Pioneer DEH-P310UB Service Manual
  1. Manuals
  2. Brands
  3. Pioneer Manuals
  4. Car Stereo System
  5. DEH-P310UB - Premier Radio / CD
  6. Service manual

Pioneer DEH-P310UB Service Manual

Cd receiver
Hide thumbs Also See for DEH-P310UB:
Table of Contents

Advertisement

Quick Links

See also: Operating Manual , Installation Manual
QQ
3 7 63 1515 0
CD RECEIVER
DEH-P310UB
DEH-P3100UB
DEH-P3100UB
DEH-3100UB
TE
L 13942296513
This service manual should be used together with the following manual(s):
Model No.
CX-3240
CRT4050
www
For details, refer to "Important Check Points for Good Servicing".
.
PIONEER CORPORATION
PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A.
PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium
PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936
PIONEER CORPORATION 2008
http://www.xiaoyu163.com
Order No.
Mech.Module
S10.5COMP2-iPod/USB
x
ao
y
i
4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan
http://www.xiaoyu163.com
8
DEH-P310UB/XS/UC
/XS/UC
/XS/EW5
/XS/ES
Q Q
3
6 7
1 3
CD Mech. Module : Circuit Descriptions, Mech. Descriptions, Disassembly
u163
.
2 9
9 4
2 8
1 5
0 5
8
2 9
9 4
Remarks
m
co
K-ZZZ. NOV. 2008 Printed in Japan
9 9
ORDER NO.
CRT4247
/XS/UC
2 8
9 9

Advertisement

Table of Contents
loading

Related Manuals for Pioneer DEH-P310UB

Summary of Contents for Pioneer DEH-P310UB

  • Page 1 PIONEER CORPORATION 4-1, Meguro 1-chome, Meguro-ku, Tokyo 153-8654, Japan PIONEER ELECTRONICS (USA) INC. P.O. Box 1760, Long Beach, CA 90801-1760, U.S.A. PIONEER EUROPE NV Haven 1087, Keetberglaan 1, 9120 Melsele, Belgium PIONEER ELECTRONICS ASIACENTRE PTE. LTD. 253 Alexandra Road, #04-01, Singapore 159936 PIONEER CORPORATION 2008 K-ZZZ.

  • Page 2: Safety Information

    When Q101 is shorted between their terminals, the laser diodes will radiate beam. If the top cover is removed with no disc loaded while such short-circuit is continued, the naked eyes may be exposed to the laser beam. DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 3 3 7 63 1515 0 CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacture. Discord used batteries according to the manufacture's instructions. L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 4 To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be u163 installed before shipment. Please be sure to follow this method especially if it is specified in this manual. DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 5: Table Of Contents

    10.1 TUNER AMP ASSY(GUIDE PAGE) .......................56 10.2 KEYBOARD UNIT ..........................62 10.3 CD MECHANISM MODULE(GUIDE PAGE)...................64 10.4 WAVEFORMS............................70 11. PCB CONNECTION DIAGRAM ........................74 11.1 TUNER AMP ASSY ..........................74 11.2 KEYBOARD UNIT...........................78 11.3 CD CORE UNIT(S10.5iPod-C3-CLASS1) ....................80 12. ELECTRICAL PARTS LIST...........................82 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 6: Service Precautions

    Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 7: Specifications

    2. SPECIFICATIONS 3 7 63 1515 0 2.1 SPECIFICATIONS DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC Slope....... –18 dB/oct General Gain ......... +6 dB to – 24 dB Power source......14.4 V DC (10.8 V to 15.1 V Phase ......Normal/Reverse allowable) Bass boost: Grounding system....Negative type Gain .........
  • Page 8 Power output ......14 W RMS × 4 Channels (4 1 % THD+N) S/N ratio ........91 dBA (reference: 1 W into Note Specifications and the design are subject to mod- ifications without notice due to improvements. L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 9 Frequency....3.15k/8k/10k/12.5k Hz Q Factor ....0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain ......±12 dB HPF: Frequency....... 50/63/80/100/125 Hz Slope........–12 dB/oct Subwoofer (mono): Frequency....... 50/63/80/100/125 Hz Slope........–18 dB/oct Gain ........+6 dB to –24 dB u163 Phase ......Normal/Reverse DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 10 Frequency range....153 kHz to 281 kHz Usable sensitivity....28 μV (S/N: 20 dB) Signal-to-noise ratio..... 62 dB (IEC-A network) Notes Specifications and the design are subject to modifications without notice due to im- provements. L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 11 Frequency....3.15k/8k/10k/12.5k Hz Q Factor ....0.35/0.59/0.95/1.15 (+6 dB when boosted) Gain ......±12 dB HPF: Frequency....... 50/63/80/100/125 Hz Slope........–12 dB/oct Subwoofer (mono): Frequency....... 50/63/80/100/125 Hz Slope........–18 dB/oct u163 Gain ......... +6 dB to –24 dB Phase ......Normal/Reverse DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 12: Disc/Content Format

