not exceed the total current available. Total Current Available: 30.0 A (EG4000CX) 37.5 A (EG5000CX) 45.8 A (EG6500CX·EG6500CXS) Receptacles Available power...
-
Page 20: Dc Application
10/07/13 15:30:13 42Z30600_020 GENERATOR USE DC Application The DC terminals may be used for charging 12 volt automotive-type batteries only. Connect the charging cable to the DC terminals and battery terminals in numerical order as shown. to positive ( ) battery terminal ＋... -
Page 21: Stopping The Engine
10/07/13 15:30:22 42Z30600_021 STOPPING THE ENGINE In emergency, turn the engine switch to the OFF position. In normal use: Switch off the connected appliance and pull off the plug. Turn the AC circuit breaker to the OFF position. SH, MH, RH, KH types LDH type AC CIRCUIT BREAKER AC CIRCUIT BREAKER... -
Page 22: Maintenance
These items should be serviced by your servicing dealer, unless you have the proper tools and are mechanically proficient. Refer to the Honda shop manual for service procedures. For commercial use, log hours of operation to determine proper maintenance intervals. -
Page 23: Engine Oil Change
10/07/13 15:30:44 42Z30600_023 MAINTENANCE ENGINE OIL CHANGE Remove the oil filler cap/dipstick and oil drain plug to drain the oil. SEALING WASHER OIL DRAIN PLUG OIL FILLER CAP/DIPSTICK Install the oil drain plug, and tighten it securely. Fill to the upper level with the recommended oil (see page ). Engine oil capacity: 1.1 L UPPER LEVEL... -
Page 24: Air Cleaner Service
10/07/13 15:30:53 42Z30600_024 MAINTENANCE AIR CLEANER SERVICE Remove the air cleaner cover taking care not to damage it. Unsnap the air cleaner cover clips and pull the air cleaner cover. Free the hooks from the setting pins. Remove to the right side of the frame pipe. Remove the air cleaner element from the air cleaner case and clean it. - Page 25 10/07/13 15:31:01 42Z30600_025 MAINTENANCE Install the air cleaner element to the air cleaner case. Reinstall the air cleaner cover. Place the air cleaner cover over the air cleaner case. Set the hooks to the setting pins securely. Push the air cleaner cover to lock the clips. HOOK AIR CLEANER CASE SETTING PIN...
-
Page 26: Spark Plug Service
10/07/13 15:31:12 42Z30600_026 MAINTENANCE SPARK PLUG SERVICE Recommended spark plug: BPR5ES (NGK) Never use a spark plug with an improper heat range. SPARK PLUG WRENCH Remove the spark plug cap and then remove the spark plug using a spark plug wrench. SPARK PLUG CAP Clean the spark plug with a wire brush. -
Page 27: Sediment Cup Cleaning
10/07/13 15:31:20 42Z30600_027 MAINTENANCE SEDIMENT CUP CLEANING Gasoline is extremely flammable and is explosive under certain conditions. Do not smoke or allow flames or sparks in the area. Type with electric starter: Turn the engine switch to the OFF position and remove the key. Type without electric starter: Turn the engine switch to the OFF position. -
Page 28: Fuse (Electric Starter Type Only)
In the event of fuse failure, locate the cause of failure and repair it before you continue operation. If the fuse continues to fail, discontinue generator use and consult an authorized Honda generator dealer. Turn the engine switch to the OFF position and remove the key before checking or replacing the fuse. -
Page 29: Storage
10/07/13 15:31:35 42Z30600_029 STORAGE Gasoline is extremely flammable and is explosive under certain conditions. Do not smoke or allow flames or sparks in the area. Drain the fuel from the fuel tank. DRAIN SCREW Loosen the drain screw and drain the carburetor. Change the engine oil (see page Slowly pull the starter grip until resistance is felt. -
Page 30: Troubleshooting
ON. Is the enough oil Add the in the engine? recommended oil. Is the spark plug Clean, readjust in good gap and dry the condition? spark plug. Replace it if necessary. Take the generator to an authorized Honda dealer. - Page 31 NO DEFECT repair. Take the generator to an authorized Honda dealer. No electricity at the DC terminals: Is the DC circuit Push the DC circuit protector ON? protector ON. Take the generator to an authorized Honda dealer.
- Page 32 Refill the fuel the tank? tank. Is the enough oil Add the in the engine? recommended oil. Turn engine switch to OFF and restart the engine. If the engine still does not start, take the generator to an authorized Honda dealer.
-
Page 33: Specifications
10/07/13 15:32:24 42Z30600_033 SPECIFICATIONS Model EG4000CX Type 120 V/240 V 220 V Rated voltage 60 Hz 50 Hz Rated frequency output 30.0 A/15.0 A 14.5 A Rated current 3.6 kVA 3.2 kVA Rated output 4.0 kVA 3.6 kVA Maximum output... -
Page 34: Installation Of Kit Parts
10/07/13 15:32:32 42Z30600_034 INSTALLATION OF KIT PARTS STANDARD KIT PARTS EG6500CXS Electric starter type: Battery Tray Kit Install the battery guard pipe on the frame. Set the battery tray on the battery guard pipe and tighten the bolts. Route the starter cable under the tank and connect it to the starter solenoid. - Page 35 13/02/08 16:45:16 42Z30600_035 INSTALLATION OF KIT PARTS STARTER CABLE (Positive) BATTERY GROUND CABLE CABLE TIE STARTER SOLENOID (16) (17) (14) (13) (11) (12) (15) (10) BATTERY SET BOLT BATTERY TRAY BATTERY SET PLATE (10) BATTERY GUARD PLATE 6 mm FLANGE NUT (11) BATTERY BOX BATTERY GROUND CABLE...
-
Page 36: Optional Kit Parts
10/07/13 15:32:46 42Z30600_036 INSTALLATION OF KIT PARTS OPTIONAL KIT PARTS Four Wheel Kit Installation Install the lock plate and four wheels on the wheel shaft using the plain washers and split pins. Install the front wheel shaft on the front side nearest the engine. Install the wheel shaft assembly on the generator using eight 8 ×...