Quadra-Fire 810-02901 Owner's Manual page 2

Castile Pellet Insert
Hearth & Home Technologies welcomes you to our
tradition of excellence! In choosing a Quadra-Fire
appliance, you have our assurance of commitment
to quality, durability, and performance.
This commitment begins with our research of the
market, including 'Voice of the Customer' contacts,
ensuring we make products that will satisfy your
needs.
Our Research and Development facility then
employs the world's most advanced technology
to achieve the optimum operation of our stoves,
inserts and fi replaces. And yet we are old-fash-
ioned when it comes to craftsmanship. Each unit
is meticulously fabricated and are hand-fi nished for
lasting beauty and enjoyment.
Our pledge to quality is completed as each model
undergoes a quality control inspection.
design, to fabrication, to shipping: We wish you
and your family many years of enjoyment in the
warmth and comfort of your hearth appliance.
Thank you for choosing Quadra-Fire.
NOTE: Consult
insurance carrier, local
building inspector, fi re
offi cials or authorities
having jurisdiction over
restrictions, installation
inspection and permits.
Page 2
From
SAMPLE OF SERIAL NUMBER & DATE OF MANUFACTURE LABEL
CAUTION
ATTENTION:
Report / Rapport
Tested and Portland
O-T L
Oregon USA
Listed by
#061-S-42-2
C US
OMNI-Test Laboratories, Inc.
DO NOT REMOVE THIS LABEL
2009 2010 2011
NE PAS ENLEVER L'ÉTIQUETTE
JAN FEB MAR APR MAY JUNE JULY AUG SEPT OCT NOV DEC
Test Lab &
Mfg Date
Rpt Nbr.
250-7251G
SAMPLE OF CLEARANCE TO COMBUSTIBLES LABEL
LOCATION: On beaded chain behind right access
panel. Panel hinges open.
SAFETY LABEL
Portland
Tested and O-T L
Listed by Oregon USA
C US
OMNI-Test Laboratories, Inc.
Castile Pellet Insert
Report No.
#061-S-42-2 Input Rating: 30,000 BTU/HR.
Electrical Rating: 115 VAC, 60 Hz, Start 4.1 Amps, Run 1.1 AMPS.
Listed Solid Fuel Room Heater/Pellet Type Insert. Also suitable for Mobile Home Installation. This
appliance has been tested and listed for use in Manufactured Homes in accordance with OAR
814-23-9000 through 814-23-909.
Tested to: ASTM E-1509-95, ULC S628-93, ULC /ORD-C1482-M1990 Room Heating Pellet Burning Type,
(UM) 84-HUD FOR USE ONLY WITH PELLETIZED WOOD OR SHELLED FIELD CORN FUEL.
Route power cord away from unit. Do not route cord under or in front of appliance.
MINIMUM CLEARANCES TO COMBUSTIBLE MATERIALS
A C
D
B B
C
0 in. Clearance To Exposed Section and Face Trim
Masonry or Zero Clearance
MANTEL
Face Trim
B
C
D
A
F E
LOCATION: Inside hopper on the top
HOT WHILE IN OPERATION DO NOT TOUCH, KEEP CHILDREN, CLOTHING AND FURNITURE AWAY. CONTACT MAY CAUSE SKIN
:
BURNS. SEE NAMEPLATE AND INSTRUCTIONS. Operate this unit with fuel hopper lid closed. Failure to do so may
result in emissions products' combustion from the hopper under certain conditions. Maintain hopper seal in
good condition. Do not overfill hopper.
CHAUD LORS DE L' O PÉRATION. NE PAS TOUCHER. GARDEZ LES ENFANTS ET LES VÊTEMENTS LOIN DE
L' E SPACE DÉSIGNÉ DE L' I NSTALLATION. LE CONTACT PEUT CAUSER DES BRÛLURES À LA PEAU. VOIR
L' É TIQUETTE ET LES INSTRUCTIONS. Opérez cet apparei l avec l e couvercl e de l a t r émi e f e rmé. Le déf a utde ne pas sui v re l e s i n st r uct i o ns
peut résul t e r, sous cert a i n es condi t i o ns, en une combust i o n des émi s si o ns des produi t s venant de l a t r émi e . Ne pas rempl i r l a t r émi e t r op pl e i n e.
R
CASTILE PELLET INSERT
U.S. ENVIRONMENTAL
Made in U.S.A. PROTECTION AGENCY
This model is exempt from EPA certification
Fait Aux États-Unis
under 40 CFR 60.531 by definition [Wood
Heater (A) "Air-to-Fuel Ratio"].
Manufactured by:
R
1445 Highway North, Colville, WA 99114
www.quadrafire.com
AS A BUILT-IN UNIT
A Top of Hopper Top/Rear Vent 0 in. (0mm)
B Side of Outside Skin Top/Rear Vent 0 in. (0mm)
C Back of Hopper Rear Vent
Top Vent
D Vent Pipe to Combustible Rear Vent
E
E From Panel Edge
A Insert side to combustible 0 in.
B Insert top to mantel 12 in.
C Insert top to face trim 0 in.
D Insert side face trim 0 in.
E Hearth extension from door opening 6 in.
F Hearth extension from side of door opening 6 in.
DO NOT REMOVE THIS LABEL
SERIAL NO. / NUMÉRO DU SÉRIE
007
Serial No.
Model
Name
August 20, 2009
R
0 in. (0mm)
2.5 in. (64mm)
3.0 in. (76mm)
0 in. (0mm)
0mm
305mm
0mm
0mm
152mm
152mm
7014-143
250-7262F