Table Of Contents - Pentair MT Sizes 500 Installation And Operation Instructions Manual

Page 2
SECTION 1.
General Information
1.1 Introduction ................................................... 3
1.2 Heater Identification ..................................... 3
1.3 Primary/Secondary Pump and Piping ........... 3
1.4 Certifications ................................................. 3
1.5 Engineering Assistance ................................ 3
SECTION 2.
Installation
2.1 Boiler Placement .......................................... 4
2.2 Installation of Indoor Boilers ......................... 4
2.2.1 Combustion Air Supply ................................. 4
2.2.2 Venting ......................................................... 5
2.2.3 Common Venting System
Test Procedure ............................................. 6
2.2.3 Instructions Relatives au Test des
Systèmes à Évent Commun ......................... 6
2.3 Installation of Outdoor Boilers ...................... 7
2.4 Gas Supply and Piping ................................. 7
2.5 Electrical Wiring ............................................ 8
2.6 General Piping Instructions .......................... 9
2.7 Boiler By-Pass Piping ................................... 9
2.8 Temperature Sensor Placement
and Installation ............................................ 10
2.9 Automatic Chlorinators ............................... 10

TABLE OF CONTENTS

Pentair Technical Support
Sanford, North Carolina (8 A.M. to 5 P.M.)
Phone: (800) 831-7133
Fax: (919) 566-8920
Moorpark, California (8 A.M. to 5 P.M.)
Phone: (800) 831-7133
Fax: (800) 284-4151
Web sites: visit www.pentairpool.com and www.staritepool.com
Pentair Water Commercial Pool and Spa
SECTION 3.
Operation
3.1 Controls - General ...................................... 11
3.2 Initial Start-Up ............................................. 11
3.3 Safety Shutoff Component Checkout ......... 12
3.4 Inlet Temperature and
Temperature Rise Adjustment .................... 12
3.5 Heater Shut Down ...................................... 13
3.6 Spring and Fall Operation
Stand-by Service ........................................ 13
3.7 Winter Operation Complete Shutdown ....... 14
3.8 Time Clock Operation ................................. 14
3.9 Therapeutic Pools (Spas) ........................... 14
SECTION 4.
Maintenance ..............................................
SECTION 5.
Troubleshooting .......................................
SECTION 6.
Parts Description and Order Numbers ................ 17
15
16