The AEL (accessible emission level )of the laser power output is less than CLASS 1 but the laser component is capable of emitting radiation exceeding the limit for CLASS 1. A specially instructed person should do servicing operation of the apparatus. AVH-X8500BHS/XNUC...
Page 3
CAUTION Danger of explosion if battery is incorrectly replaced. Replaced only with the same or equivalent type recommended by the manufacturer. Discord used batteries according to the manufacturer's instructions. AVH-X8500BHS/XNUC...
11.2 IF PCB..............................190 11.3 DVD CORE UNIT ..........................192 11.4 TUNER PCB............................194 11.5 MONITOR UNIT (SERVICE) ........................ 196 11.6 KEY UNIT (SERVICE).......................... 200 11.7 CASE UNIT (SERVICE) ........................201 11.8 SW UNIT (SERVICE) ........................... 202 11.9 HDMI UNIT............................204 AVH-X8500BHS/XNUC...
So, if Pickup or Spindle Motor is defective, replace the Mechanism Unit. 10. EJECT LOCK MODE for DVD mechanism In order to change the EJECT LOCK status of the mechanism, please perform following procedure. [VOL-] + [EJECT] -> ACC ON AVH-X8500BHS/XNUC...
Page 7
11. The following area, Heat sink, Top plate and Rear panel becomes hot areas. Be careful not to burn yourself. TUNER AMP PCB SIDE A SIDE B C131 C121 IC1461 IC181 IC832 IC831 IC1381 C804 IC261 IC471 IC1321 IC1371 C1366 IF PCB SIDE A SIDE B IC2101 IC2102 DVD MECHANISM MODULE HDMI UNIT IC10 SIDE A IC1251 IC1501 AVH-X8500BHS/XNUC...
Compared with eutectic solders, lead-free solders have higher bond strengths but slower wetting times and higher melting temperatures (hard to melt/easy to harden). The following lead-free solders are available as service parts: Parts numbers of lead-free solder: GYP1006 1.0 in dia. GYP1007 0.6 in dia. GYP1008 0.3 in dia. AVH-X8500BHS/XNUC...
Max Bit Rate ..... 8 000 kbps Max Frame Rate..30 fps Audio Codec ..... WMA Decode Size....MAX :720(H) x 1 280(W), MIN:48(H) x 48(W) Screw BPZ20P060FTC (2 mm × 6 mm) AVH-X8500BHS/XNUC...
Page 11
Gain ........+12 dB to 0 dB Max Bit Rate ....8 000 kbps Max Frame Rate.....30 fps(In case of resolution 720×480. MAX 25 fps in case of 720×576) Audio Codec ....MP2, MP3, Linear PCM/ MSAD PCM, AC-3 Decode Size.....MAX:720(H) x 480(W), MIN: 48(H) x 48(W) AVH-X8500BHS/XNUC...
Page 12
Max Bit Rate ....8 000 kbps Max Frame Rate.... 30 fps(In case of resolution 720×480. MAX 25 fps in case of 720×576) Audio Codec ....MP2, MP3, Linear PCM/ MSAD PCM, AC-3 Decode Size....MAX:720(H) x 480(W), MIN: 48(H) x 48(W) AVH-X8500BHS/XNUC...
Page 13
• UW5 Type Backup current ....5 mA or less AVH-X8500BHS/XNUC...
Page 16
Max Bit Rate ..... 8 000 kbps Max Frame Rate..30 fps(In case of resolution 720×480. MAX 25 fps in case of 720×576) Audio Codec ..... MP2, MP3, Linear PCM/ MSAD PCM, AC-3 Decode Size....MAX :720(H) x 480(W), MIN: 48(H) x 48(W) AVH-X8500BHS/XNUC...
Page 17
Max Bit Rate ..... 8 000 kbps Max Frame Rate..30 fps(In case of resolution 720×480. MAX 25 fps in case of 720×576) Audio Codec ..... MP2, MP3, Linear PCM/ MSAD PCM, AC-3 Decode Size....MAX :720(H) x 480(W), MIN: 48(H) x 48(W) AVH-X8500BHS/XNUC...
Page 18
Max Bit Rate ..... 8 000 kbps Max Frame Rate..30 fps(In case of resolution 720×480. MAX 25 fps in case of 720×576) Audio Codec ..... MP2, MP3, Linear PCM/ MSAD PCM, AC-3 Decode Size....MAX :720(H) x 480(W), MIN: 48(H) x 48(W) AVH-X8500BHS/XNUC...
Page 19
Max Bit Rate ..... 8 000 kbps Max Frame Rate..30 fps(In case of resolution 720×480. MAX 25 fps in case of 720×576) Audio Codec ..... MP2, MP3, Linear PCM/ MSAD PCM, AC-3 Decode Size....MAX :720(H) x 480(W), MIN: 48(H) x 48(W) AVH-X8500BHS/XNUC...
Page 20
Max Bit Rate .....8000 kbps Max Frame Rate..30 fps(In case of resolution 720×480. MAX 25 fps in case of 720×576) Audio Codec ..... MP2, MP3, Linear PCM/ MSAD PCM, AC-3 Decode Size....MAX :720(H) x 480(W), MIN: 48(H) x 48(W) AVH-X8500BHS/XNUC...
Page 21
Max Bit Rate .....8000 kbps Max Frame Rate..30 fps(In case of resolution 720×480. MAX 25 fps in case of 720×576) Audio Codec ..... MP2, MP3, Linear PCM/ MSAD PCM, AC-3 Decode Size....MAX :720(H) x 480(W), MIN: 48(H) x 48(W) AVH-X8500BHS/XNUC...
Page 22
Max Bit Rate .....8000 kbps Max Frame Rate..30 fps(In case of resolution 720×480. MAX 25 fps in case of 720×576) Audio Codec ..... MP2, MP3, Linear PCM/ MSAD PCM, AC-3 Decode Size....MAX :720(H) x 480(W), MIN: 48(H) x 48(W) AVH-X8500BHS/XNUC...
