ICs inside the unit. 3. To protect the pickup unit from electrostatic discharge during servicing, take an appropriate treatment (shorting-solder) by referring to "the DISASSEMBLY". 4. After replacing the pickup unit, be sure to check the grating. DEH-P3700MP/XU/UC...
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be installed before shipment. Please be sure to follow this method especially if it is specified in this manual. DEH-P3700MP/XU/UC...
• Screw adjacent to mark on the product are used for disassembly. • For the applying amount of lobricants or glue, follow the instructions in this manual. (In the case of no amount instructions,apply as you think it appropriate.) 2.1 PACKING DEH-P3700MP/XU/UC...
No differentiation is made between chip capacitors and 0.022 R022 discrete capacitors. The > mark found on some component parts indicates the importance of the safety factor of the part. > Therefore, when replacing, be sure to use parts of identical designation. CN1801 DEH-P3700MP/XU/UC...
For resistors and capacitors in the circuit diagrams, their resistance values or capacitance values are expressed in codes: Ex. *Resistors Code Practical value 12k ohms 10k ohms *Capacitors Code Practical value 0.01uF 101/10 100uF/10V 5.00MHz LCD DRIVER/ KEY CONTROLLER YAW5015 DEH-P3700MP/XU/UC...
Page 21
KEYBOARD UNIT DISPLAY CN832 40mA,14V FUNCTION DEH-P3700MP/XU/UC...
3.4 CD MECHANISM MODULE(GUIDE PAGE) PICKUP UNIT(P10)(SERVICE) M1 CXC4440 SPINDLE MOTOR M2 CXB8933 LOADING /CARRIAGE CD DRIVER MOTOR DEH-P3700MP/XU/UC...
Page 23
S904:12EJ SWITCH.....ON-OFF S905:8EJ SWITCH....ON-OFF The underlined indicates the switch position. SIGNAL LINE FOCUS SERVO LINE TRACKING SERVO LINE CARRIAGE SERVO LINE SPINDLE SERVO LINE CD CORE UNIT(S10.1) 3.3V REGULATOR SRAMLEVEL2 MICRO COMPUTER 3V REGULATOR CN721 SRAMLEVEL1 SRAMLEVEL0 TYPE_A/D & DEH-P3700MP/XU/UC...
Page 28
7 SIN 500mV/div 200mV/div 1V/div @ TE 500mV/div 9 TIN 500mV/div CD-ROM play operation(Regular track Jump) Spindle waveform during play operation Spindle waveform during play operation (Wider) Ref.: Ref.: Ref.: REFO REFO REFO Mode: Mode: Mode: Normal Normal Normal DEH-P3700MP/XU/UC...
Page 29
500mV/div 4 LOEJ 3 12SNS 9 TIN 5V/div 5V/div 500mV/div 4 LOEJ 5V/div 12 cm CD Eject operation 8 cm CD Eject operation CD-DA >> CD-ROM mode change(Band key) Ref.: Ref.: Ref.: REFO Mode: Mode: Mode: Normal Normal Normal DEH-P3700MP/XU/UC...
Page 30
% RFAGC 1V/div 500ms/div 1V/div 500µs/div 8 CIN 9 TIN 500mV/div 1V/div 9 TIN @ TE 500mV/div 1V/div 0 FIN 1V/div CD-ROM >> CD-DA mode change(Band key) Black dot(800µm) during play Ref.: Ref.: REFO REFO Mode: Mode: Normal Normal DEH-P3700MP/XU/UC...
For further information for respective destinations, be sure WIRED REMOTE CONTROL to check with the schematic dia- CORD ASSY gram. 2.Viewpoint of PCB diagrams Capacitor Connector IP-BUS SIDE A SIDE B P.C.Board Chip Part CN901 DEH-P3700MP/XU/UC...
Page 33
SIDE A REAR OUTPUT FRONT OUTPUT ORD ASSY ANTENNA CN1801 FRONT DEH-P3700MP/XU/UC...
