Page 1
° MODEL NUMBER 917.373981 • Assembly • Operation • Customer Responsibilities • Service • Adjustments • Repair Parts Caution: Read and Follow all Safety Rules and Instructions Before Operating This Equipment 144815 03/21/94 OWNER'S MANUAL OConvertible Printed in U.S.A.
PLUG TO PREVENT ACCIDENTAL STARTING WHEN SETFING UP, TRANSPORTING, ADJUSTING OR MAKING CAUTION: ALWAYS DISCONNECTSPARK PLUGWIRE ANDPLACEWlRE WHERE IT CANNOT CONTACT SPARK REPA, SAFETY STANDARDS REQUIRE OPERATOR SUCH CONTROLS. DO NOT A'I-rEMPT STANCES, TRAINING: Read this operator's manual carefully. the controls and know how to operate your mower properly. Learn-how to quickly stop mower.
LIMITED TWO YEAR WARRANTY ON CRAFTSMAN POWER MOWER For two years from date of purchase, when this Craftsman Lawn Mower is maintained, according to the operating and maintenance instructions in the owner's manual, Sears will repair free of charge any defect in material or workmanship.
Page 4
CuttingLevels... 9 ... 2 MAINTENANCE SERVICE AND ADJUSTMENTS ... 3, 12-14 STORAGE ... TROUBLESHOOTING REPAIR PARTS - LAWN MOWER ... 18-22 REPAIR PARTS - ENGINE ... PARTS ORDERING/SERVICE Engine: Air Filter... 14 Oil Change ... 14 Oil Level ... 14 Oil Type ...
These accessories were available when this lawn mower was produced. They are also available at most Sears retail outlets and service centers. Most Sears stores can also order repair parts for you, when you provide the model number of your lawn mower.
MOWING POSITION LOWER HANDLE FIG. 1 TO CONVERT MOWER Your lawn mower was shipped ready to be used as a mulcher. To convert to bagging or discharging: REAR BAGGING (See Fig. 2A) - • Open rear door and remove mulcher plug.
Page 7
Lift the rear door on the mower housing and place the dgrass catcher frame onto the formed tabs on the rear oor hinge bracket. The grass catcher is secured to the lawn mower housing when the rear door is lowered onto the grass catcher frame. SEWN...
MULCHER PLUG ENGINE OIL CAP WfDIPSTICK SiDE DISCHARGE WHEEL ADJUSTER (ON EACH WHEEL) Sears rotary walk-behind power lawn mowers conform to the safety standards of the American National Standards Institute and the U.S. Consumer Product Safety Commission. OPERATOR PRESENCE CONTROL down to the handle to start the engine.
TO CONVERT MOWER Your lawn mower was shipped ready to be used as a mulcher. To convert to rear bagging or side discharging, see "TO CONVERT MOWER" in Assembly section of this manual.
STARTING ENGINE OIL (See Fig. 10) Your lawn mower is shipped without oil in the engine. Be sure mower is level and area around oil fill is clean. Remove engine oit cap w/dipstick and fill to the full line on the dipstick.
• For best results, adjust the lawn mower cutting height so that the lawn mower cuts off only the tcp one-third of the grass blades (See Fig. 11). overgrown it will be necessary to raise the height of cut to reduce pushing effort and to keep from overloading the engine and leaving clumps of mulched grass.
4-Charge 48 hours at end of season. GENERAL RECOMMENDATIONS The warranty on this lawn mower does not cover items that have been subjected to operator abuse or negligence. To receive full value from the warranty, operator must maintain mower as instructed in this manual,...
• Disconnect spark plug wire from spark plug and place wire where it cannot come in contact with spark plug. • Turn lawn mower on its side. Make sure air filter and carburetor are up. • Use a wood block between blade and mower housing to prevent blade from turning when removing blade bolt.
• Remove engine oil cap; lay aside on a clean surface, • Tip lawn mower on its side and drain oil into a suitable container. Rock lawn mower back and forth to remove an}, oil trapped inside of engine, •...
The rear deflector, attached between the rear wheels of your lawn mower, is provided to minimize the possibility that objects will be thrown out the rear of the lawn mower into the operator's mowing position. becomes damaged, it should be replaced.
SERVICE AND ADJUSTMENTS (See Figs. TO ADJUST HANDLE Your lawn mower handle canbe raised or lowered for your mowing comfort. Four (4) positions are available: medium high, medium low and low. Handles are shipped mounted in the medium low position.
30 days or more. LAWN MOWER When lawn mower is to be stored for a period of time, clean it thoroughly, remove all dirt, grease, leaves, etc. Store in a clean, dry area.
Page 18
REPAIR PARTS CRAFTSMAN 22" ROTARY LAWN MOWER MODEL NUMBER 917,373981 ____...
Page 19
141763 144815 Available accessories 71 33723 71 33623 71 33500 7"133300 7"133417 7"133316 NUMBER 917.373981 PART DESCRIPTION Guide Clip Lawn Mower Housing (Incl. Key #14,15,51 &52) Blade Adapter Blade 22" Hardened Washer Helical Washer 3/8-24 x 1-3/8 Grd. 8 Hex Head Machine Screw 3/8-24 x 1-3/8 Grd. 8...
Page 20
REPAIR PARTS CRAFTSMAN 22" ROTARY LAWN MOWER MODEL NUMBER 917.373981...
Page 21
REPAIR PARTS CRAFTSMAN 22" ROTARY LAWN MOWER MODEL NUMBER 917.373981 PART DESCRIPTION 48029 Drive Head Kit 137076 Drive Control 69180 Locknut #10-24 750029 Pan Head Machine Screw 137078 V-Belt 700875 Carriage Bolt 1/4-20 x 2-3/4 85179 Retainer Clip 77400 Hubcap...
Page 22
REPAIR PARTS 22" ROTARY LAWN MOWER - - MODEL NO. 917.373981 GEAR CASE ASSEMBLY PART NUMBER PART DESCRIPTION 1749O416 Tapping Screw 1/4-20 x 1-1/4 137055X004 Engagement Bracket 137053 Shifter 57072 Seal 702710 Grooved Pin 1/8 x 5/8 48373 Gear Case Halves Kit (Includes Key Nos.
Page 24
CRAFTSMAN 4-CYCLE ENGINE REF PART NO. NO. DESCRIPTION 36478 Cylinder (Includes Ref. #2 and 20) Dowel Pin 26727 33734 Breather Element 34214A Breather Assembly (Includes Reference #6, 8, 9, 12 and 12B) 33735 * Breather Gasket 3O2OO Screw #10-24 x 9/16 33886 Breather Tube 12B 34695 _...
Page 25
CRAFTSMAN 4-CYCLE ENGINE CARBURETOR NO. 632681 REWIND STARTER NO. 590702 REWIND STARTER NO. 590637 MODEL NO. 1 43.945504 REF PART DESCRIPTION NO. NO. 632681 Carburetor, Complete (Includes Ref. #184 of Engine Parts List) 631615 Throttle Shaft and Lever Assembly 631767 Throttle Retum Spring 631184 Dust Seal Washer...
Page 26
The model number for your engine will be found on the blower housing of the engine. All parts listed herein may be ordered from any Sears, Roebuck and Co. Service Center/Department Retail Stores.