Page 23
Max Bit Rate ..... 8000 kbps Max Frame Rate..30 fps(In case of resolution 720×480. MAX 25 fps in case of 720×576) Audio Codec ..... MP2, MP3, Linear PCM/ MSAD PCM, AC-3 Decode Size....MAX :720(H) x 480(W), MIN: 48(H) x 48(W) AVH-X8500BHS/XNUC...
2.2 DISC/CONTENT FORMAT The Bluetooth word mark and logos are owned by the Bluetooth SIG, Inc. and any use of such marks by Pioneer Corporation is under license. Other trademarks and trade names are those of their respective owners. AVH-X8500BHS/XNUC...
DVD Core Unit Monitor Unit (Service) IF PCB Tuner PCB SW Unit (Service) Case Unit (Service) PCB Unit (Service) Key Unit (Service) A:AVH-X8500BHS/XNUC Unit Number : YWX5033 Unit Name : DVD Core Unit B:AVH-X8500BT/XNEW5 C:AVH-X8500BT/XNUW5 Unit Number : YXX5128 D:AVH-X8550BT/XNRC Unit Name...
Before shipping out the product, be sure to clean the following portions by using the prescribed cleaning tools: Portions to be cleaned Cleaning tools DVD pickup lenses Cleaning liquid : GEM1004 Cleaning paper : GED-008 Portions to be cleaned Cleaning tools Fans Cleaning paper : GED-008 AVH-X8500BHS/XNUC...
Note: When ordering service parts, be sure to refer to " EXPLODED VIEWS AND PARTS LIST" or "ELECTRICAL PARTS LIST". WIRED NAVI / iPh IP BUS BT MIC REMOTE JA2071 JA2111 JA2041 JA2011 only C - G AKN1073-A AVH-X8500BHS/XNUC only A CN2201 AVH-X8500BT/XNEW5 CKS6007-A AVH-X8500BT/XNUW5 IF PCB AVH-X8550BT/XNRC AVH-X8550BT/XNRD only A CN2161 AVH-X8550BT/XNRI AVH-X8590BT/XNID...
Page 29
CN1346 RFGND1 except A 12 CD_SW1 WP_SW CD_SW2 RT3 RT3 FAN MOTOR HDMI UNIT SD CARD SLOT CXM1449 HDMI RVICE) ILM+B RESET GNDD GNDD UPPLY PART KDT0 SOC33_2 KDT1 LEDB KEY UNIT LEDR LEDG (SERVICE) REMIN CN4001 BACKLIGHT WX4183 AVH-X8500BHS/XNUC...
MOT1 MOT2 ASENS MOT0 MOT0 MOT1 BSENS IP _ TO _ S SXTX IP _ to _ S S _ TO _ IP S XRX S _ to _ IP SXPWR SXPWR12V SXIRX SXITX SXIPWEN SXIPWREN E F G AVH-X8500BHS/XNUC...
Page 31
P.B. I SENS Q154 ISENS BG SENS Q155 BGSENS BGSENS A SENS Q152 (2/2) ASENS B SENS Q152 (1/2) Q153 FUSE BSENS B.UP BUP _ 1 BUP _ 1 10 A TELMUTE :AVH-X8500BHS/XNUC :AVH-X8550BT/XNRD :AVH-X8500BT/XNEW5 :AVH-X8550BT/XNRI :AVH-X8500BT/XNUW5 :AVH-X8590BT/XNID :AVH-X8550BT/XNRC AVH-X8500BHS/XNUC...
Page 32
TUNERON IC1610 HDRCS TC4066BFT AVCC5 HDRCK HDMI/IPHONE_L HDMI_AL Q1445 TO 1/3 HDtoSO TO 1/3 HDMI_ON SOtoHD IPHONE_L TO 1/3 IPHONE_ON :AVH-X8500BHS/XNUC :AVH-X8550BT/XNRD USB2 PORT POWER SUPPLY :AVH-X8500BT/XNEW5 :AVH-X8550BT/XNRI IC832 AN33014UA JA831 :AVH-X8500BT/XNUW5 :AVH-X8590BT/XNID USB5_0 BUP_1 :AVH-X8550BT/XNRC RSTN PVCC1 PVCC2 USBFLG1...
Is it OK? PICK UP Perform lens RF level check cleaned? cleaning Replace the Check2 CRG chassis Error rate check PICK UP Perform lens Is it OK? cleaned? cleaning Replace the CRG chassis Ckeck parts Finished other than PICK UP AVH-X8500BHS/XNUC...
Page 43
10 - 65 (mA) DVDLD1 VCC5_PU Disc Check Point Threshold Remarks: LD current TCD-782 CDLD1 - VCC5_PU 150 - 900 (mV) 10 - 60 (mA) CDLD1 VCC5_PU Notes: Please pay attention to the laser diode damage by static electricity. AVH-X8500BHS/XNUC...
Page 44
TCD-782 0000 0E00 ASMAX on display Check2 : Error rate check <Check> Status: [Tracking Closed] of TEST MODE Remarks Disc Check Point Threshold less than ID:40000 GGV1025 1.000E-3 less than GGV1025 ID:200000 1.000E-3 less than TCD-782 ID:HOME Position 2.500E-3 AVH-X8500BHS/XNUC...
Page 46
<Check> Check the voltage at the “STANBY” test point while the power is on. Use the “DGND1” test point at the reference. Check point Module No. Specification value Unit STANBY - DGND1 VCC33 - 0.6 V or more V Side A GNDD1 STANBY Fig 1.1: STANBY check point AVH-X8500BHS/XNUC...
Page 47
Check point Module No. Specification value Unit VDD5_1 - DGND1 5.0 ± 0.4 VCC33_1 - DGND1 3.3 ± 0.033 VCC12_1 - DGND1 1.2 ± 0.015 Side A VCC12 VCC33 VD5-1 DGND1 Fig 2.2: VDD5, VCC33, VCC12 voltage check points AVH-X8500BHS/XNUC...
Page 48
<Check> Check the voltage at the “XRES” test point while the power is on. Use the “DGND1” test point at the reference. Check point Module No. Specification value Unit NRES - DGND1 VCC33 × 0.7 or more V Side A NRES DGND1 Fig 3.1: RESET check point AVH-X8500BHS/XNUC...
