Page 1
THIS PROCEDURE SHOULD ONLY BE PERFORMED BY AN AUTHORIzED WEBER-STEPHEN PRODUCTS LLC SERVICE TECHNICIAN WARNINg: gENUINE WEBER-STEPHEN REPLACEMENT PARTS MUST BE USED FOR ANY REPAIR OR REPLACEMENT. YOUR ACTIONS, IF YOU FAIL TO FOLLOW THIS PRODUCT WARNINg, MAY CAUSE A FIRE, AN ExPLOSION, OR STRUCTURAL FAILURE RESULTINg IN SERIOUS PERSONAL INjURY OR DEATH AS WELL AS DAMAgE TO PROPERTY.
Page 2
DISCOnneCtIOn OF HOSe FrOm GaS SOUrCe NORTH AMERiCAN GRills LP UNITS: WARNINg: Do not use a wrench to loosen the connection. Using A) Make sure gas supply is turned off at source. a wrench could damage the B) Disconnect LP cylinder from inside of cabinet base. C) Remove LP cylinder from cabinet base.
Page 6
BUrner tUBe reInStallatIOn reCOnneCt manIFOlD aSSemBlY - PHILLIPS TOOLS NEEDED: - 7/16" CAUTION: Burner tube openings (2) must be positioned properly over valve openings (3).
Page 7
WARNINg: Make sure all control knobs are turned to the OFF position before reconnecting gas supply and operating grill. Your actions, if you fail to follow this Product Warning, may cause a fire, an explosion, or structural failure resulting in serious personal injury or death as well as damage to property. COnneCtIOn OF HOSe tO GaS SOUrCe NORTH AMERiCAN GRills WARNINg: Do not use a wrench...
Contact the Customer Service Representative in your area using the contact ® information on our website. Log onto www.weber.com E) Valves-to-manifold connections (6). F) Regulator-to-cylinder connections (7) (10). g) Regulator hose-to-regulator connections (8) (11).
Page 9
COntrOl panel reInStallatIOn TOOLS NEEDED: 310 / 320 210 / 220 - PHILLIPS CHeCK IGnItOr WIreS REASSEMBLY NOTE: After completely checking igniter wires, check for igniter spark. Push down on igniter button, listen for a clicking sound, and check for a spark at ceramic igniter. If you hear a click and see a spark, igniter module is working. lID aSSemBlY anD COOKBOX COmpOnentS reInStallatIOn...
Page 10
PROPOSITION 65 WARNINg: HANDLINg THE BRASS MATERIAL ON THIS PRODUCT ExPOSES YOU TO LEAD, A CHEMICAL kNOWN TO THE STATE OF CALIFORNIA TO CAUSE CANCER, BIRTH DEFECTS OR OTHER REPRODUCTIVE HARM. (WaSh handS after handlinG thiS product.) WARNINg: Make sure all parts are assembled and hardware is fully tightened before operating the grill. Your actions, if you fail to follow this product warning, may cause a fire, an explosion, or structural failure resulting in serious personal injury or death as well as damage to property.
Page 11
Visit Visit For All of Your For All of Your Grilling Needs Grilling Needs...
Page 12
ATTENTION: This product has been safety-tested and is only certified for use in a specific country. Refer to country designation located on outside of box. These parts may be gas-carrying or gas-burning components. Please contact Weber-Stephen Products LLC Customer Service Department for genuine Weber-Stephen Products LLC replacement part(s) information.