Advertisement
Table of Contents
Table of Contents
Important Safety Information . . . . . . . . . . . . . 1
Safety at All Times . . . . . . . . . . . . . . . . . . . . . . . . . 1
Look For The Safety Alert Symbol . . . . . . . . . . . . . 1
Safety Labels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6
Introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Application . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Using This Manual . . . . . . . . . . . . . . . . . . . . . . . . . 9
Terminology . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Definitions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Owner Assistance . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Serial Number . . . . . . . . . . . . . . . . . . . . . . . . . . . 9
Further Assistance . . . . . . . . . . . . . . . . . . . . . . . . 9
Section 1: Assembly and Set-up . . . . . . . . . . 10
Dealer Preparations . . . . . . . . . . . . . . . . . . . . . . . 10
Tractor Requirements . . . . . . . . . . . . . . . . . . . . . . 10
Torque Requirements . . . . . . . . . . . . . . . . . . . . . . 10
Tractor Shutdown Procedure . . . . . . . . . . . . . . . . 10
RTA Park Stand Set-up . . . . . . . . . . . . . . . . . . . . . 10
RTR Park Stand Set-up . . . . . . . . . . . . . . . . . . . . 11
RTR Front Deflector Assembly . . . . . . . . . . . . . . . 11
RTR Lower Clevis Assemblies . . . . . . . . . . . . . . . 12
RTA Lower Clevis Assemblies . . . . . . . . . . . . . . . 12
Center Positioning of Lower Clevises . . . . . . . . . . 12
Upper Hitch Plate Assembly . . . . . . . . . . . . . . . . . 13
Driveline Shield Assembly . . . . . . . . . . . . . . . . . . . 14
Driveline Assembly . . . . . . . . . . . . . . . . . . . . . . . . 14
Tractor Hook-Up . . . . . . . . . . . . . . . . . . . . . . . . . . 14
3-Point Hook-Up . . . . . . . . . . . . . . . . . . . . . . . . 15
Driveline Hook-Up . . . . . . . . . . . . . . . . . . . . . . . 16
Check Driveline Collapsible Length . . . . . . . . . . . . 16
Check Driveline Maximum Length . . . . . . . . . . . . . 17
Check Driveline Interference . . . . . . . . . . . . . . . . . 18
Section 2: Operating . . . . . . . . . . . . . . . . . . . 20
Operating Checklist . . . . . . . . . . . . . . . . . . . . . . . . 20
Inspections . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 20
Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . 20
RTR Park Stand Operation . . . . . . . . . . . . . . . . . . 22
Set Park Stand For Transport . . . . . . . . . . . . . . 22
Set Park Stand For Storage . . . . . . . . . . . . . . . . 22
RTA Park Stand Operation . . . . . . . . . . . . . . . . . . 23
Set Stand For Transporting . . . . . . . . . . . . . . . . 23
Set Stand Park Stand For Storage . . . . . . . . . . . 23
Transport Rotary Tiller . . . . . . . . . . . . . . . . . . . . . 24
Unhook Rotary Tiller . . . . . . . . . . . . . . . . . . . . . . . 24
General Operating Notes . . . . . . . . . . . . . . . . . . . 25
General Operating Instructions . . . . . . . . . . . . . . . 25
©
Copyright 2019 All rights Reserved
Land Pride provides this publication "as is" without warranty of any kind, either expressed or implied. While every precaution has been taken in the
preparation of this manual, Land Pride assumes no responsibility for errors or omissions. Neither is any liability assumed for damages resulting from the use
of the information contained herein. Land Pride reserves the right to revise and improve its products as it sees fit. This publication describes the state of this
product at the time of its publication, and may not reflect the product in the future.
11/19/19
Land Pride is a registered trademark.
All other brands and product names are trademarks or registered trademarks of their respective holders.
Printed in the United States of America.
Section 3: Adjustments . . . . . . . . . . . . . . . . . 26
Hitch Offset . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 26
Drive Chain Tension . . . . . . . . . . . . . . . . . . . . . . . 26
RTR12 Series Tillers . . . . . . . . . . . . . . . . . . . . . 26
RTA12 Series Tillers . . . . . . . . . . . . . . . . . . . . . 26
Rear Tailgate Adjustment . . . . . . . . . . . . . . . . . . . 27
Skid Shoe Adjustment . . . . . . . . . . . . . . . . . . . . . . 27
RTR Park Stand Adjustment . . . . . . . . . . . . . . . . . 27
Section 4: Maintenance and Lubrication . . . 28
Maintenance . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Tine Replacement . . . . . . . . . . . . . . . . . . . . . . . . . 28
Driveline Protection . . . . . . . . . . . . . . . . . . . . . . . . 28
Clutch Run-In . . . . . . . . . . . . . . . . . . . . . . . . . . . 28
Clutch Disassembly . . . . . . . . . . . . . . . . . . . . . . 29
Clutch Assembly . . . . . . . . . . . . . . . . . . . . . . . . 29
Long-Term Storage . . . . . . . . . . . . . . . . . . . . . . . . 30
Ordering Replacement Parts . . . . . . . . . . . . . . . . . 30
Lubrication Points . . . . . . . . . . . . . . . . . . . . . . . . . 31
Driveline U-Joint . . . . . . . . . . . . . . . . . . . . . . . . . 31
Driveline Shield Bearings . . . . . . . . . . . . . . . . . . 31
Driveline Shaft . . . . . . . . . . . . . . . . . . . . . . . . . . 31
Bearing On Right End Of Rotor Shaft . . . . . . . . . 32
Chaincase . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Gearbox . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Section 5: Troubleshooting . . . . . . . . . . . . . . 33
Section 6: Specifications & Capacities . . . . . 34
Section 7: Features & Benefits . . . . . . . . . . . 36
Section 8: Torque Values Chart . . . . . . . . . . . 38
Section 9: Warranty . . . . . . . . . . . . . . . . . . . . 39
RTR12 & RTA12 Series (Serial No. 884765+) Rotary Tillers 311-883M
Advertisement