Page 49
<Check> Check the voltage at the “VSENS” test point while the power is on. Use the “DGND1” test point at the reference. Check point Module No. Specification value Unit VSENS - DGND1 0.95 - 1.07 VD8 = 8.0 ± 0.4 V Side A VSENS DGND1 Fig 4.2: VSENS check point AVH-X8500BHS/XNUC...
Page 50
Check point Module No. Specification value Unit 27 MHz ± 50 ppm IC1501 156pin - DGND1 Specification value Fig 5.2: Clock specification value Side A DGND1 IC1501 156pin Fig 5.3: 27 MHz check point AVH-X8500BHS/XNUC...
Page 52
Side A Check point 1 (IC1480) Check point 2 (IC1501) Fig 6.2: SDRAM I/F check point AVH-X8500BHS/XNUC...
Page 53
Check point Module No. Specification value Unit VD8_P - PGND1 8.0 ± 0.4 VD8_A - AGND1 8.0 ± 0.4 VCC5_1 - AGND1 5.0 ± 0.05 Side A AGND1 VCC5_1 PGND1 VD8_P VD8_A Fig 7.2: VD8, VCC5 voltage check points AVH-X8500BHS/XNUC...
Page 54
Check with PGND_3 and GNDAU1 being the reference. Check point Module No. Specification value Unit VD8_A - PGND_3 8.0 ± 0.4 AVCC5 - GNDAU1 5.0 ± 0.05 Side A PGND3 GNDAU1 AVCC5 VD8_A Fig 8.2: VD8, AVCC5 voltage check points AVH-X8500BHS/XNUC...
Page 55
2.0 V - VCC33V DGND - 0.8 V 33.8688 MHz ± 300 ppm Specification value 1 Specification Specification value 2 value 3 Fig 9.2: Clock specification value Side A DGND4 Check point 2 (IC1501 148 pin) Fig 9.3: DACCLK check point AVH-X8500BHS/XNUC...
Page 56
VCC33V - 0.6 V or higher 0.4 V or lower Waveform 3 Specification value 2 Specification value 1 Fig 10.2: Serial 3 lines specification value Side A DGND1 151pin ADOUT signal 150pin LRCK signal 149pin SRCK signal Fig 10.3: Serial 3 lines check points AVH-X8500BHS/XNUC...
Page 57
Reference waveform 1400 ± 150 mV Waveform 4 1400 ± 150 mV Waveform 4 Specification value is the root-mean-square value (rms). Fig 10.4: Analog audio out (LO, RO) specification value. Side A GNDAU3 Fig 10.5: Analog audio out check point AVH-X8500BHS/XNUC...
Page 58
Specification value 2 Reference waveform VCC33V - 0.6 V or higher 0.4 V or lower Waveform 5 Specification value 2 Specification value 1 10.6: Digital audio signal (IECOUT) specification value Side A DGND1 Fig 10.7: Digital audio signal (IECOUT) check point AVH-X8500BHS/XNUC...
Page 59
PEAK COMPOSITE signal Reference value Color burst Pedestal level BOTTOM Horizontal sync signal Fig 11.2: Waveform for the case of composite white 100% output Side A COMPOSITE GNDV2 Fig 11.3: VIDEO signal check point AVH-X8500BHS/XNUC...
Page 60
(Refer to the FE test mode for the method of displaying the LD energizing time.) 2. If the second digit from the left of the energizing time display is showing E, such as “ E ”, it means that the flash memory has reached its life. Example: 0E000BB8 AVH-X8500BHS/XNUC...
Page 61
Check point Module No. Specification value Unit 48 MHz ± 200 ppm IC1501 50pin - DGND1 Specification value Fig 13.2: Clock specification value Side A 48 MHz DGND1 Fig 13.3: 48 MHz check point AVH-X8500BHS/XNUC...
Page 62
1. USB Memory: Play a song from USB memory and check D+ and D- with the DGND1 standards. 2. iPod: Connect iPod and check CP_RESET, SDATA and SCLOCK with the DGND1 standards until the Pioneer log appears. When iPod Touch or iPhone is connected, the logo is not displayed but only a check mark is displayed.
*11 Although it is USB source, it notifies as an error of DISC source. *12 Although it is USB source, iIt cancels only by Disc eject. *13 Although it is DISC source, it notifies as an error of USB source. *14 Although it is DISC source, It cancels only without Device. AVH-X8500BHS/XNUC...
Page 66
Use the sup- Available that you have SiriusXM channel er or an author- SD card is in- ported SD card. requested is not lineup. ized Pioneer serted. a valid SiriusXM Service Station channel. Non-compatible Remove your de- for assistance. SD storage de-...
Page 67
Disconnect the rupted and Pioneer Service cable from the disconnect Station. iPod. Once the from iPod’s main PandoraLink. ® menu is dis-...
Translation auto EQ, an error message may appear on the display. In such cases, refer to the table below to Pioneer recommends see what the problem is and how it may be cor- the use of a camera rected. After checking, try again.
5.5 CONNECTOR FUNCTION DESCRIPTION AVH-X8500BHS/XNUC AVH-X8500BT/XNEW5 WIRED REMOTE CONTROL ANTENNA IN USB IF REARVIEW FRONT REAR HDMI INPUT BT MIC CAMERA IN REAR AUDIO INPUT SUBWOOFER OUTPUT (AVH-X8500BHS/XNUC PRE-OUT Only) SXI-BUS INPUT POWER SUPPLY NAVI INTERFACE 9 10 1. CCR 10.
6.1 MONITOR TEST MODE MONITOR TEST MODE MENU SCREEN Method for Mode IN While pressing [Reverse] + [Eject] key, restart the system. Display specification Operational description Remote controller key Selection cursor up movement Selection cursor down movement Down Menu enter Band AVH-X8500BHS/XNUC...
Page 72
When Eject Lock is on : ON When Eject Lock is canceled : OFF Operational description Remote controller key Return to test mode menu RETURN Page up NEXT Page down PREV Page: 2 Page: 3 Page: 4 Page: 5 AVH-X8500BHS/XNUC...
