Power Transmission; Brakes - Volvo 164 Instruction Book

Replacing the bulbs for the
number plate light
The two bulbs for the number plate light
are mounted on a holder located under the
l uggage compartment locking device.
Loosen the two screws which hold the
glass and remove it. The bulb is now
accessible for changing.

POWER TRANSMISSION

33 Check the clutch yoke free travel
To avoid risk of the clutch slipping, the
clutch yoke free travel should be checked
and adjusted if necessary every 10 000 km
(6000 miles). If the clutch does not disen-
gage in a satisfactory manner, the free
travel of the clutch pedal should also be
checked. For data see page 59.
The clutch should be checked and
adjusted at a workshop which has the
proper equipment.
34 Check the propeller shaft
After every 10 000 km (6000 miles) or once
a year the rubber seal on the spline shaft
and the universal joints should be checked.
I f the rubber seal is damaged, it should be
replaced and the new seal filled with
molybdenum disulphide grease.
SERVICING

BRAKES

35 Check and overhaul the brakes
After every 10 000 km (6000 miles) the
vehicle should be taken to a Volvo work-
shop for a check on the functioning of the
brakes. Every third year or 60 000 km
(36 000 miles) the brake system seals
should also be replaced.
36 Replacing the booster cylinder air filter
Every 40 000 km (25000 miles) the car
should be taken to a Volvo workshop for
replacement of the booster cylinder air
and damper filters.
49