Summary of Contents for Vulcan-Hart VB150 ML-126552
Page 1
VBP13 I ML-126359 VB200 VBP15 I ML-126360 VBP77 I ML-126361 For additional information on Vulcan-Hart or to locate an authorized parts and service provider in your area, visit our website at www.vulcanhart.com VULCAN-HART DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC WWW.VULCANHART.COM...
V SERIES IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL ELECTRICAL EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START-UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS IN THE VICINITY OF THIS OR ANY OTHER APPLIANCE.
Page 3
INSTALLATION, OPERATION AND CARE V SERIES FOOD HOLDING AND TRANSPORTATION CABINETS AND BANQUET CARTS SAVE THESE INSTRUCTIONS FOR FUTURE USE Vulcan-Hart Holding and Transport Cabinets and Banquet Carts are produced with quality workmanship material. installation, usage, and maintenance of your cabinet will result in many years of satisfactory performance.
If the electrical service does not agree with the rating plate, do not proceed with installation. Contact your dealer or local Vulcan-Hart service technician immediately. Fig. 2 UNPACKING The APPLIANCE was inspected before leaving the factory.
INSTALLATION CODES AND STANDARDS The APPLIANCE must be installed in accordance with: In the United States of America: 1. State and local codes. 2. National Electrical Code, ANSI/NFPA-70 (latest edition). Copies may be obtained from The National Fire Protection Association, Batterymarch Park, Quincy, MA 02269.
Page 6
V SERIES Electrical Connection Electrical and grounding connections must comply with the applicable portions of the National Electrical Code and/or other Local Electrical Codes. MODEL VOLTAGE VBP5I, VBP7I, VBP13I, 110/120 VBP15I, VBS7, VBS15, 208/240 VHDP5, VDW3 VBP77I 110/120 208/240 VHP3, VHP7, VHP8 110/120 208/240 VHP15, VHP20...
The cabinet and its parts are hot, be very careful when operating, cleaning or servicing the cabinet. CONTROLS POWER FULL RANGE INDICATOR THERMOSTAT LIGHT POWER/HEAT ® °C °F HEAT THERMOMETER INDICATOR LIGHT Fig. 4 HOLDING COMPARTMENTS POWER INDICATOR LIGHT Lit when power is supplied to cabinet. HEAT INDICATOR LIGHT Lit when heat is supplied to cabinet.
V SERIES OPERATING APPLIANCE 1. Connect electric power supply. • Power indicator light is lit. Fig. 6 2. Turn thermostat knob to desired setting. • Heating elements begin heating. • Heat indicator light is lit. 4 5 6 7 Fig. 7 3.
Page 9
Shutdown Turn full range thermostat counterclockwise to OFF. 4 5 6 7 Fig. 9 Unplug electrical power supply. Power indicator light will go off. Fig. 10 Extended Shutdown Unplug electrical power supply. Power indicator light will go off. CLEANING electrical power to the machine and follow Lockout/ Tagout procedures before cleaning.
Press power switch to the on position. Close door. Check door gasket for damage. If adjustment is needed, contact your Authorized Vulcan-Hart Servicer. Contact your authorized service provider. Contact your authorized service provider. Check power source. Check power source and thermostat operation.
WIRING DIAGRAMS THERMOSTAT POWER CONNECTION 120V, 1PH, 60 Hz 208/240V, 1PH, 60 Hz BLACK WHITE GREEN VB48, VB72, VB90, VB96, VB150, VBP5I, VBP7I, VBP13I, VBP15I, VHP15, VHP20 POWER BLACK WHITE HEATING ELEMENT Wiring Diagram — 11 — V SERIES POWER HEATING ELEMENT...
Page 12
V SERIES BLACK POWER CONNECTION WHITE 120V, 1PH, 60 Hz GREEN 208/240V, 1PH, 60 Hz POWER BLACK THERMOSTAT HEATING ELEMENT POWER BLACK THERMOSTAT HEATING ELEMENT VBP77I Wiring Diagram — 12 — POWER POWER...
Page 13
BLACK POWER CONNECTION WHITE 120V, 1PH, 60 Hz GREEN 208/240V, 1PH, 60 Hz VHP3, VHP7, VHP8 Wiring Diagram POWER THERMOSTAT WHITE — 13 — V SERIES HEATING ELEMENT...
Page 14
V SERIES VULCAN REPLACEMENT PARTS LIST BOLT, RETAINING RACK (PACK OF 4) CAP, CHROME INSPECTION CLIP, ELEMENT CORD, POWER 12/3 120V. 15 AMP CORD, POWER 12/3 120V. 20 AMP CORD, POWER 12/3 208/240V. 15 AMP CORD, POWER 16/3 120V. ELEMENT, 120V – 1000W ELEMENT, 120V –...
Page 15
V SERIES NOTES (9-07) — 15 — PRINTED IN U.S.A.
V SERIES SERVICE AND PARTS INFORMATION To obtain service and parts information concerning this model, contact the Vulcan-Hart Service Agency in your area (refer to our website, www.vulcanhart.com for a complete listing of Authorized Service and Parts depots). When calling for service, the following information must be available: model number, serial number, manufacture date (MD) and voltage.