Page 73
When “conditions that the mark is lit” are not satisfied When “Data Initialize is executed” When “EEPROM initialize is executed” Operational description Remote controller key Return to test mode menu RETURN Selection cursor up movement Selection cursor down movement Down Menu enter Band AVH-X8500BHS/XNUC...
Page 74
Remote controller key Check is interrupted Band Outermost circle check result screen Finished normally Finished abnormally Operational description Remote controller key Check is finished Band 2. Effective Area Calibration - 2 Outermost circle check screen First point Second point AVH-X8500BHS/XNUC...
Page 75
By repeating this action 16 times, obtain calibration value of each [+]. When touching the last 17th cursor, calibration values at 16 points and information of normal finish in 17 bytes are written in EEPROM and the screen returns to TOP menu by pressing a key. AVH-X8500BHS/XNUC...
Page 76
Operational description Remote controller key Return to top menu Band 4. Touch Panel Coordinates Test [+] is displayed at a touched place. (Two [+] are displayed by touching two places.) Operational description Remote controller key Return to top menu RETURN AVH-X8500BHS/XNUC...
Page 77
Repeating this action for 4 points and by pressing the last 4th point, “O.K.” is displayed. Operational description Remote controller key Return to top menu RETURN Calibration confirmation result screen Operational description Remote controller key Return to top menu RETURN AVH-X8500BHS/XNUC...
Page 78
When Outermost circle check of line calibration or 16-point adjustment is finished normally after 16-point adjustment of user calibration is finished normally Operational description Remote controller key Return to test mode menu RETURN Selection cursor up movement Selection cursor down movement Down Menu enter Band AVH-X8500BHS/XNUC...
Page 79
1 dot stripe image of black and gray (50% white) will appear. Adjust the number to minimize the flicker. Operational description Remote controller key Return to top menu RETURN Following items in EEPROM Adjustment menu are not used on service. AVH-X8500BHS/XNUC...
Page 80
Method for Mode IN Choose “4. EEPROM Initialize” among the Monitor Test Menu screen. Display specification Confirmation screen Operational description Remote controller key Return to test mode menu RETURN Selection cursor left movement Selection cursor right movement Menu enter Band AVH-X8500BHS/XNUC...
Page 81
Cyan:50% -> Yellow:100% -> Yellow:50% -> Black -> Gray -> White -> Green & Magenta dot signal (The display of the screen will be changed in 1 second.) R: 100% Operational description Remote controller key Return to test mode menu RETURN Stop / restart of auto display Band AVH-X8500BHS/XNUC...
Page 82
Operational description Remote controller key Return to test mode menu RETURN Pattern change Band 3. Color Bar Display of color bar signals. Color bar (Vertical) Operational description Remote controller key Return to test mode menu RETURN Pattern change Band AVH-X8500BHS/XNUC...
Page 83
Alpha blend Down (-0x10) Down Alpha blend Up (+0x01) Alpha blend Down (-0x01) Pattern change Band 5. Raster Signal Display of signals for step confirmation. White 0% Operational description Remote controller key Return to test mode menu RETURN Pattern change Band AVH-X8500BHS/XNUC...
Page 84
Black Operational description Remote controller key Return to test mode menu RETURN Pattern change Band 7. Center Marker Display of signal for screen central location setting. Center marker Operational description Remote controller key Return to test mode menu RETURN AVH-X8500BHS/XNUC...
Page 85
R:100% -> R:50% -> G:100% -> G:50% -> B:100% -> B:50% -> Black -> Gray -> White signal (The display of the screen will be changed in 1 second.) R: 100% Operational description Remote controller key Return to test mode menu RETURN Stop / restart of auto display Band AVH-X8500BHS/XNUC...
Page 86
Display of step signals and signals for alpha blend check. Right-white 64step Operational description Remote controller key Return to test mode menu RETURN Alpha blend Up (+0x10) Alpha blend Down (-0x10) Down Alpha blend Up (+0x01) Alpha blend Down (-0x01) Pattern change Band AVH-X8500BHS/XNUC...
Page 87
White 0% Operational description Remote controller key Return to test mode menu RETURN Pattern change Band 5. Center Marker Display of signal for screen central location setting. Center marker Operational description Remote controller key Return to test mode menu RETURN AVH-X8500BHS/XNUC...
(1) [MUTE] key + [VOL-] key -> Turn on BUP and ACC. (2) DVD SOURCE -> ON (3) Execute the test mode using each key. Display on function flow Operation Key VOL+ MUTE REAR SRC AUDIO MENU SUB TITLE TOP MENU EJECT EJECT AVH-X8500BHS/XNUC...
Page 90
3C00 0000 : CRG- Tracking close state FBAL coefficient (layer 0) FBAL coefficient (layer 1) Focus gain coefficient (layer 0) Focus gain coefficient (layer 1) Tracking gain coefficient (layer 0) Tracking gain coefficient (layer 1) AS normalization adjustment value (layer 0) AVH-X8500BHS/XNUC...
Page 91
Designation of digit by command (1) and (2). UP/DOWN of numbers by command (3) and (4). Fix by command (5). Power_OFF Error occurrence at Power_OFF [Note] If an error occurs at Power_OFF, reset cannot be made. In such a case, it is necessary to turn the power off and start the test mode once again. Error display AVH-X8500BHS/XNUC...
Page 92
[Note] If the power on time is 999999 hours or more, it is always reported as 999999 hours. [Note] If the power on time is “*E** ****”, the value may not be correct due to the life of the flash memory. AVH-X8500BHS/XNUC...
Page 93
5: Return CRG moves to the most outer Please Input Number Now Running Please Input Number <Error> ERROR 1: Power OFF select Code : 00000000 Please Input Number <Error : Power OFF> ERROR Code : 00000000 Please Reset AVH-X8500BHS/XNUC...
Monitor Assy Case Unit Cover Reverse the top and bottom of the product. Push the two tabs and then remove the Cover. Disconnect the connector and then remove the Monitor Assy and the Case Unit. Monitor Assy Case Unit Fig.2 AVH-X8500BHS/XNUC...
