READ SAFETY RULES AND INSTRUCTIONS CAREFULLY BEFORE OPERATION
Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush-
covered or grass-covered land unless the engine's exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any).
If a spark arrester is used, it should be maintained in effective working order by the operator. In the State of California the above is required by law
(Section 4442 of the California Public Resources Code). Other states may have similar laws. Federal laws apply on federal lands. A spark arrester
for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 361131 Cleveland,
Page 1
21” Rear & Side D Mulching Lawn Mower Model Series 430 IMPORTANT READ SAFETY RULES AND INSTRUCTIONS CAREFULLY BEFORE OPERATION Warning: This unit is equipped with an internal combustion engine and should not be used on or near any unimproved forest-covered, brush- covered or grass-covered land unless the engine’s exhaust system is equipped with a spark arrester meeting applicable local or state laws (if any).
This Operator’s Manual is an important part of your new lawn mower. It will help you assemble, prepare and maintain the unit for best performance. Please read and understand what it says. Slope Gauge ... 3 Safe Operation Practices ... 4 Setup and Adjustment ...
Use this page as a guide to determine slopes where you may not operate safely. Do not operate your lawn mower on such slopes. Slope Gauge WARNING Do not mow on inclines with a slope in excess of 15 degrees (a rise of approximately 2-1/2 feet every 10 feet).
DANGER: This machine was built to be operated according to the rules for safe operation in this manual. As with any type of power equipment, carelessness or error on the part of the operator can Safe result in serious injury. This machine is capable of amputating hands and feet and throwing objects. Failure to observe the following safety instructions could result in serious injury or death.
19. Shut the engine off and wait until the blade comes to a complete stop before removing the grass catcher or unclog- ging the chute. The cutting blade continues to rotate for a few seconds after the engine is shut off. Never place any part of the body in the blade area until you are sure the blade has stopped rotating.
Setup and Adjustment Figure 3-1: Unfold handle and tighten hardware. Stand behind the mower as if you were going to operate it. Your right hand corresponds to the right side of the mower; your left hand corresponds to the left side of the mower. Make sure to route cable outside the lower handle.
Page 7
5. Follow steps below to assemble the grass catcher (if needed). Make certain bag is turned right side out before assembling (warning label will be on the outside). a. Place bag over frame so that its black plastic side is at the bottom. b.
Operating Your Lawn Mower Recoil Starter Grass Catcher WARNING The blade control is a safety device. DO NOT bypass its operations. Side Discharge Chute Use extreme care when handling gasoline. Gasoline is extremely Figure 4-1: The main components on the mower. flammable and the vapors are explosive.
Starting Engine WARNING: Be sure no one other than the op- erator is standing near the lawn mower while starting engine or operating mower. Never run engine indoors or in enclosed, poorly ventilated areas. Engine exhaust contains carbon monoxide, an odorless and deadly gas.
Maintaining Your Lawn Mower Figure 5-1: Areas of lubrication (model 435 shown) General Recommendations • Always observe safety rules when performing WARNING any maintenance. • The warranty on this lawn mower does not cover items that have been subjected to operator abuse Always stop engine, or negligence.
Blade Care WARNING: When removing the cutting blade for sharpening or replacement, protect your hands with a pair of heavy gloves or use a heavy rag to hold the blade. Periodically inspect the blade adapter for cracks, especially if you strike a foreign object. Replace when necessary.
Problem Engine fails to start Trouble Shooting Engine runs erratic Engine overheats For repairs beyond the minor adjustments listed here, contact Occasional skips an authorized service (hesitates) at high speed dealer. Idles poorly Excessive Vibration Mower will not mulch grass Uneven cut NOTE: Specifications are subject to change without...
Ref. Part No. Description 747-1161A Blade Control Handle 749-1092A Upper Handle 747-04080 Grass Catcher Frame 749-0928A Lower Handle 720-0279 Wing Nut 710-1205 Rope Guide 710-1174 Carriage Bolt ,5/16-18 x 2 664-04027 Grass Bag Assembly 720-04072 Hand Knob 731-1506A Front Cover 726-0240 Cable Tie 710-0703...
Page 16
MANUFACTURER’S LIMITED WARRANTY FOR The limited warranty set forth below is given by MTD LLC with respect to new merchandise purchased and used in the United States, its posses- sions and territories. “MTD” warrants this product against defects in material and workmanship for a period of two (2) years commencing on the date of original purchase and will, at its option, repair or replace, free of charge, any part found to be defective in materials or workmanship.