Page 2
Kondensatwannentausch MGK(-2)-390-1000 Warnhinweise: - Kondensatwannentausch darf nur durch Fachmann durchgeführt werden - Die Gasdichtigkeit ist nach der Montage zu überprüfen - Bei unsachgemäßer Montage besteht durch Abgasaustritt Vergiftungsgefahr Inhalt Set für Kondensatwannentausch • Kondensatwanne • Silikon „Silirub“, in Karton in der Kondensatwanne •...
Page 3
Kondensatwannentausch MGK(-2)-390-1000 Demontage Kondensatwanne - Stempelwagenheber ansetzen. Vorne unter dem Rücklaufrohr. Hinten unter der Zugstange. - Schrauben am Gasrohr entfernen (1). - Die 2 bzw. 3 Verbindungsschrauben an den oberen beiden Quertraversen ausbauen. Stempelwagenheber unter Rücklaufrohr - Vorsichtig anheben (mind. 3mm), bis die Silikonnaht der Wanne reißt.
Page 4
Kondensatwannentausch MGK(-2)-390-1000 Neue Kondensatwanne einbauen • Silikon umlaufend auftragen (dicke Silikonraupe) Grund: Zwischen Wanne und dem Wärmetauscher ist später 3mm Spiel, das mit dem Silikon ausgefüllt werden müssen Kondensatwanne und Gerät in umgekehrter Reihenfolge montieren Montage Abgas-Druckschalter Schwarze Verschlußkappe von der Schlauchtülle abziehen.
Page 6
Changing the condensate pan MGK(-2)-390-1000 Warnings: - The condensate pan should only be changed by a specialist - Check for gas leaks after installation - There is a risk of poisoning from gas leaks if installed incorrectly Contents set for changing the condensate pan •...
Page 7
Changing the condensate pan MGK(-2)-390-1000 Removing the condensate pan - Put the jacks in place. At the front beneath the return pipe. Beneath the connecting rod. - Remove the screws on the gas pipe (1). - Remove the 2 or 3 connecting screws on the top 2 crosspieces.
Page 8
Changing the condensate pan MGK(-2)-390-1000 Install the new condensate tray • Apply a thick bead of silicone around the tray. There will be 3mm of play between the pan and heat exchanger which must be filled with silicone. Install the condensate pan and equipment in reverse order Installing the flue gas pressure switch Remove the black cap from the hose nipple.