Page 95
Remove the Key Unit (Service). Spacer After the Key Unit (Service) is replaced, check the following items. Check whether all LED's light up Check the operation of all switches Check the operation of light receiving part of the remote controller Fig.4 AVH-X8500BHS/XNUC...
Page 96
DVD Mechanism Module. Fig.6 - Removing the Heat Sink and the Holder (Fig.7) Heat Sink Holder Remove the three screws and then remove the Heat Sink. Remove the two screws and then remove the Holder. Remove the two screws. Fig.7 AVH-X8500BHS/XNUC...
Page 97
- Removing the Tuner Amp PCB and the IF PCB (Fig.9) IF PCB Disconnect the connector. Remove the three screws and then remove the IF PCB. Remove the four screws and then remove the Tuner Amp PCB. Tuner Amp PCB Fig.9 AVH-X8500BHS/XNUC...
Page 98
If you tighten the screw after withdrawing it to the opposite direction of the arrow, the pitch between Worm Gear and Worm Wheel opens up and the gear jumps due to drop of package and abnormal sound may be generated. Fig.10 AVH-X8500BHS/XNUC...
Page 99
<<Drive Unit Gear set position>> The cutting lack of the Gear (ENV1635) is put between signs of the PCB. The point of the Frame (ENC2001) is set to the position of the mark of the Gear (ENV1630). AVH-X8500BHS/XNUC...
Page 100
- Removing the HDMI Unit (Fig.11) HDMI Unit Remove the solder and then straighten the tab. Remove the screw. Remove the screw. HDMI Unit Pull out the HDML Unit to the direction indicated by an arrow. Fig.11 AVH-X8500BHS/XNUC...
Press the EJECT key only after the disk has stopped completely. If the product hangs up turn the power OFF immediately. Don't touch the volume for laser power adjustment other than the time of POWER adjustment. (Laser diode may be damaged.) AVH-X8500BHS/XNUC...
Page 102
Adjustment screwdriver : crosshead, No.0, nonmetal (ceramic screwdriver for adjustment) Line Locating The following line locating is required. Power adjustment Power adjustment VREF1 Connection Diagram : Checking terminal for oscilloscope The figure in parentheses of resistor / capacitor is constant. Universal board VREF1 Enlarged For CDt For DVDt AVH-X8500BHS/XNUC...
Page 103
Adjust VR in order that this width is within the range of target FR level adjustment value. Power adjustment standard RF level adjustment value (The setup is completed. STEP 12, 26) 848 mV to 892 mV 658 mV to 702 mV AVH-X8500BHS/XNUC...
Page 104
16. Return the state of mecha to clockwise. 17. Set up again (state of mecha to clockwise / setting of DVD single layer) and conduct the final check of RF level and ERR rate. (Check in the state of Tracking Close) 18. Eject. AVH-X8500BHS/XNUC...
Page 105
(Check in the state of Tracking Close) 528 mV to 832 mV Refer to FE test mode function flow. 1.0E – 2 and under 32. Eject. Refer to FE test mode function flow. 33. Take out CD TCD-782 (or TCD-792). 34. Power off. AVH-X8500BHS/XNUC...
The clock signal is output from the CLKOUT terminal IC601 (Pin 106)(TP : CLKO). The frequency of the clock signal is 31.45728 MHz. If the clock signal out of the range, the X’tal (X601) should be replaced with new one. AVH-X8500BHS/XNUC...
(In the case of no amount instructions,apply as you think it appropriate.) 9.1 PACKING Tape RC, RD, RI, RC, RD, RI, UC, RC, RD UC, RC, RD RI, ID RI, ID EW5, UW5 UC, EW5, UW5 EW5, UW5, RI AVH-X8500BHS/XNUC...
Page 109
••••• USB Extended Cable CDP1587 Cord YDE5138 Card Remote Control Unit See Contrast table(2) (2) CONTRAST TABLE AVH-X8500BHS/XNUC, AVH-X8500BT/XNEW5, AVH-X8500BT/XNUW5, AVH-X8550BT/XNRC, AVH-X8550BT/ XNRD, AVH-X8550BT/XNRI and AVH-X8590BT/XNID are constructed the same except for the following: AVH-X8500BHS AVH-X8500BT AVH-X8500BT AVH-X8550BT Mark Description...
Page 110
* YRB5277 Finnish * YRB5278 Danish * YRB5279 Portuguese * YRB5280 Greek * YRB5281 Turkish All operation manuals are supplied in PDF files by the CD-ROM. Regarding the availability of paper manual, contact Pioneer Service representative in your region. AVH-X8500BHS/XNUC...
( A ) (NOTE) ( A ) (NOTE) ( A ) ( C ) ( C ) ( A ) : GEM1045 ( B ) : GEM1038 ( C ) : GEM1024 (NOTE) Apply grease to the whole part. AVH-X8500BHS/XNUC...
11.9 HDMI UNIT HDMI UNIT SIDE A HDMI AVH-X8500BHS/XNUC...
Page 205
HDMI UNIT SIDE B CN1346 AVH-X8500BHS/XNUC...
Page 206
11.10 PCB UNIT (SERVICE) PCB UNIT(SERVICE) SIDE A S101 VR101 HOME POSITION R103 R104 C101 R102 S102 IC101 HOME C103 MOTOR UNIT CN101 CN2091 AVH-X8500BHS/XNUC...
Page 207
PCB UNIT(SERVICE) SIDE B AVH-X8500BHS/XNUC...
The expression of the unit in this manual is shown by u instead of . Please do not make a mistake. Circuit Symbol and No. Part No. Circuit Symbol and No. Part No. Unit Name : SW Unit(Service) A:AVH-X8500BHS/XNUC Unit Number : YWM5608 B:AVH-X8500BT/XNEW5 Unit Name : HDMI Unit C:AVH-X8500BT/XNUW5 Unit Number : EXX2001...
Page 210
L 2011 (B,61,31) Inductor CTF1545 D 1461 (A,33,95) Diode 1SR154-400 L 2012 (B,70,35) Inductor CTF1545 D 1462 (A,33,99) Diode 1SR154-400 L 2013 (B,65,34) Inductor CTF1545 D 1463 (A,31,90) Diode 1SR154-400 D 1464 (A,34,90) Diode 1SR154-400 L 2031 (B,49,29) Inductor CTF1545 AVH-X8500BHS/XNUC...
