1. Manuals
  2. Brands
  3. Yard Works Manuals
  4. Log Splitter
  5. 60-3800-4
  6. Instruction manual

Yard Works 60-3800-4 Instruction Manual

Electric log splitter
Hide thumbs

Advertisement

Table of Contents

4
C
US
218549

Advertisement

Table of Contents
loading

Summary of Contents for Yard Works 60-3800-4

  • Page 1 218549...

  • Page 2: Table Of Contents

    YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 2 Table of Contents Technical data ....... . 2 Warranty .

  • Page 3: General Safety Rules

    YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 3 General Safety Rules Safety is a combination of common sense, staying alert, and knowing how to use the log splitter. WARNING: ⁄ TO AVOID MISTAKES THAT COULD CAUSE SERIOUS INJURY, DO NOT PLUG IN THE LOG SPLITTER UNTIL THE FOLLOWING STEPS HAVE BEEN READ AND UNDERSTOOD.

  • Page 4: Specific Safety Rules For Log Splitters

    YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 4 General Safety Rules - continued 13. MAINTAIN TOOLS PROPERLY. ALWAYS keep tools clean and in working order. 14. CHECK FOR DAMAGED PARTS. Check for alignment of moving parts, binding, breakage, or any other conditions that may affect the tool’s operation.
  • Page 5 YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 5 Specific Safety Rules for Log Splitters - continued 8. Never use the log splitter for any other purpose than splitting wood. Any other use can result in injury. Use extreme caution at all times.

  • Page 6: Electrical Information

    YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 6 Electrical Information WARNING: ⁄ TO AVOID ELECTRICAL HAZARDS, FIRE HAZARDS, OR DAMAGE TO THE TOOL, USE PROPER CIRCUIT PROTECTION. THE LOG SPLITTER IS WIRED AT THE FACTORY FOR 120 V OPERATION.
  • Page 7 YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 7 Electrical Information - continued CAUTION! IN ALL CASES, MAKE CERTAIN THE RECEPTACLE IN QUESTION IS PROPERLY GROUNDED. IF YOU ARE NOT SURE, HAVE A CERTIFIED ELECTRICIAN CHECK THE RECEPTACLE. WARNING: ⁄...

  • Page 9: Assembly

    YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 9 Assembly UNPACKING The log splitter is fully assembled. The enclosed hex wrench is for turning the fluid drain bolt to check and/or replace hydraulic fluid. Note: Do not discard box or any packing material until all parts are examined.

  • Page 10: Operation

    YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 11 Operation BEFORE OPERATING Select a work area Place the log splitter in a flat, stable area. Make sure there is sufficient room for the unsplit logs and stacks of split logs. Make sure there is a safe electrical connection no more than 33’...
  • Page 11 YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 12 Operation - continued Place a log on the log splitter (Fig. 3) WARNING: WHEN LOADING A LOG, PLACE HANDS ON THE SIDES OF THE LOG, NOT THE END. DO NOT LOAD A LOG WHEN THE PUSH ROD IS IN MOTION.
  • Page 12 YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 13 Operation - continued WARNING: ⁄ IF THE LOG DOES NOT BEGIN TO SPLIT AFTER 5 SECONDS OF OPERATION, RELEASE BOTH CONTROLS. THE MOTOR OR HYDRAULIC FLUID MAY OVERHEAT AND DAMAGE THE MACHINE.

  • Page 13: Maintenance

    YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 14 Maintenance ⁄WARNING: DISCONNECT THE LOG SPLITTER FROM THE POWER SOURCE BEFORE PERFORMING ANY MAINTENANCE. Check the level of hydraulic fluid before each use. Replace the hydraulic fluid at the beginning of each season or if the fluid level is low. Use only the type of fluid recommended by the manufacturer (DTE 24).
  • Page 14 YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 15 Maintenance - continued Replace hydraulic fluid (Fig. 9 and 10) ⁄WARNING: LIFTING THE LOG SPLITTER IS A TWO PERSON OPERATION. ONCE RAISED, MAKE SURE THE LOG SPLITTER IS STABLE BEFORE PERFORMING ANY MAINTENANCE.

  • Page 15: Troubleshooting

    YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 16 Troubleshooting Use this troubleshooting information to remedy problems that may occur during the operation of the log splitter. Logs will not split The problem may be with the log or with the machine: •...

  • Page 16: Parts Breakdown

    YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 16 Parts Breakdown...

  • Page 17: Parts List

    YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 16 Parts List Model Num. Description Motor 60-3800-1 Rubber Washer 60-3800-2 Nut M5 60-3800-3 Column Pin φ2.5×4 60-3800-4 Oil Seal φ11×φ26×7 60-3800-5 Rubber Washer 60-3800-6 Nut M8 60-3800-7 Front Cover For Motor...
  • Page 18 YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 16 Parts List Model Num. Description Bolt 60-3800-32 Ball Nut M10 60-3800-33 Rubber Handle 60-3800-34 Hydraulic Control Lever 60-3800-35 Spring Washer φ10 60-3800-36 Cover For Hydraulic Control Lever 60-3800-37 Nuts M10...
  • Page 19 YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 16 Parts List Model Num. Description Squareness washer for front cover 60-3800-63 Oil seal 48.7×3.55G 60-3800-64 Push rod 60-3800-65 Down pad 60-3800-66 Up pad 60-3800-67 Left worktable guard 60-3800-68 Right worktable guard...
  • Page 20 YW Log Split 60-3800-4 E 1/3/04 2:20 PM Page 16 Parts List Model Num. Description Circuit breaker 60-3800-94 Locked washer φ4 60-3800-95 Washer φ4 60-3800-96 Power cord14AWG-UL 60-3800-97 Screw M4×6 60-3800-98 Spring washer 4 60-3800-99 Locked nut for power cord φ20...

Table of Contents