Table of Contents
Related Manuals for Toyota Celica
Summary of Contents for Toyota Celica
- Page 1 T O Y O T A N A V I G A T I O N S Y S T E M INSTALLATION INSTRUCTIONS PART NUMBER 08545-00803 NAVIGATION KIT PART N° Manual Ref. Nr.N1RT23-0-00 TOYOTA MOTOR CORPORATION Downloaded from www.Manualslib.com manuals search engine...
-
Page 2: Precautions
• Check body and trim near area of installation to be certain no dirt or scratches resulted from the installation. • Confirm that lamps, horn, wiper and other car accessories operate normally. 09-99 Celica (RHD) - 2 Downloaded from www.Manualslib.com manuals search engine... -
Page 3: Table Of Contents
Installation of the GPS Antenna ............................Wire Harness Installation ............................... Installation of the Computer ............................Monitor Installation ................................. Wire Harness Connection ............................... Storage of the Remote Control ............................System Start Up ................................Celica (RHD) - 3 09-99 Downloaded from www.Manualslib.com manuals search engine... -
Page 4: Required Parts/Subkits
TM4000 (08600-00888) 18401 (86100-20510) 08545-00803 58408 (86100-60080) TM0461 (08601-00879) Radio/Cassette + CD-Changer TF4301 (08600-00922) W/H (08695-00260) 08545-00803 + Navigation TM4000 (08600-00888) 18401 (86100-20510) 08545-00803 TM0461 (08601-00879) W/H (08695-00260) 58408 (86100-60080) 09-99 Celica (RHD) - 4 Downloaded from www.Manualslib.com manuals search engine... -
Page 5: Navigation System Assy
WIRE TIE EARTH PLATE ANCHOR BOLT BOLT (M5 x 16) BOLT (M5 x 20) HOLD BRACKET ADHESIVE TAPE 1: NAVIGATION DISC (CD-ROM) is not included in the navigation kit. Celica (RHD) - 5 09-99 Downloaded from www.Manualslib.com manuals search engine... - Page 6 In cases where the CD-Changer is installed together with the navigation system, the wire harness n° 08695-00260 is needed (See page 7). The wire harness is not included in the navigation kit. 09-99 Celica (RHD) - 6 Downloaded from www.Manualslib.com manuals search engine...
-
Page 7: Wire Harness
Celica TNS 500 WIRE HARNESS 08695-00260 For CD- and MD-Changer only Celica (RHD) - 7 09-99 Downloaded from www.Manualslib.com manuals search engine... -
Page 8: Installation Overview
Antenna Wire Audio Assembly Wire Harness Computer (to the Deck Floor Box) WIRE HARNESS SUB-ASSY - SPEED LINE (VIOLET/WHITE) WIRE HARNESS ANTENNA WIRE WIRE HARNESS REVERSE SENSOR WIRE (RED/BLUE) 09-99 Celica (RHD) - 8 Downloaded from www.Manualslib.com manuals search engine... -
Page 9: How To Connect
The wire harness connection depends on the type of audio; for more details see pages 10 - 11 - 12. Note : CD-Changer installation To connect the CD-Changer an additional subwire harness (08695-00260) is required. See page 7. Celica (RHD) - 9 09-99 Downloaded from www.Manualslib.com... -
Page 10: Fujitsu Ten Audio Unit (With Avc-Lan)
AUDIO ASSY + NAVIGATION SYSTEM + CD-CHANGER Audio Assy DIN 13P (No use) Antenna * 08695-00260 Disconnect Reverse signal CD-Changer To CD-Changer unit wire * 08695-00260 To be ordered separately 09-99 Celica (RHD) - 10 Downloaded from www.Manualslib.com manuals search engine... -
Page 11: Matsushita Audio Unit (With Avc-Lan)
AUDIO ASSY + NAVIGATION SYSTEM + CD-CHANGER Audio Assy DIN 13P (No use) Antenna * 08695-00260 Reverse signal Connection WIRE HARNESS CD-Changer wire To CD-Changer unit * 08695-00260 To be ordered separately Celica (RHD) - 11 09-99 Downloaded from www.Manualslib.com manuals search engine... -
Page 12: Audio Units With 13Pin Connector (Without Avc-Lan)
AUDIO ASSY + NAVIGATION SYSTEM + CD-CHANGER Audio Assy DIN 13P (No use) Antenna * 08695-00260 Connection No use Reverse signal WIRE HARNESS CD-Changer wire To CD-Changer unit * 08695-00260 To be ordered separately 09-99 Celica (RHD) - 12 Downloaded from www.Manualslib.com manuals search engine... -
Page 13: Vehicle Disassembly
Figure 1 FOR M/T MODELS Remove the shift knob and console panel Figure 2 FOR VEHICLES WITH AUTO AIR CONDITIONER Remove the center cluster : Screws (2x) Figure 3 Celica (RHD) - 13 09-99 Downloaded from www.Manualslib.com manuals search engine... - Page 14 Remove the heater control knobs and center cluster : Screws (2x) Figure 4 Remove the covers : Bolts (4x) Figure 5 Remove the front pillar garnish RH Figure 6 09-99 Celica (RHD) - 14 Downloaded from www.Manualslib.com manuals search engine...
- Page 15 (RH) : Nut Figure 7 Remove the deck floor box (RH) : Hook : Bolts (2x) Figure 8 Remove the luggage front box : Clips (2x) Figure 9 Celica (RHD) - 15 09-99 Downloaded from www.Manualslib.com manuals search engine...