Page 211
R 102 (A,111,108) RS1/16SS473J R 263 (B,51,79) RS1/16SS0R0J R 121 (B,60,121) RS1/4SA102J R 264 (B,51,84) RS1/16SS0R0J R 122 (B,54,120) RS1/4SA102J R 267 (B,35,84) RS1/16SS0R0J R 123 (B,58,121) RS1/4SA102J R 268 (B,30,75) RS1/16SS2200D R 131 (A,94,100) RS1/16SS102J R 271 (B,28,81) RS1/16SS750J AVH-X8500BHS/XNUC...
Page 212
R 435 (A,149,83) RS1/16SS104J R 578 (A,29,25) RS1/16SS221J R 436 (A,152,83) RS1/16SS821J R 579 (A,30,25) RS1/16SS221J R 437 (A,154,83) RS1/16SS821J R 580 (A,33,25) RS1/16SS221J R 438 (A,160,79) RS1/16SS0R0J R 581 (A,32,25) RS1/16SS221J R 443 (B,117,61) RS1/16SS0R0J R 582 (A,34,25) RS1/16SS221J AVH-X8500BHS/XNUC...
Page 213
R 661 (B,35,55) RS1/16SS473J R 798 (B,25,111) RS1/16SS472J R 662 (A,34,57) RS1/16SS473J R 811 (A,144,16) RS1/16SS102J R 663 (A,34,61) RS1/16SS473J R 812 (A,144,14) RS1/16SS473J R 664 (A,29,27) RS1/16SS104J R 821 (A,149,14) RS1/16SS473J R 665 (B,29,27) RS1/16SS104J R 822 (A,151,14) RS1/16SS104J AVH-X8500BHS/XNUC...
Page 214
R 903 (B,22,66) RS1/10SR681J R 1028 (A,162,72) RS1/10SR0R0J R 904 (A,18,45) RS1/16SS680J R 1029 (B,162,72) RS1/10SR0R0J R 905 (A,18,46) RS1/16SS680J R 1030 (B,148,72) RS1/16SS221J R 907 (A,18,47) RS1/16SS473J R 1031 (B,147,71) RS1/16SS221J R 908 (B,22,69) RS1/16SS103J R 1034 (A,164,50) RS1/16SS330J AVH-X8500BHS/XNUC...
Page 215
R 1103 (A,143,39) RS1/16SS100J R 1175 (A,127,52) RS1/16SS0R0J R 1104 (B,143,38) RS1/16SS100J R 1176 (B,153,64) RS1/16SS471J R 1105 (B,140,38) RS1/16SS100J R 1177 (A,131,54) RS1/16SS103J R 1106 (A,158,48) RS1/16SS330J R 1178 (B,159,74) RS1/16SS101J R 1107 (B,149,39) RS1/16SS100J R 1179 (A,164,46) RS1/16SS561J AVH-X8500BHS/XNUC...
Page 216
R 1322 (B,93,83) RS1/16SS561J R 1435 (A,67,60) RS1/16SS221J R 1323 (B,93,81) RS1/16SS3302D R 1436 (A,65,60) RS1/16SS221J R 1324 (B,94,81) RS1/16SS4301D R 1437 (A,63,60) RS1/16SS473J R 1325 (B,95,81) RS1/16SS3601D R 1438 (A,63,58) RS1/16SS103J R 1326 (B,87,80) RS1/10SR0R0J R 1439 (A,65,57) RS1/16SS0R0J AVH-X8500BHS/XNUC...
Page 217
C 188 (B,49,92) CKSRYB105K10 R 2042 (A,163,28) RS1/10SR102J C 189 (B,49,91) CKSRYB105K10 R 2052 (B,103,25) RAB4CQ750J C 190 (B,48,102) CKSRYB105K10 R 2055 (A,106,25) RS1/16SS223J C 191 (B,44,104) CKSRYB105K10 R 2056 (A,111,28) RS1/10SR102J C 192 (B,32,101) CKSRYB105K10 R 2057 (A,113,28) RS1/10SR102J AVH-X8500BHS/XNUC...
Page 218
CKSRYB105K10 C 523 (B,101,48) CKSSYB104K10 C 301 (B,48,78) CKSRYB105K10 C 524 (A,103,41) CKSSYB104K10 C 302 (B,48,81) CKSRYB105K10 C 526 (B,103,40) CKSSYB104K10 C 304 (B,33,73) CKSSYB104K16 C 530 (B,90,44) 10 uF DCH1201 C 305 (B,33,72) CKSSYB104K16 C 531 (B,97,40) CKSSYB104K10 AVH-X8500BHS/XNUC...
Page 219
DCH1256 C 1009 (B,136,66) CKSSYB104K10 C 844 (B,122,100) CKSSYB104K16 C 1010 (B,136,64) CKSSYB104K10 C 845 (B,122,89) 10 uF CCG1236 C 1011 (B,135,60) CKSSYB104K10 C 846 (A,135,100) XCEVW101M16 C 1012 (B,140,62) CKSSYB104K10 C 847 (B,113,94) CKSRYB105K10 C 1013 (B,139,62) CKSSYB104K10 AVH-X8500BHS/XNUC...
Page 220
C 1236 (A,159,23) CKSSYB104K10 C 1074 (B,140,51) CKSSYB104K10 C 1237 (B,130,24) CKSSYB105K6R3 C 1075 (B,147,56) CKSSYB104K10 C 1238 (B,155,24) CKSSYB105K6R3 C 1076 (B,141,51) CKSSYB104K10 C 1239 (B,131,23) 10 uF DCH1201 C 1078 (B,147,55) CKSSYB104K10 C 1240 (B,157,25) 10 uF DCH1201 AVH-X8500BHS/XNUC...
Page 221
C 1396 (A,127,71) 10 uF DCH1201 C 1397 (A,127,73) 10 uF DCH1201 C 2033 (B,48,35) CCSSCH101J50 C 2041 (A,162,25) CKSRYB104K50 C 1401 (A,112,53) 10 uF DCH1201 C 2042 (A,166,26) CKSRYB104K50 C 1402 (A,102,52) 10 uF DCH1201 C 2093 (A,53,46) CKSRYB104K16 AVH-X8500BHS/XNUC...
