Page 1
HISTORY Model Name KDL-26/32/40T3000 SERVICE MANUAL Click on Page Number to display detail of changes. Date Part Number Description of Revisions Version 2007.07 9-927-562-01 Original Manual. Amendments to table of contents (P2), sections 5 & 6 9-927-562-02 2007.12 (P83), (P84), (P87), (P94) and addition of full size schematic diagrams.
Page 2
SE1A RM-ED009 SE1A SERVICE MANUAL CHASSIS MODEL MODEL COMMANDER DEST COMMANDER DEST KDL-26T3000 KDL-26T3000 RM-ED009 RM-ED009 KDL-32T3000 KDL-32T3000 RM-ED009 RM-ED009 KDL-40T3000 KDL-40T3000 RM-ED009 RM-ED009 KDL-26T3000 / KDL-32T3000 / KDL-40T3000 RM-ED009 FLAT PANEL COLOR TV - 1 -...
COMPONENTS IDENTIFIED BY SHADING AND MARKED THE SCHEMATIC DIAGRAMS, EXPLODED VIEWS AND IN THE PARTS LIST ARE CRITICAL FOR SAFE OPERATION. REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR IN SUPPLEMENTS PUBLISHED BY SONY.
Due to the higher melting point of Lead Free Solder the soldering iron tip temperature needs to be set to 370 degrees centigrade. This requires soldering equipment capable of accurate temperature control coupled with a good heat recovery characteristics. For more information on the use of Lead Free Solder, please refer to http://www.sony-training.com - 3 -...
SE1A RM-ED009 CONNECTORS 21 Pin Connector (SCART) Pin No Signal Signal level Audio output B Standard level : 0.5V rms (right) Output impedence : Less than 1kohm* Audio input B Standard level : 0.5V rms (right) Output impedence : More than 10kohm* Audio output A Standard level : 0.5V rms (left)
Page 7
SE1A RM-ED009 HDMI Connector Pin No Signal Assignment Pin No Signal Assignment TMDS Data2+ TMDS Clock Shield TMDS Data2 Shield TMDS Clock- TMDS Data2- TMDS Data1+ Reserved (N.C. on device) TMDS Data1 Shield TMDS Data1- TMDS Data0+ DDC/CEC Ground TMDS Data0 Shield +5V Power TMDS Data0- Hot Plug Detect...
SE1A RM-ED009 SE1A SELF DIAGNOSTIC SOFTWARE The identification of errors within the SE1A chassis is triggered in one of two ways :- 1: Busy or 2: Device failure to respond to IIC. In the event of one of these situations arising the software will first try to release the bus if busy (Failure to do so will report with a continuous flashing LED) and then communicate with each device in turn to establish if a device is faulty.
SE1A RM-ED009 SECTION 3 CIRCUIT ADJUSTMENTS 3-1. Electrical Adjustments Service adjustments to this model can be performed using the supplied remote Commander RM-ED009. How to enter into the Service Mode Turn on the main power switch. Press the following sequence of buttons on the Remote Commander.
SE1A RM-ED009 3-2. TT MODE TT mode is available by setting the TV for operation in Service Mode [ As shown on Page 16 ] , OSD ‘TT’ appears. The functions described below are available by selecting the two numbers. To release the ‘Test mode 2’, press 00, 10, 20 ... twice or switch the TV set into Stand-by mode.
SE1A RM-ED009 3-3. TT OSD Labels A E P T T - " E C S C B A N o r m D D C (10) (11) (12) (13) (14) (15) C l k (16) (17) (18) (19) (20) (21) (22) W c g...
SE1A RM-ED009 4-1. BLOCK DIAGRAM , sw itch-buttons , SIR C S, LED . Front A V U 1 / U 2 CI bu ffers Elp ida R G B 4+ 4+ 4+ 5(c trl) EDD12 16 AAT A D ata, A ddr, DDR 128M b C ontrol C V B S D ig ita l R F...
BC.SE1A COMPONENTS MARKED AS XX REFER TO PARTS LIST, WILL ONLY BE LISTED IF FITTED FB1001 5V_MAIN 1005 1005 0 . 1 C1013 680p C1016 C1022 1A/13 TUNER, AUDIO/VIDEO PROCESSOR, HDMI & PC INPUT CN1000 NFE_NLNA_SW R1032 1005 1005 1005 1/16W CHIP 680p...