D 751 (A,13,62) Diode HZS9L(A1) R 111 (B,32,118) RS1/16S222J R 113 (A,39,80) RS1/16S332J D 801 (B,117,26) Diode UMZ6R8EN R 114 (A,40,77) RS1/16S562J D 803 (B,63,23) Diode UDZS10(B) R 211 (A,101,72) RAB4C102J D 811 (B,77,16) Diode UMZ6R8N R 271 (A,107,92) RS1/16S101J DEH-P3700MP/XU/UC...
Page 41
C 107 (A,48,60) CKSRYB472K50 C 108 (B,42,61) CCSRCH680J50 R 621 (B,116,41) RS1/16S104J C 201 (B,118,76) CKSRYB105K10 R 622 (B,119,41) RS1/16S104J C 202 (B,118,71) CKSRYB105K10 R 623 (B,121,41) RS1/16S104J C 203 (A,63,76) CEJQ1R0M50 R 624 (A,108,46) RS1/16S681J R 625 (A,108,47) RS1/16S681J DEH-P3700MP/XU/UC...
Page 42
(B,82,48) CCSRCH680J50 RESISTORS C 651 (A,61,68) CKSRYB105K10 C 712 (B,35,27) CCSRCH101J50 C 731 (A,64,51) CCSQCH222J50 R 1801 (B,23,43) RS1/16S222J C 732 (A,59,51) CCSQCH222J50 R 1802 (B,20,43) RS1/16S222J C 733 (A,64,55) CCSQCH102J50 R 1803 (B,22,33) RS1/16S151J R 1804 (B,22,31) RS1/16S181J DEH-P3700MP/XU/UC...
Page 43
(B,45,54) RS1/16SS221J RESISTORS R 901 (B,52,65) RAB4CQ221J R 101 (A,22,24) RS1/10SR2R4J R 905 (B,54,60) RS1/16SS221J R 102 (A,22,26) RS1/10SR2R4J R 906 (B,56,68) RS1/16SS221J R 103 (A,25,25) RS1/10SR2R7J R 908 (B,45,69) RS1/16SS0R0J R 201 (A,53,16) RS1/16SS102J R 910 (B,44,69) RS1/16SS0R0J DEH-P3700MP/XU/UC...
Page 44
C 712 (A,22,42) CKSRYB224K16 C 714 (B,60,45) CKSSYB104K10 C 716 (A,61,40) CKSSYB103K16 C 722 (B,52,48) CKSQYB475K6R3 C 723 (A,26,41) CKSRYB105K10 C 903 (B,56,70) CKSSYB471K50 C 906 (A,40,77) CKSRYB224K16 C 907 (A,47,76) CKSSYB103K16 C 910 (B,60,71) CKSQYB225K10 Miscellaneous Parts List DEH-P3700MP/XU/UC...
1k ohms in series. • The load and eject operation is not guarantied with the mechanism upside down. If the mechanism is blocked due to mistaken eject operation, reset the product or turn off and on the ACC to restore it. DEH-P3700MP/XU/UC...
Page 46
→ → TYP(1X) TYP(2X) TRK 22 MIN 22 SEC 22 TRK 11 MIN 11 SEC 11 TRK 11 MIN 11 SEC 11 TRK 22 MIN 22 SEC 22 As for the double speed (2x), audio output cannot be supported DEH-P3700MP/XU/UC...
Because of eccentricity in the disc and a slight misalignment of the clamping center the grating waveform may be seen to "wobble" ( the phase difference changes as the disc rotates). The angle specified above indicates the average angle. • Hint Reloading the disc changes the clamp position and may decrease the "wobble". DEH-P3700MP/XU/UC...
If TOC can’t be read, error wouldn’t occur, but mechanism still continues its operation. The upper digits of error code is mainly classified by 3 kinds as follows: 1x: Setup related error, 3x: Search related error, Ax: Other errors. DEH-P3700MP/XU/UC...
TESTIN (Pin 5) terminal to H. The clock signal is output from the PCL terminal (Pin 62). The frequency of the clock signal is 786.432kHz that is one 16th of the fundamental frequency. The clock signal should be 786.432kHz ± 32Hz. If the clock signal is out of the range, the X'tal (X601) should be replaced with new one. DEH-P3700MP/XU/UC...