Page 222
Q 571 (A,25,12) Chip Transistor RN4982 IC 601 (A,39,42) IC PEQ136A8 Q 572 (A,28,15) Chip Transistor HN1C03FU Q 591 (A,48,90) Transistor UMF23N IC 602 (B,58,35) RESET IC S-80829CNMC-B8O Q 601 (A,60,48) Transistor LSCR523UB IC 771 (B,147,107)L-MOS And Gate(C,D,E,F,G) TC7SET08FUS1 AVH-X8500BHS/XNUC...
Page 223
D 714 (B,82,25) Diode DZ2S068C D 1463 (A,31,90) Diode 1SR154-400 D 715 (B,81,25) Diode DZ2S068C D 1464 (A,34,90) Diode 1SR154-400 D 716 (B,79,25) Diode DZ2S068C D 1475 (A,45,97) Diode CRG03 D 717 (B,78,25) Diode DZ2S068C D 2012 (B,66,31) Diode DZ2S068C AVH-X8500BHS/XNUC...
Page 224
CKS6273 L 1601 (B,157,84) Chip Beads VTL1126 JA121 (A,62,118) Plug CKM1376 JA771 (A,147,118) Jack(C,D,E,F,G) CKN1042 L 2011 (B,61,31) Inductor CTF1545 JA781 (A,35,120) Pin Jack XKB7001 L 2012 (B,70,35) Inductor CTF1545 JA811 (A,138,10) Jack CKS6437 L 2013 (B,65,34) Inductor CTF1545 AVH-X8500BHS/XNUC...
Page 225
R 235 (B,50,66) RS1/10SR153J R 404 (B,163,27) RS1/16SS101J R 236 (B,53,59) RS1/10SR153J R 405 (B,167,31) RS1/16SS103J R 237 (A,54,58) RS1/10SR273J R 406 (B,165,30) RS1/16SS103J R 238 (B,51,60) RS1/10SR153J R 421 (B,120,59) RS1/16SS102J R 239 (A,53,58) RS1/10SR273J R 422 (B,119,53) RS1/16SS472J AVH-X8500BHS/XNUC...
Page 226
R 508 (B,141,99) RS1/16SS101J R 635 (B,47,52) RS1/16SS473J R 510 (B,128,92) RS1/16SS151J R 636 (A,48,57) RS1/16SS473J R 512 (B,149,87) RS1/16SS331J R 638 (A,42,58) RS1/16SS104J R 514 (A,130,90) RS1/16SS750J R 639 (B,43,32) RS1/16SS103J R 515 (A,130,88) RS1/16SS0R0J R 640 (B,42,57) RS1/16SS103J AVH-X8500BHS/XNUC...
Page 227
R 705 (A,24,47) RS1/16SS0R0J R 860 (B,115,101) RS1/16SS224J R 706 (B,72,18) RS1/16SS472J R 861 (B,118,102) RS1/16SS4702D R 707 (B,70,24) RS1/16SS472J R 862 (B,112,90) RS1/16SS152J R 729 (B,78,17) RS1/16SS222J R 863 (B,113,91) RS1/16SS3302D R 738 (B,80,17) RS1/16SS222J R 864 (B,111,93) RS1/16SS8201D AVH-X8500BHS/XNUC...
Page 228
R 1008 (A,157,54) RS1/16SS330J R 1075 (A,131,47) RS1/16SS101J R 1009 (A,166,53) RS1/16SS330J R 1077 (B,135,48) RS1/16SS0R0J R 1010 (A,164,52) RS1/16SS330J R 1079 (B,139,51) RS1/16SS82R0D R 1011 (A,159,53) RS1/16SS330J R 1080 (B,137,48) RS1/16SS82R0D R 1012 (A,157,71) RS1/16SS105J R 1086 (A,159,49) RS1/16SS330J AVH-X8500BHS/XNUC...
Page 229
R 1148 (B,128,57) RS1/16SS0R0J R 1217 (A,121,45) RS1/16SS121J R 1149 (B,131,56) RS1/16SS0R0J R 1218 (A,123,45) RS1/16SS121J R 1150 (B,129,56) RS1/16SS0R0J R 1219 (A,121,43) RS1/16SS121J R 1159 (A,158,64) RS1/16SS331J R 1220 (A,123,43) RS1/16SS121J R 1160 (A,158,65) RS1/16SS331J R 1221 (A,121,44) RS1/16SS121J AVH-X8500BHS/XNUC...
Page 230
R 2012 (B,61,33) RS1/16SS750J R 1407 (A,111,47) RS1/16SS1302D R 2013 (B,64,31) RS1/10SR0R0J R 1408 (A,111,45) RS1/16SS6801D R 2014 (B,67,31) RS1/10SR0R0J R 1409 (A,109,54) RS1/16SS5R6J R 2017 (B,68,35) RS1/16SS223J R 1411 (A,104,47) RS1/16SS102J R 1412 (A,117,68) RS1/16SS102J R 2018 (B,67,34) RS1/16SS223J AVH-X8500BHS/XNUC...
Page 231
C 243 (A,59,69) CKSRYB104K16 R 6009 (A,62,38) RS1/4SA5R6J R 6010 (B,58,33) RS1/16SS102J C 246 (A,55,64) CCSSCH101J50 R 6011 (A,45,29) RS1/16SS0R0J C 247 (A,56,59) CKSQYB225K10 R 6014 (A,64,38) RS1/4SA5R6J C 261 (B,39,69) CKSRYB105K10 R 6015 (A,66,38) RS1/4SA5R6J C 262 (B,48,70) CKSRYB105K10 AVH-X8500BHS/XNUC...
