Ranger RS-500-D-601 Installation And Operation Manual page 3

Table of Contents
Introduction
Shipping Information
Safety Considerations
Specifications
Components
FAQ
Setup
Introduction
This manual describes these Spray-Wash Cabinet models:
• RS-500-D-601: 1 Phase Spray-Wash Cabinet with 500 pound (227 kg) load capacity.
• RS-750-D-601: 1 Phase Spray-Wash Cabinet with 1,000 pound (454 kg) load capacity.
• RS-500-D-503: 3 Phase Spray-Wash Cabinet with 500 pound (227 kg) load capacity.
• RS-750-D-503: 3 Phase Spray-Wash Cabinet with 1,000 pound (454 kg) load capacity.
The RS-500-DS-601 and RS-750-DS-601 models are a Stainless Steel alternative to the Powder-Coat
models; there are no differences in operation between the Powder-Coat models and Stainless Steel
models.
More information about the full line of Ranger Products is available at rangerproducts.com.
⚠
WARNING
⚠
CAUTION
This manual is mandatory reading for all Spray-Wash Cabinet users
who sets them up, operates, maintains, or repairs them.
⚠
DANGER
Keep this manual on or near the equipment so that anyone who uses or services it can read it.
RS Series Spray-Wash Cabinets
3
4
4
6
7
10
11
certified, licensed Electrician
Always use a
incorrectly could result in human injury or product damage.
Only use Detergent formulated for mild steel parts washers; Aluma-Klean, for
example, which is available from
high PH, caustic detergents that are formulated for harsher cleaning environments;
hot dip tanks, for example. This voids your warranty and may cause significant
damage to your unit.
Be very careful when setting up, operating, maintaining, or repairing this equipment;
failure to do so could result in property damage, product damage, injury, or (in very
rare cases) death. Make sure only authorized personnel operate this equipment. All
repairs must be performed by an authorized technician. Make sure to read and
follow the instructions on the labels on the unit.
Operation
Maintenance
Troubleshooting
Wiring Diagram
Labels
Parts Diagrams
Maintenance Log
the Ranger website.
3
P/N 5900245 — Rev. B7 — November 2019
for electrical work. Wiring the unit
Do not
use high alkaline,
, including anyone
13
16
19
21
25
29
37