Page 25
COMPONENTS MARKED AS XX REFER TO PARTS LIST, WILL ONLY BE LISTED IF FITTED S C A R T 1 SELECT_OUT_R JL2030 R2018 R2001 C2004 R2037 C2016 0 . 0 2 2 470k PZU9.1B2 1/10W 1/10W D2011 CHIP RN-CP RN-CP 1608 JL2031 SC2_IN_R...
Page 26
S C A R T 2 JL2051 ANALOG_RF_R R2089 R2097 C2036 R2112 C2044 0 . 0 2 2 470k PZU9.1B2 1/10W RN-CP CHIP RN-CP D2035 1/10W 1608 JL2052 SCART1_R C2037 R2090 R2098 C2042 1000p R2113 PZU9.1B2 C2032 470k CHIP 1/10W 1/10W D2036 CN2001...
Page 27
AUDIO_13V AVCC ROSC AVCC VREG FAULT VBYP MUTE AGND SHUTDOWN BSLP BSRP TPA3100D2PHPR LOUTP ROUTP IC3000 LOUTP ROUTP LOUTN ROUTN LOUTN ROUTN BSLN BSRN 12V_DD 22uH L3009 L3010 L3008 22uH 22uH L3007 22uH B+ IN A+ IN B- IN B OUT A- IN A OUT D3000...
Page 50
AGNDV IC7100 UPD61123F1-100-KA3-A AGNDP GND_1 CHIP 1/16W R7150 CHIP 1/16W R7151 GND_1 9D/13 COMPONENTS MARKED AS XX REFER TO PARTS LIST, WILL ONLY BE LISTED IF FITTED BC.SE1A ~ BC Board Schematic Diagram [ Tuner, Audio/Video Processor, HDMI & PC Input ] Page 9D/13 ~ - 49 -...
SECTION 5 EXPLODED VIEWS NOTE : Non-serviceable items with no part number and no Items marked “*” are not stocked since they are seldom required for description are not stocked because they are not required for routine service. routine service. Some delay should The construction parts of an assembled part are indicated be anticipated when ordering these with a collation number in the remarks column.
SECTION 6 ELECTRICAL PARTS LIST PARTS LISTING TABLE OF CONTENTS Page U2 BOARD COMPLETE Parts List : 32/40 Inches only................. 87 G3 BOARD COMPLETE Parts List : 40 Inches only................88 D1 BOARD COMPLETE Parts List : 40 Inches only................91 BC BOARD COMMON Parts List : Parts common to all models in this manual.........
Page 112
REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK X7201 1-813-784-21 VIBRATOR, CRYSTAL C5520 NOT FITTED C5521 NOT FITTED C6507 NOT FITTED BC Board Variant Parts (26 Inches Only) C6508 NOT FITTED < CAPACITOR > C6510 NOT FITTED C5018 NOT FITTED C6558 NOT FITTED C5019 NOT FITTED C5020 NOT FITTED < CONNECTOR > C5021 NOT FITTED C5022 NOT FITTED CN5500...
Page 113
REF.NO. PART.NO DESCRIPTION REMARK REF.NO. PART.NO DESCRIPTION REMARK R5059 NOT FITTED R5673 NOT FITTED R5060 NOT FITTED R5674 1-218-990-81 SHORT CHIP 0 R5063 NOT FITTED R5675 1-218-990-81 SHORT CHIP 0 R5502 NOT FITTED R6560 NOT FITTED R5539 NOT FITTED R6562 NOT FITTED R5544 NOT FITTED R6563 NOT FITTED R5548 NOT FITTED R6571 NOT FITTED R5549 NOT FITTED R6572 NOT FITTED R5550...
Page 122
BC.SE1A COMPONENTS MARKED AS XX REFER TO PARTS LIST, WILL ONLY BE LISTED IF FITTED FB1001 5V_MAIN 1005 1005 0 . 1 C1013 680p C1016 C1022 1A/13 TUNER, AUDIO/VIDEO PROCESSOR, HDMI & PC INPUT CN1000 NFE_NLNA_SW R1032 1005 1005 1005 1/16W CHIP 680p...
Page 136
G3.SE1A G3.SE1A Mount Mecha A6000 214976631 D6000 t @ X g ƒ “ VAi u « • ƒ \ B CN6003 EY6158 L6501 EY6151 R6011 C6024 ‡ 28.5mm A 120mmq [ g V N 300uH C6515 C6516 Mount Mecha D6151 FROM INVERTER R6106 L6150...