    Signal-to-noise ratio..... 62 dB (IEC-A network) Infrared remote control Wavelength......940 nm ±50 nm Output ........typ; 12 mw/sr per Infrared Notes Specifications and the design are subject to modifications without notice due to im- provements. L 13942296513 2.2 DISC/CONTENT FORMAT (DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC) u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 13: Panel Facilities

    L 13942296513 directly. the source. Pioneer CD-U50E USB cable is also avail- Press and hold to switch to link play mode able. For details, consult your dealer. while using an iPod. For details, refer toSelecting songs from (detach) button lists related to the currently playing song.
  • Page 14 Appears when an upper tier of folder or Press to increase or decrease the volume. menu exists. h MUTE button (list) indicator Press to turn off the sound. To turn on the Appears when operating list function. sound, press again. u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 15 When repeat function is on, only is dis- played. (folder random) indicator Appears when folder random is on. When random function is on, only is dis- played. (shuffle) indicator Appears when shuffle function is on while iPod source is being selected. u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 16 USB storage device is projected forward L 13942296513 from the unit, it is dangerous to connect directly. Pioneer CD-U50E USB cable is also avail- able. For details, consult your dealer. 1 SRC/OFF button This unit is turned on by selecting a source.
  • Page 17 Band and frequency are displayed. • RDS Program service name, PTY information and other literal information are dis- played. • Built-in CD player, external storage de- vice (USB), iPod Elapsed playback time and literal infor- mation are displayed. u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 18 Appears when loudness is on. (TA) indicator Appears when TA (traffic announcement standby) function is on. (TP) indicator Appears when a TP station is tuned in. (AF) indicator Appears when AF (alternative frequencies search) function is on. u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 19 1 SRC/OFF button directly. This unit is turned on by selecting a source. Pioneer CD-U50E USB cable is also avail- Press to cycle through all the available able. For details, consult your dealer. sources.
  • Page 20 1 Main display section Displays band, frequency, elapsed playback time and other settings. • Tuner Band and frequency are displayed. • Built-in CD player, external storage de- vice (USB), iPod Elapsed playback time and literal infor- mation are displayed. u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 21 Appears when local seek tuning is on. (loudness) indicator Appears when loudness is on. (stereo) indicator Appears when the selected frequency is Screw being broadcast in stereo. Screw Parts No. DEH-P310UB/XS/UC BPZ20P060FTC DEH-P3100UB/XS/UC DEH-P3100UB/XS/EW5 BPZ20P080FTC (folder repeat) indicator DEH-3100UB/XS/ES CXX2204 u163 Appears when folder repeat is on.

  • Page 22: Connection Diagram

    2.4 CONNECTION DIAGRAM 3 7 63 1515 0 DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 23 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 24 3 7 63 1515 0 DEH-P3100UB/XS/EW5 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 25 3 7 63 1515 0 DEH-3100UB/XS/ES L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 26 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 27: Basic Items For Service

    See the table below for the items to be checked regarding audio: Item to be checked regarding audio Distortion Noise Volume too low Volume too high Volume fluctuating Sound interrupted L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 28: Pcb Locations

    3.2 PCB LOCATIONS 3 7 63 1515 0 Tuner Amp Assy Keyboard Unit CD Core Unit (S10.5iPod-C3-CLASS1) A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC C:DEH-P3100UB/XS/EW D:DEH-3100UB/XS/ES Unit Number YWM5360(A) L 13942296513 Unit Number YWM5361(B) Unit Number YWM5359(C) Unit Number YWM5362(D) Unit Name Tuner Amp Assy...