Grille Assy. Grille Assy Fig.1 Removing the Tuner Amp Unit (Fig.2) Remove the screw. Remove the three screws. Straighten the tabs at three locations indicated. Remove the screw and then remove the Tuner Amp Unit. Tuner Amp Unit Fig.2 DEH-P3700MP/XU/UC...
Page 52
Caution: Before installing the carriage mechanism in the frames, be sure to apply some alcohol to the dampers and set the mechanism to the clamp mode. Carriage Mechanism Damper Lower Frame Damper Damper DEH-P3700MP/XU/UC...
Page 53
Caution: In assembling, move the planet gear to the load/eject position before setting the feed screw in the inner holder. Washer Pickup Lock Arm Change Arm Styling Holder Feed Screw Inner Holder Planet Gear DEH-P3700MP/XU/UC...
P-BUS : Serial clock output TSCK/BSCK P-BUS : Serial data input TSI/BSI P-BUS : Serial data output P-BUS : Reset output BRST Not used 69,70 IP-BUS : Slave power supply control output ASENSBO Not used EMUTE TEST TUNER : Signal level input DEH-P3700MP/XU/UC...
Page 56
Beep tone output BEEP * PE5467A IC's marked by * are MOS type. Be careful in handling them because they are very liable to be damaged by electrostatic induction. HA12240FP BD4834G BUS+ BUS- BIAS DRIVER OUTPUT Vref RECEIVER OUTPUT DEH-P3700MP/XU/UC...
Page 57
Key data output MODA Crystal oscillator connection pin Crystal oscillator connection pin 25,26 KDT2,3 Key data input Not used KST4 Key strobe output 29-32 Not used 33-55 SEG35-13 LCD segment output Power supply 57-64 SEG12-5 LCD segment output * PD6340A NJM2388F84 DEH-P3700MP/XU/UC...
Page 58
Output of DRAM ras cas)(LDQM) Output of DRAM lower cas(LDQM) cas!(UDQM) Output of DRAM upper cas(UDQM) Output of DRAM we oe(cas) Output of DRAM oe(cas) D.GND Ground for digital circuits 73-88 RDB0-15 Input/output of DRAM data0-15 89-99 RA0-10 Output of DRAM address0-10 DEH-P3700MP/XU/UC...
Page 59
Connected to the capacitor for output of REFOUT Reversal input of FE Output of FE ADIN Input of FE, TE A/D converter Reversal input of TE Output of TE Output of LD Input of PD D.GND Ground for digital circuits * UPD63763GJ DEH-P3700MP/XU/UC...
Page 60
CD mute control output 56-58 Not used CD LSI chip selection output Not used xwait CD LSI write control signal input CLKOUT Internal system clock output(Open) LOCK Spindle lock input Not used xwrite CD LSI write control signal output Not used DEH-P3700MP/XU/UC...
Page 61
CD-DA analog/digital output change setup testin Chip check test program starting input HOME Home SW sense input TEMP Temperature information sense input VDSENS VD power supply short sense input Not used * PE5454A Format Meaning CMOS NJM2885DL1-33 Thermal Protection Bandgap Reference DEH-P3700MP/XU/UC...
Page 62
22 AUDIOGND audio ground Ground of audio block 23 L ch O L channel output FM stereo “L-ch” signal output or AM audio output 24 R ch O R channel output FM stereo “R-ch” signal output or AM audio output DEH-P3700MP/XU/UC...
In case of the above signal, the communication with Grille microcomputer may fail. Source keys If the time interval is not 300msec, the oscillator operative may be defective. Source ON SYSPW←H Pin 21 Completes power-on operation. (After that, proceed to each source operation) DEH-P3700MP/XU/UC...
7.4 CLEANING Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned Cleaning tools CD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 DEH-P3700MP/XU/UC...
Page 72
About the fixing screws for the front panel If you do not operate the Detaching and Replacing the Front Panel Function, use the supplied fixing screws and fix the front panel to this unit. Fixing screw (CBA1488) Fixing screw (CBA1488) DEH-P3700MP/XU/UC...