Table of Contents
Advertisement
Instruction Manual
D103370X012
June 2010
t
Baumann
Angle and Inline Control Valve
Contents
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Introduction
The Baumann 84000 sanitary control valve (figures
1, 2, and 3) is designed to satisfy the stringent
demands of the pharmaceutical and biotechnology
industries. These valves are in compliance with 3 A
Sanitary Standards, Inc. requirements.
Scope of Manual
This instruction manual includes installation,
maintenance, and parts information for the Baumann
84000 sanitary control valve.
Do not install, operate, or maintain Baumann 84000
control valves without being fully trained and
qualified in valve, actuator, and accessory
installation, operation, and maintenance. To avoid
personal injury or property damage, it is important to
carefully read, understand, and follow all the
contents of this manual, including all safety cautions
and warnings. If you have any questions about these
instructions, contact your Emerson Process
Management sales office before proceeding.
www.Fisher.com
84000 Sanitary Diaphragm
. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
1
1
2
3
3
3
4
4
4
4
4
W9838
5
Figure 1. 84000 Inline Sanitary Valve
6
11
W9839
Figure 2. 84000 Angle Sanitary Valve with Baumann 32
Actuator and FIELDVUEt DVC2000 Digital Valve Controller
W9840
Figure 3. 84000 Angle Sanitary Valve with Baumann 54
Actuator and FIELDVUE DVC6000 Digital Valve Controller
84000 Valve
with Baumann 32 Actuator
Advertisement
Table of Contents
Related Manuals for Fisher Baumann 84000
Summary of Contents for Fisher Baumann 84000
-
Page 1: Table Of Contents
This instruction manual includes installation, maintenance, and parts information for the Baumann 84000 sanitary control valve. Do not install, operate, or maintain Baumann 84000 control valves without being fully trained and qualified in valve, actuator, and accessory installation, operation, and maintenance. To avoid... -
Page 2: Safety Precautions
Instruction Manual 84000 Valve June 2010 these conditions are you should WARNING contact your Emerson Process Management sales office for more complete specifications. Provide the Always wear protective gloves, product serial numbers (shown on the clothing and eyewear when performing nameplate) and all other pertinent any installation operations to avoid information. -
Page 3: Maintenance
Instruction Manual 84000 Valve June 2010 Maintenance that must be taken to protect against process media. WARNING Note Whenever a gasket seal is disturbed Avoid personal injury and property by removing or shifting gasketed damage from sudden release of parts, install a new gasket during process pressure or bursting of parts. -
Page 4: Air Piping
Instruction Manual 84000 Valve June 2010 Air Piping Actuator Removal 1. For an air to extend actuator (air to close To remove the actuator, unscrew the drive nut action), connect the actuating air pressure line to the (key 9) and loosen the jam nuts (key 27). Unscrew 1/4 NPT opening in the upper diaphragm case. -
Page 5: Valve Calibration
Instruction Manual 84000 Valve June 2010 4. IMPORTANT: Verify that the recessed roller Valve Calibration bearings in the drive mechanism (key 4) rest against After the valve is assembled per the previous the flats of the piston stem assembly (key 3). instructions, install the properly configured actuator 5. -
Page 6: Parts Ordering
(key 11) to compress the diaphragm (key 8) by Management should not, under any tightening the clamp nut. For NPS 1 valves, circumstances, be used in any Fisher tighten the bolts (key 18) on the bonnet flange valve, because they may void your (key 11) using 45 lbfSft. - Page 7 84000 Valve June 2010 E1314 E1316 Figure 4. Baumann 84000 NPS 1 Angle Valve Body Figure 6. Baumann 84000 NPS 1 1/2 and 2 Angle Valve Sub Assembly Body Sub Assembly E1315 E1317 Figure 5. Baumann 84000 NPS 1 Inline Valve Body Sub Assembly Figure 7.
- Page 8 Instruction Manual 84000 Valve June 2010 Table 1. Common Parts VALVE SIZE DESCRIPTION NPS 1 Angle NPS 1 Inline NPS 1 1/2 Angle NPS 2 Angle Valve Body, < 30 Ra Microinch 82128 82128 2 82124 82125 Valve Body, < 20 Ra Microinch 82128 10 82128 2 1 82124 6...
- Page 9 Instruction Manual 84000 Valve June 2010 E1319 E1318 NPS 1 INLINE VALVE BODY POSITIONED FOR FORWARD FLOW SELF DRAINING FROM PORT A TO B NPS 1 ANGLE VALVE BODY POSITIONED FOR FORWARD FLOW SELF DRAINING FROM PORT A TO B E1319 E1318 NPS 1 INLINE VALVE BODY POSITIONED FOR...
- Page 10 Instruction Manual 84000 Valve June 2010 E1321 NPS 1 1/2 AND 2 ANGLE VALVE BODY POSITIONED FOR SELF DRAINING FROM PORT B TO A E1320 NPS 1 1/2 AND 2 ANGLE VALVE BODY (RECOMMENDED FOR PROCESSES WHERE ATMOSPHERIC OR SLIGHT VACUUM IS PRESENT DOWNSTREAM OF PORT B [PORTS A AND B MUST BE DRAINED SEPARATELY) Figure 9.
-
Page 11: Dimensions And Weights
FIELDVUE DVC2000 DIGITAL VALVE 3660/3661 POSITIONER CONTROLLER E1322 NOTE: ACTUATOR REMOVAL REQUIRES 115mm (4.5 INCHES) VERTICAL CLEARANCE. FOR (inch) PROPER ADJUSTMENTS TO DUAL TRAVEL STOPS, REFER TO ACTUATOR INSTRUCTIONS Figure 10. Dimensional Drawings for Baumann 84000 NPS 1 Angle and Inline Valves... - Page 12 PROPER ADJUSTMENTS TO DUAL TRAVEL STOPS, REFER TO ACTUATOR INSTRUCTIONS Figure 11. Dimensional Drawing for Baumann 84000 NPS 1 1/2 and 2 Angle Valve with FIELDVUE DVC6010 Digital Valve Controller Table 2. Dimensions for NPS 1 1/2 and 2 Angle Valve Body...