Table of Contents
Advertisement
Quick Links
USE/INSTALLATION
INSTRUCTIONS
VRBD/VUBD 24" W. BEVERAGE DISPENSER
Retain for Future Reference
IMPORTANT - PLEASE READ AND FOLLOW
•Before beginning, please read these instructions completely and carefully.
•Do not remove permanently affixed labels, warnings, or plates from the product. This may void the warranty.
•The installer should leave these instructions with the consumer for future reference.
GENERAL INFORMATION
1. A A L L W W A A Y Y S S connect CO2 gas cylinder to reducing valve or regulator
2. N N E E V V E E R R connect gas cylinder directly to keg.
3. A A L L W W A A Y Y S S secure gas cylinder in upright position.
4. A A L L W W A A Y Y S S keep gas cylinder away from heat.
5. N N E E V V E E R R drop or throw gas cylinder.
6. A A L L W W A A Y Y S S ventilate after CO2 leakage.
7. Gas cylinders should be stored in the coolest part of the room, preferably at 70
upright position before the primary regulator is attached to the cylinder
CO
CAN BE DANGEROUS
2
If it becomes difficult to breathe and
your head starts to ache, abnormal
concentrations of carbon dioxide may
be present in the area. Leave the
room immediately.
B B E E E E R R D D I I S S P P E E N N S S I I N N G G K K I I T T C C O O N N S S I I S S T T S S O O F F : :
•Draft Tower Assembly
•Drain Hose
•Drain Container
•Keg Coupler
•Air Line with Clamps
•Single Gauge Regulator
•Filled 5 lb. CO 2 Cylinder
T T O O O O L L S S N N E E E E D D E E D D : :
•Crescent Wrench
•Pliers
•Screwdriver
Draft Tower
Assy
Beer Line
VIKING
111 Front Street
Greenwood, Mississippi 38930 USA
(662) 455-1200
o
F., and securely fastened in the
Regulator
Keg Coupler
Pressure
(Sankey type
Gauge
shown)
Air
Line
Toggle Shut
Off Valve
Regulator
Coupling Nut
Drum Valve
Set Screw
CO 2 Tank
41006170 Rev. F
Advertisement
Table of Contents
Related Manuals for Viking VRBD/VUBD 24" W. BEVERAGE DISPENSER
Summary of Contents for Viking VRBD/VUBD 24" W. BEVERAGE DISPENSER
-
Page 1: General Information
•Pliers •Screwdriver Greenwood, Mississippi 38930 USA F., and securely fastened in the Draft Tower Assy Keg Coupler (Sankey type shown) Beer Line VIKING 111 Front Street (662) 455-1200 Regulator Regulator Coupling Nut Pressure Gauge Drum Valve Set Screw CO 2 Tank... -
Page 2: Built-In Installation
Proper Disposal of Your Old Refrigeration Product Suffocation Hazard Remove doors from your old refrigerator. Failure to do so can result in child entrapment, which can cause death or brain damage I I M M P P O O R R T T A A N N T T : : Child entrapment and suffocation are not problems of the past. - Page 3 CASTERS Your beverage dispenser is equipped with four casters. the front two casters can be locked. For built-in applications, the four casters can be removed by removing the nut located inside the dispenser cabinet and then pulling the threaded caster spindle through the base of the unit.
- Page 4 DIMENSIONS - FREESTANDING MODELS FRONT 24 5/8” (62.5 cm) 24” (61.0 cm) 12 5/16” (31.3 cm) SIDE 2 1/16” (5.2 cm) 41 25/32” (106.2 cm) 2 3/8” (6.0 cm) 2 1/2” (6.4 cm) 25 1/8” (63.8 cm) 12 7/8” (32.7 cm) 13 3/4”...
- Page 5 CABINET CUTOUT - UNDERCOUNTER MODELS *Actual dimension of drain pan is 12” x 5” (30.5 cm x 12.7 cm) This area should be cut 12 3/16” x 5 3/16” (31.0 cm x 13.2 cm) for clearance 24” (61.0 cm)* Min. 34 1/8” (87.9 cm Max.
- Page 6 DIMENSIONS - UNDERCOUNTER MODELS FRONT 23 7/8” (60.7 cm) 30 3/4” (78.1cm) 24 3/8” (61.9 cm) 5” (12.7 cm) SIDE Min 34” (86.4 cm) Max 35” (88.9 cm) with leveling legs fully adjusted 23 7/8” (60.7 cm) 4” 12” (30.5 cm) (10.2 cm) 2 11/16”...
- Page 7 ASSEMBLY 1. Screw the black faucet knob onto the faucet. 3. Attach the clear beverage line coming from the draft tower to the keg coupler. Use the black washer inside the hex nut and tighten securely with crescent wrench. 5. Attach one end of the red air hose to the hose barb on the CO 2...
- Page 8 CO 2 REGULATOR 1. Low pressure gauge. (reads the amount of internal keg pressure) 2. Adjustment lock nut. 3. Regulator adjustment screw (after keg is tapped, screw clockwise until low pressure gauge indicates between 12 & 14 lbs.) 4. Shut-off valve. 5.
- Page 9 TAPPING PROCEDURES There are two keg sizes: 1) the quarter barrel containing 7 3/4 gallons or approximately 3 1/2 cases of 12 ounce bottles or 2) the half barrel containing 15 1/2 gallons or approximately 7 cases. SANKEY TYPE KEG COUPLER (Taps all Coors , Miller...
-
Page 10: Final Preparation
DRAIN HOSE AND CONTAINER Before using the beverage dispenser, make sure the drain hose and container are properly installed. 1. Attach the hose to the drain. 2. Attach the container to the hose. 3. Empty the container when it becomes full. 4. -
Page 11: Setting The Control
W W A A R R N N I I N N G G : : E E L L E E C C T T R R I I C C A A L L G G R R O O U U N N D D I I N N G G I I N N S S T T R R U U C C T T I I O O N N S S This appliance is equipped with a three prong grounding plug for your protection against shock hazard and should be plugged directly into a properly grounded three prong receptacle. - Page 12 HOW TO DRAW THE PERFECT GLASS OF BEER 1. Start with a clean beer glass that has been wetted in cold water. Place the glass at a angle, one inch below the faucet. Do not let the glass touch the faucet. . Open the faucet all the way.
-
Page 13: Common Draft Problems
COMMON DRAFT PROBLEMS DESCRIPTION Wild Beer Beer, when drawn, is all foam, or too much foam and not enough liquid beer. Cloudy Beer When beer in glass appears hazy, not clear Flat Beer Foamy head disappears quickly; beer lacks usual zestful brewery fresh flavor False Head Large soap-like bubbles, head dissolves very quickly Unpalatable Beer... -
Page 14: Cleaning And Maintenance
If you are unable to obtain the name of an authorized service agency, or if you continue to have service problems, contact Viking at (888) 845-4641 or write to: Record the information indicated below. You will need it if service is ever required. The model and serial number for your beverage dispenser is located on the front of the unit at the base of the door frame. -
Page 15: Professional Series
W W A A R R R R A A N N T T Y Y S S E E R R V V I I C C E E : : Under the terms of this warranty, service must... - Page 16 Specifications subject to change without notice F1755F (PS0205VR)