- Page 16 Celica TNS 500 Remove the rear seat back : Bolts (4x) Figure 10 Remove the rear seat cushion : Hooks (2x) Figure 11 09-99 Celica (RHD) - 16 Downloaded from www.Manualslib.com manuals search engine...
-
Page 17: Installation Of The Gps Antenna
CAUTION: To insert the antenna cord between the wind shield and yy yy instrument panel, use minus screw- driver mentioned above. yy yy Antenna Cord Figure 14 Celica (RHD) - 17 09-99 Downloaded from www.Manualslib.com manuals search engine... -
Page 18: Wire Harness Installation
2. Make a splicing connector as shown in the left figure. Splicing Connector Pliers Vehicle Wire Harness Figure 16 Locate and disconnect the 20P con- nector from the center J/B. 20P Connector (white) Figure 17 09-99 Celica (RHD) - 18 Downloaded from www.Manualslib.com manuals search engine... - Page 19 INSTALLATION Splicing Connector Pliers Vehicle Wire Harness Figure 19 Locate and disconnect the 8P connec- tor (black) at the top of the center J/B. 8P Connector (black) Figure 20 Celica (RHD) - 19 09-99 Downloaded from www.Manualslib.com manuals search engine...
- Page 20 Figure 22 Cut one tape ) into 2 equal sized pieces. tape (tape and tape are exactly the same tape) Figure 23 09-99 Celica (RHD) - 20 Downloaded from www.Manualslib.com manuals search engine...
- Page 21 Adjust the length of the antenna cord, Antenna Cord and affix it after routing the cord to the and Wire Harness yyy yy yy computer procedures in (6). yy yyy yy yy Tape Figure 26 Celica (RHD) - 21 09-99 Downloaded from www.Manualslib.com manuals search engine...
- Page 22 CAUTION: Route the antenna cord securely in between the trim, so that Antenna Cord and it does not show. Wire Harness Figure 27 09-99 Celica (RHD) - 22 Downloaded from www.Manualslib.com manuals search engine...
-
Page 23: Installation Of The Computer
Deck Floor Box (RH) CAUTION: Connect the connectors before affixing the computer Affix the computer to the deck floor box RH following the dimension shown in the illustration. Figure 30 Celica (RHD) - 23 09-99 Downloaded from www.Manualslib.com manuals search engine... - Page 24 Slit the luggage carpet at the computer installation position. Computer installing part 20mm Figure 31 Install the computer at the left rear position of the luggage room. Asphalt Seat (Right Side) 30mm Slit Figure 32 09-99 Celica (RHD) - 24 Downloaded from www.Manualslib.com manuals search engine...
-
Page 25: Monitor Installation
Even if the hinge of the connector is broken, the perfor- mance does not charge. Do not reuse the connector. Cord color : violet/white Wrap the urethane tape around to hold the harness. Bild 33 - Figure 33 Celica (RHD) - 25 09-99 Downloaded from www.Manualslib.com manuals search engine... - Page 26 Panel (L) Audio Assembly Panel (R) Figure 35 After connecting wire harness to moni- and audio assembly, install the monitor and audio assembly. : Bolts (4x) Audio Assembly Figure 36 09-99 Celica (RHD) - 26 Downloaded from www.Manualslib.com manuals search engine...
-
Page 27: Wire Harness Connection
Vehicle Wire Harness Figure 38 Connect the wire harness sub-assy to the monitor 12P connector and the audio assy. Wrap the 12P connector in the foam To Audio assy Figure 39 Celica (RHD) - 27 09-99 Downloaded from www.Manualslib.com manuals search engine... - Page 28 * 08695-00260 To Changer wire Figure 41 FOR FUJITSU TEN AUDIO UNITS To Audio assy * 08695-00260 To monitor Disconnect the 1P connectors. Disconnect Figure 42 To Changer wire 09-99 Celica (RHD) - 28 Downloaded from www.Manualslib.com manuals search engine...
- Page 29 Celica TNS 500 Secure the 1P connectors with wire To Audio assy * 08695-00260 To monitor To Changer wire Figure 43 Celica (RHD) - 29 09-99 Downloaded from www.Manualslib.com manuals search engine...
-
Page 30: Storage Of The Remote Control
Attach the “hard” part of the Velcro the mid console. Figure 45 HIDE AWAY STORAGE Attach the “hard” part of the Velcro the inside of the glove compartment. Figure 46 09-99 Celica (RHD) - 30 Downloaded from www.Manualslib.com manuals search engine... -
Page 31: System Start Up
1. Attach the (-) terminal of the battery and turn the key to the ACC or ON posi- tion or start the engine. a) Press the OPEN button to eject the dis- play. Figure 48 Celica (RHD) - 31 09-99 Downloaded from www.Manualslib.com manuals search engine... - Page 32 Celica TNS 500 The display will slide out. Figure 49 Raise the display by hand. Figure 50 An image will appear on the screen. TOYOTA NAVIGATION SYSTEM Figure 51 09-99 Celica (RHD) - 32 Downloaded from www.Manualslib.com manuals search engine...
- Page 33 6. Set the system to the customers language by following the section on “language setting” in the Navigation System Owner’s Manual. NOTE : In case of any abnormality, please refer to the “TOYOTA Navigation System Troubleshooting Guide”. 7. Take the vehicle for a test drive and confirm that the map scrolls automatically.
- Page 34 Celica TNS 500 NOTES ..............................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................................09-99 Celica (LHD) - 34 Downloaded from www.Manualslib.com manuals search engine...
- Page 35 GENUINE PARTS Downloaded from www.Manualslib.com manuals search engine...