  • Page 29: Jigs List

    L 13942296513 Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned Cleaning tools CD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 30: Block Diagram

    DET, FM MPX, RDS DECODER RF adj ANT adj CF52 → 3.3V 2.5V 3.3V 2.5V VDD3.3V L 13942296513 CN101 IN1+ IP-BUS DRIVER IN1- IC101 :DEH-P310UB/XS/UC HA12241FP :DEH-P3100UB/XS/UC BUS- DIN1 IP BUS :DEH-P3100UB/XS/EW5 BUS+ ROUT :DEH-3100UB/XS/ES MUTE STBY SYSPW Q101 IPPW B.UP Q102 ASENBO CD CORE UNIT(S10.5iPod-C3-CLASS1)
  • Page 31 SW/BASS : JOYST JOYST JOYST MUTE DISP SOURCE SOURCE SW5V SSENS BAND LIST S.Rtrv KYDT KYDT KYDT DPDT DPDT DPDT DSEN DSENS DSENS u163 REMOTE CONTROL SWVDD SENSOR Q851 SW5V SW5V GP1UXC14RK SWVDD Q852 VBUS VBUS(US5V) US5V US5V US5V DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 32 3 7 63 1515 0 LCD (YAW5101) L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 33: Diagnosis

    Source keys with Grille microcomputer may fail. operative If the time interval is not 300 msec, the oscillator may be defective. Source ON SYSPW <- H Pin 48 u163 Completes power-on operation. (After that, proceed to each source operation) DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 34: Error Code List

    Remarks: Mechanical errors are not displayed (because a CD is turned off in these errors). Unreadable TOC does not constitute an error. An intended operation continues in this case. Upper digits of an error code are subdivided as shown below: 1x: Setup relevant errors, 3x: Search relevant errors, Ax: Other errors. u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 35 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 36: Connector Function Description

    5.3 CONNECTOR FUNCTION DESCRIPTION 3 7 63 1515 0 SUBWOOFER OUTPUT FRONT WIRED REMOTE CONTROL ANTENNA IP-BUS INPUT OUTPUT (DEH-P310UB/XS/UC, (DEH-P310UB/XS/UC, (DEH-P310UB/XS/UC, DEH-P3100UB/XS/EW5, DEH-P3100UB/XS/UC, DEH-P3100UB/XS/UC, DEH-3100UB/XS/ES) DEH-P3100UB/XS/EW5) DEH-3100UB/XS/ES) 1. BUS1 2. GND 3. GND L 13942296513 4. NC 5. BUS2 6.

  • Page 37: Service Mode

    CH1 - CH4 : Usage condition of ROM Correction CH (using:X / Not used:0) When ROM Correction itself didn't exist: When check sum is a disagreement: *3) LCD check mode 1 *4) LCD check mode 2 *5) LCD check mode 3 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 38: Cd Test Mode

    3 Press the C key to change display/non-display of key names. When the non-display mode is selected for the K1 - K6 key names, "A key" and "B key" are invalid. C key *) Pressing the A key or B key does not work. u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 39 • When the power is turned on/off the jump mode is reset to the Single TR (91) while the gain of the RFAMP is reset to 0 dB. At the same time all the self-adjusting values shall return to the default setting. DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 40: Disassembly

    Panel Assy L 13942296513 Fig.1 - Removing the Tuner Amp Unit (Fig.2) Remove the three screws. Remove the screw. Straighten the tabs at four locations indicated and then remove the Tuner Amp Unit. u163 Tuner Amp Unit Fig.2 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 41 3. While lifting the Carriage Mechanism, Upper Frame remove it from the three Dampers. Caution: When assembling, be sure to apply some alcohol to the Dampers and assemble L 13942296513 the mechanism in a clamped state. Damper Carriage Mechanism Damper Lower Frame u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 42 Assemble the sub unit side of the Pickup, taking the plate (Chassis) in-between. When treating the leads of the Load L 13942296513 Carriage Motor Assy, do not make them loose over the Feed Screw. Poly Washer Change Arm Inner Holder Pickup Lock Arm Feed Screw Planet Gear Pickup Rack Chassis u163 Pickup DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 43: Each Setting And Adjustment

    1k ohms in series. The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it. u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 44: Checking The Grating After Changing The Pickup Unit

    Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. Hint u163 Reloading the disc changes the clamp position and may decrease the "wobble". DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 45 3 7 63 1515 0 Grating waveform Ech -> Xch 20 mV/div, AC Fch -> Ych 20 mV/div, AC 0 degrees 30 degrees 45 degrees 60 degrees L 13942296513 75 degrees 90 degrees u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 46: Pcl Output Confirmation

    STEST IC601(Pin 63) terminal to H. The clock signal is output from the PCL1 terminal IC601(Pin 39). The frequency of the clock signal is 468.750 Hz that is one 32th of the fundamental frequency. L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 47 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 48: Exploded Views And Parts List

    Screw adjacent to mark on the product are used for disassembly. For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) 9.1 PACKING DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P310UB/XS/UC DEH-P3100UB/XS/UC...
  • Page 49 21-6 Owner's Manual See Contrast table (2) Screw TRZ50P080FTC Unit Box See Contrast table (2) (2) CONTRAST TABLE DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC, DEH-P3100UB/XS/EW5 and DEH-3100UB/XS/ES are constructed the same except for the following: Mark Description DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P3100UB/XS/EW5 DEH-3100UB/XS/ES Polyethylene Bag CEG1173...

  • Page 50: Exterior (1)

    9.2 EXTERIOR (1) 3 7 63 1515 0 DEH-P3100UB/XS/EW5 L 13942296513 DEH-P3100UB/XS/EW5 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 51 Transistor(Q702, Q911) 2SD2396 Holder CND4324 Screw See Contrast table (2) Holder XNC7030 (2) CONTRAST TABLE DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC, DEH-P3100UB/XS/EW5 and DEH-3100UB/XS/ES are constructed the same except for the following: L 13942296513 Mark Description DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P3100UB/XS/EW5 DEH-3100UB/XS/ES Tuner Amp Assy YWM5360 YWM5361...

  • Page 52: Exterior (2)

    9.3 EXTERIOR (2) 3 7 63 1515 0 DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P3100UB/XS/EW5 DEH-3100UB/XS/ES L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 53 See Contrast table (2) Remote IC(IC2) GP1UXC14RK Connector(CN4) CKS6049 LCD(LCD1) YAW5101 (2) CONTRAST TABLE DEH-P310UB/XS/UC, DEH-P3100UB/XS/UC, DEH-P3100UB/XS/EW5 and DEH-3100UB/XS/ES are constructed the same except for the following: Mark Description DEH-P310UB/XS/UC DEH-P3100UB/XS/UC DEH-P3100UB/XS/EW5 DEH-3100UB/XS/ES Remote Control Assy CXC8885 CXC8885 Not used...

  • Page 54: Cd Mechanism Module

    9.4 CD MECHANISM MODULE 3 7 63 1515 0 L 13942296513 43 10 u163 (1) : GEM1024 : GEM1045 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 55 CND3831 Lever CND2585 CND2586 Bracket CND2587 CND2588 Lever CND2589 Holder CNV9522 Gear CNV7207 Gear CNV9513 Gear CNV7209 Gear CNV9514 Gear CNV9515 Gear CNV9516 Rack CNV9517 CNV7216 Roller CNV8189 Gear CNV9518 u163 Guide CNV9519 Gear CNV7595 Guide CNV9520 CNV7805 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 56: Schematic Diagram

    AUX G AUXL AUX L JOYST JOYST LCD_CLR LCD_CLR USBG USBG u163 USBG VBUS VBUS ILM+B ILM+B ROT1 R810 R804 R814 ROT1 ROT0 R812 R805 R815 2.2k ROT0 KYDT R806 2.2k KYDT DPDT 2.2k 2.2k DPDT DSEN R807 DSENS DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 57 3 7 63 1515 0 A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC C:DEH-P3100UB/XS/EW TUNER AMP ASSY D:DEH-3100UB/XS/ES C352 R351 2.2u/50 CD/USB: +0.6 dBs CN351 C351 R356 R352 2.2u/50 RCRR RCRL RCFR RCFL RCG1 A,B,D FM(10%):/EW -12.0 dBs, -11.0 dBs AM(15%):/EW -7.5 dBs, -7.5 dBs CD/USB: -6.3 dBs...
  • Page 58 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 59 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 60 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 61 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 62: Keyboard Unit

