Start Up Sheet - York TM8V C Series Installation Manual

SECTION XI: START UP SHEET
Proper furnace start up is critical to customer comfort and equipment longevity
Start-Up Date
Technician Performing Start-Up
Owner Information
Name
City
Equipment Data
Furnace Model
Evaporator Coil Model
Outdoor Unit Model
Furnace Configuration
Upflow Downflow
Filter, Thermostat, Accessories
Filter Type
Thermostat Type
Connections -- All Per Installation Instructions and Local Code
Unit is level Gas piping is connected (including drip leg)
Vent system is connected
Venting: B Vent
Vent Pipe Size
Vertical Termination
Connector Size
Horizontal Term. (with External Power Vent)
Venting: Lined Masonry Chimney
B Vent Connector
# of 90 Degree Ells
Venting system is the proper size, within the limitations of the chart in the
installation instructions, properly connected to the furnace, and properly pitched
Electrical: Line Voltage
Polarity is correct (black is L1 (hot), white is N (neutral)
Electrical: Low Voltage
Thermostat wiring is complete
Low voltage value between "R" and "C" on furnace control board (volts AC)
Thermostat:
Thermostat Staging:
Johnson Controls Unitary Products
33" 80% AFUE Two Stage Gas Furnace Start Up Sheet
State or Province
Horizontal Left
Filter Size
Other System Equipment and Accessories
# of 90 Degree Ells
Connector Length
Vent Pipe Size
Single Wall Connector
Connector Size
# of 45 Degree Ells
Thermostat heat anticipator set to .4 (6 cycle per hour for electronic thermostats )
OFF 10 MIN 15 MIN
Installing Contractor Name
Address
Furnace Serial
Evaporator Coil Serial
Outdoor Unit Serial
Horizontal Right
Filter Location(s)
Supply plenum and return air are connected
# of 45 Degree Ells
# of 90 Degree Ells
Connector Length
Other appliances in same common vent:
Water Heater
Furnace
Other
Ground wire is connected
20 MIN
5402847-UIM-A-0917
Zip or Postal Code
Total Height
# of 45 Degree Ells
Chimney Height
BTUH Input Fan Assisted?
BTUH Input Fan Assisted?
BTUH Input Fan Assisted?
Line voltage to furnace (AC)
Continued on next Page
Y N
Y N
Y N
33