Troubleshooting Of The Connectors; For Products With S/N: Lil -2015080000, Lir -2015100000 - Husqvarna 536LiL Workshop Manual

Symptom
A green lamp on the charger comes
on for approximately 5-10 seconds
when the battery is attached. After
that a red warning sign flashes on the
charger. This sequence then occurs
again.

6.9 Troubleshooting of the connectors

6.10 For products with S/N: LiL
-2015080000, LiR -2015100000
6.10.1 Power connectors
Make sure connectors are clean and that metal surfaces
are not damaged.
Note: The connection tabs on the power connectors
have the same construction on product, battery and
charger. The colors can be different.
6.10.2 Keypad connector
Make sure that the 2 connector parts are fully attached.
Look for damaged or loose cables.
6.10.3 Signal connector for the main switch
For products with S/N up to: LiL -2015080000
Make sure the white female connector is fully attached
to the main switch. Look for damaged or loose cables.
737 - 002 - 25.10.2018
Possible causes
Defective Battery.
Defective charger.
Also look for signs of water, corrosion or short circuit on
the connector and pins when disassembled.
6.10.4 Communication cables
Make sure that the 3 small communication cables are
not loose or damaged.
6.10.5 Motor connector
Make sure that the motor connector is assembled
correctly.
Recommended step
Put the battery in a QC330 charger. If
the same problem occurs, replace the
battery.
Put a battery in the charger. If the
same problem occurs, replace the
charger.
Troubleshooting - 43