Page 232
C 477 (B,129,93) CKSRYB105K16 C 608 (B,53,29) CKSSYB104K10 C 478 (B,132,94) CKSSYB102K50 C 609 (B,55,37) CKSSYB104K10 C 479 (B,131,96) CKSRYB105K16 C 610 (B,49,36) CKSQYB475K6R3 C 480 (B,135,83) CKSSYB102K50 C 611 (A,52,27) CKSSYB104K10 C 481 (B,132,85) CKSRYB105K16 C 613 (A,39,27) CKSSYB104K10 AVH-X8500BHS/XNUC...
Page 233
C 877 (B,123,36) CKSSYB104K10 C 1040 (B,136,59) CKSSYB104K10 C 878 (B,126,13) CKSSYB104K10 C 1041 (A,129,60) CCSSCH100D50 C 879 (B,117,42) CKSSYB104K10 C 1042 (B,150,59) CKSSYB104K10 C 880 (B,127,9) CKSRYB104K16 C 1043 (B,150,58) CKSSYB104K10 C 901 (B,21,70) CKSQYB225K10 C 1044 (B,150,57) CKSSYB104K10 AVH-X8500BHS/XNUC...
Page 234
C 1203 (B,128,33) CKSSYB104K10 C 1332 (B,90,79) CCSSCH8R0D50 C 1204 (B,128,31) CKSSYB104K10 C 1333 (B,84,73) CKSYB105K35 C 1205 (B,131,31) CKSSYB104K10 C 1334 (B,88,80) CKSSYB104K16 C 1206 (B,128,30) CKSSYB104K10 C 1335 (B,88,67) CKSSYB104K16 C 1207 (B,128,28) CKSSYB104K10 C 1336 (B,90,67) CCSSCH8R0D50 AVH-X8500BHS/XNUC...
Page 235
C 6007 (A,56,18) CKSSYB104K10 C 1445 (B,68,76) 4.7 uF CCG1222 C 6008 (A,64,13) CCSSCJ3R0C50 C 1446 (B,68,69) CKSRYB104K16 C 6009 (A,50,20) CKSSYB103K16 C 1447 (B,65,65) CKSSYB104K16 C 6010 (A,56,19) CKSSYB103K16 C 1448 (B,64,64) 4.7 uF CCG1222 C 6011 (A,59,18) CKSSYB103K16 AVH-X8500BHS/XNUC...
Page 236
(A,39,33) IC MN2DS0018MA R 1482 (A,72,32) RAB4CQ560J IC 1801 (B,34,16) D/A Converter PCM1753DBQ R 1483 (A,72,35) RAB4CQ560J IC 1953 (B,57,17) IC S-1135D12-A6 R 1484 (A,72,39) RAB4CQ560J Q 1101 (B,13,59) Transistor LSCR523UB R 1485 (A,55,22) RAB4CQ560J Q 1102 (B,13,56) Transistor LSCR523UB AVH-X8500BHS/XNUC...
Page 237
R 1803 (B,37,13) RS1/16SS821J C 1510 (B,51,18) CCSSCH100D50 R 1804 (B,39,14) RS1/16SS821J C 1511 (A,48,18) CKSSYB104K10 R 1982 (A,10,62) RS1/16SS822J R 1983 (B,40,20) RS1/16SS1000D C 1512 (B,45,18) CCSSCH100D50 R 1987 (B,43,21) RS1/16SS0R0J C 1513 (A,48,48) CKSSYB104K10 C 1514 (B,45,21) CKSSYB104K10 AVH-X8500BHS/XNUC...
Page 238
Unit Number : YXX5128 CN4053 (A,119,79) Connector DKN1220 CN4131 (A,129,9) Connector CKS6524 Unit Name : Monitor Unit(Service) CN4151 (A,120,19) Connector CKS6327 CN4400 (A,32,29) Connector CKS6536 MISCELLANEOUS IC 4001 (A,138,74) IC BD81A04EFV-M RESISTORS IC 4051 (A,93,74) IC NJM2886DL3-33 IC 4151 (A,132,20) IC AK4187VN AVH-X8500BHS/XNUC...
Page 239
R 4248 (A,26,72) RS1/16SS102J R 4408 (A,44,45) RS1/16SS47R0D R 4249 (A,24,68) RS1/16SS473J R 4409 (A,43,46) RS1/16SS0R0J R 4251 (A,22,34) RS1/16SS121J R 4410 (A,44,47) RS1/16SS39R0D R 4252 (A,22,36) RS1/16SS121J R 4411 (A,43,48) RS1/16SS4R7J R 4253 (A,11,55) RS1/16SS121J R 4412 (A,44,49) RS1/16SS1000D AVH-X8500BHS/XNUC...
Page 240
(A,161,6) Remote Receiver Unit RS-470 CN5001 (B,33,6) Connector CKS6291 C 4211 (A,14,47) CKSSYB104K10 C 4302 (A,46,81) CKSYB475K16 RESISTORS C 4304 (A,60,80) CKSSYB561K50 C 4305 (A,64,74) CKSSYB683K10 R 5001 (A,71,4) RS1/16SS182J C 4306 (A,64,73) CCSQCH101J50 R 5002 (A,61,4) RS1/16SS222J R 5003 (A,53,4) RS1/16SS472J AVH-X8500BHS/XNUC...
Page 241
(A,36,21) RS1/16SS0R0J D 12 (A,36,19) Diode EZAEG2A50AX R 47 (A,34,21) RS1/16SS0R0J D 13 (A,60,22) Diode CRG03 R 48 (A,31,21) RS1/16SS0R0J D 14 (A,38,14) Diode DA2J101 R 49 (B,29,10) RS1/16SS473J (A,25,18) Filter CTF1834 (A,23,18) Filter CTF1834 R 50 (B,34,11) RS1/16SS473J AVH-X8500BHS/XNUC...
Page 242
CCG1212 C 13 (B,26,10) 10 uF DCH1201 C 15 (B,20,3) CKSRYB105K10 C 16 (B,24,5) CCSRCH182J50 C 17 (B,26,6) CCSRCH182J50 C 29 (A,16,11) CCSSCH470J50 C 38 (B,16,16) CCSSCH220J50 C 39 (B,25,13) CCSSCH220J50 C 40 (B,25,16) CCSSCH220J50 C 41 (B,25,14) CCSSCH220J50 AVH-X8500BHS/XNUC...