Federal laws apply on federal lands. A spark arrester for the muffler is available through your nearest engine authorized service dealer or contact the service department, P.O. Box 361131 Cleveland, Ohio 44136-0019. MTD LLC, P.O. BOX 361131 CLEVELAND, OHIO 44136-0019 FORM NO. 769-00564.fm PRINTED IN U.S.A.
Troubleshooting... 15 Parts List ... 16 This Operator’s Manual is an important part of your new Lawn Mower. It will help you assemble, prepare and maintain the unit for best performance. Please read and understand what it says. Before you start assembling your new equipment, please locate the model plate on the equipment and copy the information from it in the space provided below.
SECTION 1: IMPORTANT SAFE OPERATION PRACTICES WARNING: This symbol points out important safety instructions which, if not followed, could endanger the personal safety and/or property of yourself and others. Read and follow all instructions in this manual before attempting to operate this machine. Failure to comply with these instructions may result in personal injury.
8. Never operate the mower in wet grass. Always be sure of your footing. A slip and fall can cause serious personal injury. If you feel you are losing your footing, release the blade control handle immediately and the blade will stop rotating within three seconds.
Page 5
7. Extinguish all cigarettes, cigars, pipes and other sources of ignition. 8. Never fuel machine indoors because flammable vapors will accumulate in the area. 9. Never remove gas cap or add fuel while the engine is hot or running. Allow engine to cool at least two minutes before refueling.
NOTE: Reference to right or left hand side of the mower is observed from the operating position. Disconnecting Spark Plug • Before setting up your lawn mower, disconnect the spark plug wire from the spark plug, and ground it to retaining post on the engine. See Figure 1. Figure 1 Assembling Handle •...
• Insert post of cable ties that are on lower handle into the holes provided on the lower handle. The holes may be on the inside or outside. Pull cable ties tight and cut off the extra. See Figure 5 below. Cable Tie Post on Cable Tie...
Converting to Side-Discharge SECTION 4: KNOW YOUR LAWN MOWER Read this owner’s manual and safety rules before operating your lawn mower. Compare the illustrations in Figure 11 with your lawn mower to familiarize yourself with the location of various controls and adjustments.
This is called mulching. WARNING: Be sure no one other than the operator is standing near the lawn mower while starting engine or operating mower. WARNING: Never run engine indoors or in enclosed, poorly ventilated areas.
• Be sure that the lawn is clear of stones, sticks, wire, or other objects which could damage lawn mower or engine. Such objects could be accidently thrown by the mower in any direction and cause serious personal injury to the operator and others.
SECTION 6: MAINTAINING YOUR LAWN MOWER WARNING: Always stop engine and disconnect spark plug wire before performing any maintenance or adjustments on the mower. WARNING: Never tip mower more than 90 degrees in any direction and do not leave it tipped for long.
SECTION 7: SERVICING YOUR MOWER Blade Care Periodically inspect the blade adapter and pulley for cracks, especially if you strike a foreign object. Replace when necessary. WARNING: When removing the cutting blade for sharpening or replacement, protect hands by using heavy gloves or a thick rag to grasp the cutting blade.
• Insert hairpin clips in the inner holes of the weld pins and attach the starter rope as instructed in the “Assembling Your Lawn Mower” section. • Attach the new flap and new rod to deck, bending the ends of the new rod over to secure to deck.
SECTION 9: OFF-SEASON STORAGE Prepare your lawn mower for storage at the end of the season or if the unit will not be used for 30 days or more. Store the mower in a clean, dry area. Gasoline • Do not store gasoline from one season to another.
Shroud Chart Part No. Color 751B281439 Dark Red 751B281440 Black 751B281443 Bright Red Hardware: 710-1256 Part No. Color 731-1585B Black Hardware: 710-1274 Part No. Color 7511681311 Black 7511681911 7511682011 Gray Part No. Color 731-1395A 731-1396A Black 731-1397A Gray Hardware: 710-1256 Part No.
Page 20
MANUFACTURER’S LIMITED WARRANTY FOR: The limited warranty set forth below is given by MTD LLC with respect to new merchandise purchased and used in the United States, its possessions and territories. MTD LLC warrants this product against defects for a period of...