Table of Contents
Related Manuals for HELIX 9600
Summary of Contents for HELIX 9600
- Page 1 ELIX 9600 Compressor Schematics (Low Voltage - Three Phase Cryopump Power) ©2004 Helix Technology Corporation Pub. No. 8040426, Rev. 101, 2/10/04 ECO No. 16163 Printed in USA HELIX TECHNOLOGY CORPORATION http://www.helixtechnology.com...
- Page 3 The information in this document is believed to be accurate and reliable. However, Helix Technology Corporation, cannot accept any financial or other responsibilities that may result from the use of this information. No warranties are granted or extended by this document.
-
Page 5: Table Of Contents
ELIX 9600 Compressor Schematics (Low Voltage - Three Phase Cryopump Power) Table of Contents Tables Figures Compressor Safety Schematics Introduction ............1-1 Appendix A - Customer Support Information Customer Support Center Locations . - Page 7 Table 1-4: Legend: Cryo-Torr Interface P/N 8135904P001....1-3 Table 1-5: Legend: On-Board Splitter Box P/N 8135203 ....1-4 ©2004 Helix Technology Corporation Pub. No. 8040426, Rev. 101, 2/10/04...
- Page 9 Figures Figure 1-1: 9600 Compressor, Low Voltage Schematic..... . 1-5 Figure 1-2: Autoset, Voltage Control Schematic ......1-6 Figure 1-3: Interface Cryo-Torr Box Schematic.
-
Page 11: Compressor Safety
Lockout and tagout the Compressor to prevent a remote start from occurring before attempting to service the Compressor. CAUTION This is a general caution that describes various safety hazards or unsafe practices that could result in equipment damage. ©2004 Helix Technology Corporation... - Page 12 ELIX WARNING This is a general warning that describes various safety hazards or unsafe practices that could result in personal injury or death. CAUTION Burn hazard. Allow the Compressor pump to cool before servicing the Compressor. ©2004 Helix Technology Corporation...
-
Page 13: Schematics
ELIX 9600 Compressor Schematics (Low Voltage - Three Phase Cryopump Power) Schematics Introduction The schematics in this manual support the 9600 (Low Voltage - Three Phase Cryopump Power) Compressor CTI-CRYOGENICS P/N 8135900G001. Table 1-1: Legend: Basic Control Assembly Identifier Description... -
Page 14: Table 1-2: Legend: On-Board/Cryo Electrical Module P/N 8135127G001
ELIX 9600 Compressor Schematics (Low Voltage - Three Phase Cryopump Power) Table 1-1: Legend: Basic Control Assembly (Continued) Identifier Description Open Module Signal Connector J13/P13 Phase Monitor Open Cryo Power Output Over Temperature Lockout Relay Table 1-2: Legend: On-Board/Cryo Electrical Module P/N 8135127G001... -
Page 15: Table 1-3: Legend: On-Board Output Module P/N 8135148G001
ELIX 9600 Compressor Schematics (Low Voltage - Three Phase Cryopump Power) Table 1-3: Legend: On-Board Output Module P/N 8135148G001 Identifier Description On-Board Output Receptacle Remote Control Receptacle Power Connector Signal Connector Remote Jumper Table 1-4: Legend: Cryo-Torr Interface P/N 8135904P001... -
Page 16: Table 1-5: Legend: On-Board Splitter Box P/N 8135203
ELIX 9600 Compressor Schematics (Low Voltage - Three Phase Cryopump Power) Table 1-5: Legend: On-Board Splitter Box P/N 8135203 Identifier Description J/P18 On-Board HV Input J/P19 On-Board Control Input J/P20 Compressor Remote Connector J/P21 On-Board 1 HV Connector J/P22 On-Board 2 HV Connector... - Page 17 9600 Compressor Schematics (Low Voltage - Three Phase Cryopump Power) REVISIONS DESCRIPTION DATE APPROVED REVISED PER ECO 16163 1/04 8135127G001 200-230VAC, 16A BASIC CONTROL ASSY LO VOLT 8135143G001 ON-BD/CRYO ELEC MOD 8135167G001 PHASE OR O/L; .02A GRN/YEL TRIPS BREAKER M1OL...
- Page 18 9600 Compressor Schematics (Low Voltage - Three Phase Cryopump Power) REVISIONS REVISIONS DESCRIPTION DESCRIPTION DATE DATE APPROVED APPROVED REVISED PER DEO 10972 9/19/95 POWER IN 171-250V 50/60 Hz T3(24V) 1 2 3 4 1 2 3 4 1 2 3...
- Page 19 9600 Compressor Schematics (Low Voltage - Three Phase Cryopump Power) REVISIONS REVISIONS DESCRIPTION DESCRIPTION DATE DATE APPROVED APPROVED REVISED PER DEO 10922 10/12/95 COLDHEAD 1 8135169G001 GRN/YEL COLDHEAD 2 WHT/BLU WHT/ORN COLDHEAD 3 4 5 1 6 WHT/RED WHT/ORN JUMPER/REMOTE ORCAD V4.04...
- Page 20 9600 Compressor Schematics (Low Voltage - Three Phase Cryopump Power) REVISIONS DESCRIPTION DATE APPROVED INITIAL RELEASE PER DEO 10922 11/22/95 WHT/RED WHT/ORN WHT/RED WHT/ORN WHT/RED WHT/ORN WHT/BLU WHT/RED WHT/ORN WHT/BLU 8135199G001 CON2 PROPRIETARY NOTICE DATE CTI-CRYOGENICS DRAWN HELIX TECHNOLOGY CORPORATION...
-
Page 21: Appendix A - Customer Support Information
Product Part Number • Product Serial Number • Product Application • Specific Problem Area • Hours of Operation • Equipment Type • Vacuum System Brand/Model/Date of Manufacture E-mail For your convenience, you may also e-mail us at: techsupport@helixtechnology.com ©2004 Helix Technology Corporation...