Hot Water - Electric Powered - Electric Heated Operator’s Manual Pressure Washer Operating Instructions (ENG) MODELS: HDS 4.0/20 E Ec 1.109-075.0 HDS 4.0/30 E Ec 1.109-076.0 HDS 4.0/20 E Ef 1.109-956.0 IE NT HDS 4.0/30 E Ef E- EA O FF IN T 1.109-957.0...
NOTE: The manual part number is located on the Sales Representative: lower right corner of the front cover. The model and serial number will be found on a decal attached to the pressure washer. Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
à la and/or property damage. propriété ou des blessures graves. Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
Page 6
Cet équipement tion and knowledge of the machine. doit être utilisé uniquement par des opérateurs 17. Karcher will not be liable for any changes made to formés. our standard machines, or any components not 9. Never make adjustments on machine while it is in purchased from Karcher.
AVERTISSEMENT: Ne pas utiliser sous le plancher du garage ou au-dessous du niveau du sol. Follow the maintenance instructions specified in the manual. Suivre les instructions d'entretien spécifiées dans le manuel. Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
Page 8
E’ TA Nipple Variable Inlet Pressure Spray Connector Control Wand Water Supply Handle Hose Small High Pressure (not included) Hose Trigger Swivel Connector Heat Exchanger Detergent Bucket (Not included) High Pressure Hose Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
NOTE: If trigger on spray gun is released for more than 2 minutes, water will leak from the pump protector. Warm water will discharge from pump protector onto floor. This system prevents internal pump damage. Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
However, this will stop after temperature is reached. approprié à la borne étiquetée Leave main power on to the machine to ensure hot water on pump start up. L1, L2 et L3. Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
Page 11
AVERTISSEMENT: Ces machines d'abord mettre le dispositif de sont conçues pour une utilisa- sécurité sur la détente du tion à l'intérieur. La machine doit pistolet pulvérisateur. être entreposée à l'intérieur lorsqu'elle n'est pas utilisée. Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
NOTE: High pressure nozzle must be inserted at end of wand to obtain replacing hoses, wand and high pressure. To apply soap read Detergents & General Cleaning nozzles, move switch to OFF Techniques section. position, open spray gun to release pressure before removing discharge hose. Karcher HDS Operator’s Manual 9.800-967.0 - C...
Apply detergent to work area. Do not allow detergent to dry on surface. These chemicals will harm the machine and will damage the surface being cleaned. Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
CAUTION: With machine off, open spray gun to release pressure before removing discharge hose. ATTENTION: Avec la machine hors tension, ouvrir le pistolet pulvérisateur pour relâcher la pression avant de retirer le tuyau de refoulement Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
Change oil in pump crankcase. Note the condition of the oil when drained. If found to be creamy, water seals in pump may have to be removed and replaced. Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
Annually if there is any sense of wear Grease Motor Every 10,000 hours Inspect Heater Module Tank Water Level Weekly Oil Change Record Date Oil Changed Estimated Operating Month/Day/Year Hours Since Last Oil Change Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
Water sprayed at machine machine. PRESENCE OF WATER High humidity in air Check and change oil twice as often. IN PUMP OIL Piston packing worn. Oil seal worn Check and replace if necessary. Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
Page 18
Bypass pressure unloader by wiring PUMP RUNNING NORMALLY BUT spray gun open. If good PSI, turn LOW WATER PRESURE Faulty pressure unloader machine off and replace regulator. DO NOT RELEASE SPRAY GUN WHILE BYPASSING UNLOADER. Karcher HDS Series Operator’s Manual 9.800-967.0 - C...
Page 19
Tip worn- the GPM may be greater Replace tip. than expected with a worn tip Bad gauge - the pressure may be Replace gauge. higher than the gauge shows Karcher HDS Series Operator’s Manual 9.800-967.0 - C...