LZ-800W CIRCUIT DESCRIPTION Hideaway Unit (X25-8630-61) Ref. No. Parts No. Description Processing Operation TA78DS05F 5V Reg +5V power supply for microprocessor UPD784214GC077 Microprocessor Controls functions PST9130NR RESET IC Controls reset operation TDA8579T-T Isolation amplifier Audio input isolation amplifier (AV IN2)
Page 5
LZ-800W CIRCUIT DESCRIPTION Video Unit (X35-4170-61) Ref. No. Parts No. Description Processing Operation IC20 PNA4603H Autodimmer IC Autodimmer detection sensor IC30 TC7W34FU Buffer Remote control output buffer IC100 NJM2368V DC-DC control IC Controls DC-DC IC150 TA78DS05F 5V Reg +5V power supply for microprocessor...
LZ-800W MICROCOMPUTER'S TERMINAL DESCRIPTION Panel Microprocessor terminal functions (X35-, IC600) Pin No. Pin name Function Logic Not used SCREEN Tact key screen L: SCREEN ON H: SCREEN OFF MODE Tact key wide mode L: MODE ON H: MODE OFF V.SEL Tact key video switch L: V.SEL ON H: V.SEL OFF...
Page 7
SPMUTE Speaker mute output H: mute off L: mute on VMUTE Video mute output H: mute on L: mute off KEN/KY KENWOOD/KY market sector setup H: KENWOOD L: KY TV/NAVI TV·VIDEO/NAVI change H: NAVI L: TV/VIDEO Not used NT/PAL NT/PAL change...
Page 8
LZ-800W MICROCOMPUTER'S TERMINAL DESCRIPTION Hideaway processor terminal function description (X25-, IC3) Pin No. Pin name Function Logic DIVER Diversity adjustment mode (test mode) H: adjustment mode ON Not used IF switch (overseas only) H: DK AREA IF switch (overseas only)
Page 9
LZ-800W MICROCOMPUTER'S TERMINAL DESCRIPTION Pin No. Pin name Function Logic PLLCLK PLL serial clock output PLLENB PLL data enable output T VMUTE TV tuner, video mute H: mute on L: mute off FMDATA FM transmitter DATA output FMCLK FM transmitter CLK output...
LZ-800W KEY EXPLANATION 1 Composition Covers the tact key, touch panel and remote control keys. 2 Key explanation 2-1 Tact key The tact key functions are listed below. Table 2-1 Tact key functions Name Operation PWR ON (AVOUT) (When POWER OFF) Power turns on with one push (When POWER ON) Switches FM-TX audio and AV output sources (NORMAL→TV→NAV→VD1→VD2)
LZ-800W TEST MODE 1. Setup Method Reset by pressing the 'VOL UP' key and 'SCRN" key. 2. Details Includes all items applicable to the supported NA-R300 remote control unit. Function Operation details Autodimmer The dimmer responds with the same timing (without waiting) as external light changes...
Page 12
LZ-800W ADJUSTMENT X35 Unit Adjustment Specification Item Adjustment method/Adjustment value Conditions 1. Screen display start • With a monoscope display confirm that the left and right positions are equal. • Monoscope position confirmation If they are slightly off, adjust for left/right equality with VR200.
Page 13
LZ-800W ADJUSTMENT Power Supply Voltage: 14.4V X35 Gamma Timing Controller Circuit Adjustment Specification Item Adjustment method/Adjustment value Conditions 1. Set to TEST mode • Pressing the (SCREEN) and (VOL+) keys set the (RESET) key ON. • Must be in TEST mode.
Page 14
LZ-800W ADJUSTMENT Power Supply Voltage: 14.4V X35 Gamma Timing Controller Circuit Adjustment Specification Item Adjustment method/Adjustment value Conditions 5. Gamma curve (6) Adjust GAMMA2 VR305 so the 7th step from the pedestal is 3.1V±0.1V. • Input signal adjustment Composite input (10 step signal) •...
Page 15
PC BOARD (Component side view) HIDEAWAY UNIT (X25-8630-61) X25-8630-61 (J74-1103-12) GREEN (X25-8630-61) C242 IC14 R242 Ref. No. Address C243 C100 10 13 C244 IC18 R152 C160 R134 R150 C256 S-METER IC11 C206 VR401 R129 IC12 R151 MUTE LEVEL V LEVEL C101 IC13 R131...
Page 16
PC BOARD (Foil side view) HIDEAWAY UNIT (X25-8630-61) X25-8630-61 (J74-1103-12) GREEN (X25-8630-61) C242 IC14 R242 Ref. No. Address C100 C243 C244 IC18 R152 C160 R134 R150 C256 IC11 C206 S-METER VR401 R129 IC12 R151 V LEVEL MUTE LEVEL C101 IC13 C158 R131 W401...
Page 21
4.39V AUDIO 4.38V UPC1830GT SWITCH 2.2K R239 C255 4.7K SWITCH SWITCH R249 IC12 MULTIPLEXER MULTIPLEXER LZ-800W (1/2) LZ-800W •DC voltages are as measured with a high impedance voltmeter. Values may vary slightly due to variations between individual instruments or/and units.
LZ-800W PARTS LIST ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. (X25-8630-61) Des- Des- Ref. No. Parts No. Description Ref.
Page 25
LZ-800W PARTS LIST ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. (X25-8630-61) (X25-8630-61) Des- Des- Ref. No. Parts No.
Page 26
LZ-800W PARTS LIST ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. (X25-8630-61) (X25-8630-61) Des- Des- Ref. No. Parts No.
Page 27
LZ-800W PARTS LIST ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. (X35-4170-61) (X35-4170-61) Des- Des- Ref. No. Parts No.
Page 28
LZ-800W PARTS LIST ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. (X35-4170-61) (X35-4170-61) Des- Des- Ref. No. Parts No.
Page 29
LZ-800W PARTS LIST ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. (X35-4170-61) (X35-4170-61) Des- Des- Ref. No. Parts No.
Page 30
LZ-800W PARTS LIST ∗ New Parts Parts without Parts No. are not supplied. Les articles non mentionnes dans le Parts No. ne sont pas fournis. Teile ohane Parts No. werden nicht geliefert. (X35-4170-61) Des- Ref. No. Parts No. Description tina-...