    SEG18 CSS1547-A SEG18 SEG17 SEG17 SEG16 SEG16 RESET SEG15 MOD1 SEG15 SEG14 MOD0 DGND SEG14 DGND DGND YAW5101-A LCD1 SW(V) A:DEH-P310UB/XS/UC C:DEH-P3100UB/XS/EW OVER-UNDER D:DEH-3100UB/XS/ES B:DEH-P3100UB/XS/UC 0.00-0.50 A(UP) D5-D15 CL-195PG-CD(GREEN) CL-195SR-CD(RED) CL-197HB1-D(CDE) 0.50-1.30 B(LEFT) R4-R8 RS1/4SA681J RS1/4SA392J RS1/4SA122J 1.30-2.30 C(DOWN) RS1/16S331J...
  • Page 63 3 7 63 1515 0 A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC C:DEH-P3100UB/XS/EW D:DEH-3100UB/XS/ES CSX1144 EJECT SG1155-A ILMGND GION2 ILMGND SG1155-A S.Rtrv SG1155-A DAN202U DGND DAP202U ILMG ILMGND SW5V SOURCE AUXR AUXG AUXL JOYST USBG L 13942296513 2.2k USBG CN803 2.2k VBUS(US5V) ILM+B ROT1...

  • Page 64: Cd Mechanism Module(Guide Page)

    10.3 CD MECHANISM MODULE(GUIDE PAGE) 3 7 63 1515 0 PICKUP UNIT(P10.5)(SERVICE) L 13942296513 SWITCHES: CD CORE UNIT(S10.5IPOD-C3-CLASS1) S901:HOME SWITCH..ON-OFF S903:DSCSNS SWITCH..ON-OFF S904:12EJ SWITCH...ON-OFF S905:8EJ SWITCH.....ON-OFF M1 CXC7134 SPINDLE MOTOR M2 CXC4026 LOADING/CARRIAGE MOTOR u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 65 3 7 63 1515 0 CD CORE UNIT(S10.5iPod-C3-CLASS1) SIGNAL LINE FOCUS LINE TRACKING LINE CARRIAGE LINE SPINDLE LINE L 13942296513 CN701 341S2159 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 66 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 67 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 68 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 69 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 70: Waveforms

    2 ms/div 1 V/div s/div µ %RFAGC 500 mV/div 500 mV/div 500 mV/div 9TIN 500 mV/div Focus Search waveform Track Open waveform 1 Track Jump waveform Ref.: Ref.: Ref.: REFO REFO REFO u163 Mode: Mode: Mode: TEST TEST TEST DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 71 Mode: Mode: Normal Normal Normal 1 V/div 50 ns/div 2 V/div 50 ms/div 2 V/div 50 ms/div 1 V/div 2 V/div 2 V/div USB Play USB device inserting to USB connector. CD Play with USB(iPod) device connecting. u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 72 2 V/div 10 s/div 2 V/div ⁄SDA ⁄SDA 2 V/div 2 V/div 2 V/div ¤SCL ¤SCL 2 V/div 2 V/div ACC OFF with USB(iPod) device connecting. iPod Authentication Operation iPod Authentication Operation(zoom until 2 s) L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 73 3 7 63 1515 0 L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 74: Pcb Connection Diagram

    D901 Q911 L951 D903 D552 L901 C922 R955 D904 D551 D931 D932 L 13942296513 D911 R912 C913 D912 Q702 L101 C911 D701 R701 D502 C703 L601 L602 C502 CN701 C607 CN701 L501 C708 C501 BZ601 L852 u163 CN803 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 75 ANTENNA CN401 D901 R454 D902 R309 D454 L951 C354 C355 C353 C356 C405 L161 Y401 C165 C351C352 R955 L401 C162 C160 L 13942296513 L101 C401 X601 L601 L602 C605 C607 C962 CN650 L403 C408 R414 u163 CN803 FRONT DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 76 R611 C602 R401 R409 R824 Q402 R615 R410 R408 R803 R415 Q401 R973 R411 C403 R413 L720 R715 R652 R651 R667 R654 R653 R716 R666 R655 IC401 C410 C404 D810 C841 Q841 R816 Q842 R841 u163 R842 R972 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 77 IC702 C506 C503 R510 R506 R501 R707 R704 R616 C505 R713 R709 R502 R504 R512 R513 R851 R852 R819 Q851 R809 R853 R806 Q852 D811 D806 R820 D804 C851 u163 R818 D808 C802 D813 D812 R972 D807 D805 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 78: Keyboard Unit

