Ebe23*/Eue23* Wiring Diagram - Johnson Controls EBE23A Installation Manual

BLK (3)
ORG (4)
GRN(14)
YEL (6)
WHT
H4
H3
BLK
HEAT
ELEMENTS
NOTE: IF ANY OF THE ORIGINAL WIRE
SUPPLIED WITH THIS UNIT MUST BE
REPLACED. IT MUST BE REPLACED
WITH TYPE 105 C THERMOPLASTIC
THIS FURNACE MAY BE CONNECTED TO MORE THAN ONE POWER SUPPLY.
TURN OFF ALL POWER TO THE FURNACE AT THE WALL BOX, AND LOCK IT OUT.
IMPORTANT -
FIGURE 18: EBE23*/EUE23* Wiring Diagram
Subject to change without notice. Published in U.S.A.
Copyright © 2019 by Johnson Controls. All rights reserved.
ECM ELECTRIC FURNACE - 23kW
4
(HIGH)
C
5
3
(MED/HIGH)
L
4
BLOWER
2 (MED)
G MOTOR 3
WHT (10)
(LOW/MED)
1
2
N
GRN (12)
(LOW)
1
YEL(13)
GRN(12)
ORG (4)
XFMR
YEL(6)
LINE
LOAD
BLK(3)
YEL(7)
BLK(1)
SEQUENCER
RED
RED
WHT
YEL
YEL
M7 H2 M3
M5
M1
M2
M4
M8 M6 H1
YEL
BLK
YEL
L ORG
R
L
ORG
R
L BLK
R 0 1
L BLK
4 8
R
LIMIT
2 6
SWITCHES
RELAY
DO NOT OPEN THIS PANEL UNTIL ELECTRICAL POWER IS SHUT
OFF AT HOUSEHOLD SERVICE BOX. CHECK WITH A VOLTMETER
OR OTHER PROPER INSTRUMENT.
- HAZARD OF ELECTRICAL SHOCK -
SERVICE CONNECTION COVER MUST BE INSTALLED.
IF FILTERS ARE USED, CLEAN/REPLACE EACH SEASON
OR MORE OFTEN AS NEEDED.
York International Corp.
LINE VOLTAGE
YEL(13)
FIELD SUPPLY POWER
LOW VOLTAGE
FIELD INSTALLED CONTROL
WHT(11)
FUSE
RED(8)
3A
BLK(2)
WIRING MUST
CONFORM TO
LOCAL CODES
CIRCUIT #1
GND
BREAKER
CIRCUIT 1
240 VAC.
60Hz
1 PHASE
D.O.E. OUTPUT CAPACITY - BTU
DUAL BRANCH
MAX. MOTOR-FLA
CIRCUIT SERVICE
SINGLE BRANCH
CIRCUIT SERVICE
CIRCUIT 2
240 VAC.
NOMINAL CIRCUIT LOAD-AMPS
60Hz
1 PHASE WIRE SIZE (75 C) COPPER
CIRCUIT #2
GND
BREAKER
WIRE SIZE (60 C) COPPER
MAX. FUSE SIZE
(OR CB) - AMPS
BLK
BRN
DUAL BRANCH
0 1
CIRCUIT SERVICE
4 8
BRANCH CKT. LOAD-AMPS
2 6
BRANCH CKT. MIN. AMPACITY
RELAY
WIRE SIZE (75 C) COPPER
REPLACE FILTER WIRE SIZE (60 C) COPPER
WITH SAME SIZE
MAX. FUSE SIZE
(OR CB) - AMPS
REQUIRES JUMPER BARS (P/N 3500-378/*)
WARNING
HIGH VOLTAGE
SHOCK HAZARD
CAUTION
5005 York Drive
Norman, OK 73069
HEAT/COOL
T'STAT
Y
G
W
R
CONDENSING UNIT
CONTACTOR
SINGLE BRANCH CIRCUIT SERVICE
CIRCUIT #1
BREAKER
240 VAC.
60Hz
1 PHASE
CIRCUIT #2
GND. LUG
BREAKER
240 VAC - 60 Hz - 1 PHASE
77,000
3.8
2 LEADS +
1 GROUND
93.8
#1
#0
125
4 LEADS +
2 GROUNDS
CKT #1 CKT #2
47.1 46.7
58.9 58.4
#6 #6
#4 #4
60 60
5395389-UWD-A-0717
Supersedes: 5396713-BIM-B-0618
5396713-BIM-C-0319