    11.2 KEYBOARD UNIT 3 7 63 1515 0 KEYBOARD UNIT SIDE A A:DEH-P310UB/XS/UC B:DEH-P3100UB/XS/UC C:DEH-P3100UB/XS/EW D:DEH-3100UB/XS/ES L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 79 3 7 63 1515 0 KEYBOARD UNIT SIDE B L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 80: Cd Core Unit(S10.5Ipod-C3-Class1)

    11.3 CD CORE UNIT(S10.5iPod-C3-CLASS1) 3 7 63 1515 0 CD CORE UNIT(S10.5iPod-C3-CLASS1) SIDE A PICKUP UNIT(P10.5) (SERVICE) CN701 REFO1 L 13942296513 HOME LOADING/CARRIAGE MOTOR SPINDLE MOTOR u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 81 3 7 63 1515 0 CD CORE UNIT(S10.5iPod-C3-CLASS1) SIDE B 12EJ DSCSNS L 13942296513 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 82: Electrical Parts List

    The expression of the unit in this manual is shown by u instead of µ. Please do not make a mistake. Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. A:DEH-P310UB/XS/UC MISCELLANEOUS B:DEH-P3100UB/XS/UC IC 101 (B,70,67) IC(A,B,C)
  • Page 83 R 605 (B,112,76) RS1/16S681J R 151 (B,145,89) RS1/16S102J R 606 (B,99,48) (A,C,D) RS1/16S103J R 152 (B,145,87) RS1/16S102J R 607 (B,112,77) RS1/16S681J R 153 (B,145,86) RS1/16S102J R 608 (B,98,52) (C) RS1/16S104J R 609 (B,101,54) (D) RS1/16S104J R 254 (B,46,67) RS1/16S681J DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 84 R 922 (B,10,110) RS1/16S473J R 931 (B,67,56) RS1/16S104J C 407 (B,159,68) CKSRYB103K50 R 932 (B,100,100) RS1/16S104J C 408 (A,157,31) CEJQ220M10 R 933 (B,63,97) RS1/16S104J C 410 (B,154,27) (A,B,D) CKSRYB474K10 R 934 (B,63,98) RS1/16S473J C 411 (B,167,93) (A,B,D) CCSRCH470J50 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

  • Page 85: Ao Y U163

    (B,11,23) (A,B) RS1/4SA681J u163 (A,50,22) White LED NESW505C-5273 (B,11,23) (C) RS1/4SA122J (A,42,10) LED(A,B) CL-195PG-CD (B,11,23) (D) RS1/4SA392J (A,42,10) LED(C) CL-195SR-CD (B,10,18) (A,B) RS1/4SA681J (A,42,10) LED(D) CL-197HB1-D(CDE) (B,10,18) (C) RS1/4SA122J (B,10,18) (D) RS1/4SA392J (A,147,40) LED(A,B) CL-195PG-CD (A,147,40) LED(C) CL-195SR-CD DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 86 R 101 (B,61,74) RS1/10SR2R4J u163 R 708 (B,15,37) RS1/16S0R0J R 102 (B,61,72) RS1/10SR2R4J R 712 (B,14,54) RS1/16SS0R0J R 103 (B,61,71) RS1/10SR2R7J R 713 (B,14,53) RS1/16SS0R0J R 104 (B,53,66) RS1/16SS222J R 105 (B,44,57) RS1/16SS102J CAPACITORS R 107 (B,52,60) RS1/16SS105J DEH-P310UB/XS/UC http://www.xiaoyu163.com...
  • Page 87 CKSSYB472K25 C 304 (A,36,21) CKSSYB223K16 C 307 (A,22,11) CKSRYB104K16 C 308 (B,11,18) CKSRYB105K10 C 703 (B,14,35) CCSSCH101J50 C 704 (B,11,36) CKSSYB102K50 C 711 (A,31,25) CKSSYB104K10 Miscellaneous Parts List Pickup Unit(P10.5)(Service) CXX1942 Motor Unit(SPINDLE) CXC7134 Motor Unit(LOADING/CARRIAGE) CXC4026 u163 DEH-P310UB/XS/UC http://www.xiaoyu163.com...

Table of Contents