Trademarks used in this text: Dell, the DELL logo, and Latitude are trademarks of Dell Inc.; Bluetooth is a registered trademark owned by Bluetooth SIG, Inc. and is used by Dell

under license.

Other trademarks and trade names may be used in this document to refer to either the entities claiming the marks and names or their products. Dell Inc. disclaims any

proprietary interest in trademarks and trade names other than its own.

September 2009 Model PP04X Rev. A01

Table of Contents

Summary of Contents for Dell Latitude D830

Page 1 Reproduction in any manner whatsoever without the written permission of Dell Inc. is strictly forbidden. Trademarks used in this text: Dell, the DELL logo, and Latitude are trademarks of Dell Inc.; Bluetooth is a registered trademark owned by Bluetooth SIG, Inc. and is used by Dell under license.
Page 2 Back to Contents Page Base Dell™ Latitude™ D830 Service Manual CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 3 Back to Contents Page Battery Latch Dell™ Latitude™ D830 Service Manual CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 4 Damage due to servicing that is not authorized by Dell is not covered by your warranty. Read and follow the safety instructions that came with the product.
Page 5 NOTICE: When you disconnect a cable, pull on its connector or on its pull-tab, not on the cable itself. Some cables have a connector with locking tabs; if you are disconnecting this type of cable, press in on the locking tabs before you disconnect the cable. As you pull connectors apart, keep them evenly aligned to avoid bending any connector pins.
Page 6 front left back right Back to Contents Page ...
Page 7 Back to Contents Page Internal Card with Bluetooth® Wireless Technology Dell™ Latitude™ D830 Service Manual CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 9 Back to Contents Page Using Cards Dell™ Latitude™ D830 Service Manual Card Types Card Blanks Extended Cards Installing a PC Card or ExpressCard Removing a Card or Blank Card Types CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Page 10 The computer recognizes most cards and automatically loads the appropriate device driver. If the configuration program tells you to load the manufacturer's drivers, use the floppy disk or CD that came with the PC Card. ExpressCard 1. Hold the card with its orientation symbol pointing into the slot and the top side of the card facing up. The latch may need to be in the "in" position before you insert the card.
Page 11 Back to Contents Page ...
Page 12 Back to Contents Page Coin-Cell Battery Dell™ Latitude™ D830 Service Manual CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 13 Back to Contents Page Processor Module Dell™ Latitude™ D830 Service Manual Removing the Processor Module Installing the Processor Module Removing the Processor Module CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 14 Installing the Processor Module NOTICE: Ensure that the cam lock is in the fully open position before seating the processor module. Seating the processor module properly in the ZIF socket does not require force. NOTICE: A processor module that is not properly seated can result in an intermittent connection or permanent damage to the processor and ZIF socket.
Page 15 Back to Contents Page Processor Thermal-Cooling Assembly Dell™ Latitude™ D830 Service Manual CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 16 Back to Contents Page Display Assembly Dell™ Latitude™ D830 Service Manual Removing the Display Assembly Removing the Display Bezel Removing the Display Panel Installing the Display Panel Removing the Display Panel Brackets Removing the Display Latch Removing the Display Assembly CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide.
Page 17 M2.5 x 5-mm screws labeled "D" (2) 10. From the back of the computer, remove the two M2.5 x 5-mm screws. M2.5 x 5-mm screws (2) 11. Turn the computer top-side up and open the display. 12. Lift the display assembly out of the computer base. Removing the Display Bezel ...
Page 18 screws (8) display bezel top cover NOTICE: Carefully separate the bezel from the top cover to avoid damage to the bezel. 5. Starting from the sides of the display panel, use your fingers to separate the bezel from the top cover and lift the bezel away from the top cover. Removing the Display Panel ...
Page 19 3. Replace the display bezel . Removing the Display Panel Brackets CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 20 6. Slide the display latch toward the right side of the top cover and straight out. display latch latch spring 7. Unhook the latch spring from the display latch, and then lift away the latch. Back to Contents Page ...
Page 21 Back to Contents Page Fan Dell™ Latitude™ D830 Service Manual CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 22 Back to Contents Page FCM (Flash Cache Module) Dell™ Latitude™ D830 Service Manual CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 23 FCM card NOTICE: When installing this card, ensure that the two antenna cables are not under the card. The antenna cables are designed to lie across the top of the FCM card and into the protective sleeve. Installing the card on top of these antenna cables may cause damage to your computer. Also, do not install the FCM card in the WLAN card connector.
Page 24 1. Ensure that the AC adapter is plugged in, the main battery is properly installed, and a network cable is attached. 2. Turn on the computer. 3. Locate the latest BIOS update file for your computer at support.dell.com. 4. Click Download Now to download the file. ...
Page 25 Dell does not guarantee compatibility or provide support for hard drives from sources other than Dell. NOTE: If you are installing a hard drive from a source other than Dell, you need to install an operating system, drivers, and utilities on the new hard drive. To replace the hard drive in the hard drive bay: ...
Page 26 5. Slide the hard drive bezel that you took off the old hard drive onto the new hard drive and fasten the two M3 x 5-mm screws on the sides of the bezel. NOTICE: Use firm and even pressure to slide the drive into place. If you use excessive force, you may damage the connector. ...
Page 27 Back to Contents Page Hinge Cover Dell™ Latitude™ D830 Service Manual CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 29 Back to Contents Page Keyboard Dell™ Latitude™ D830 Service Manual CAUTION: Before working inside your Dell™ computer, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer. 1. Follow the procedures in Before You Begin.
Page 30 If you remove your original memory modules from the computer during a memory upgrade, keep them separate from any new modules that you may have, even if you purchased the new modules from Dell. If possible, do not pair an original memory module with a new memory module.
Page 31 the module and reinstall it. 7. Replace the keyboard (see Keyboard). 8. Replace the hinge cover (Hinge Cover). 9. Insert the battery into the battery bay, or connect the AC adapter to your computer and an electrical outlet. ...
Page 32 memory module securing clips (2) NOTICE: If you need to install memory modules in two connectors, install a memory module in the connector labeled "DIMM A" before you install a module in the connector labeled "DIMM B." Insert memory modules at a 45-degree angle to avoid damaging the connector. NOTE: If the memory module is not installed properly, the computer may not boot properly.
Page 33 Back to Contents Page Communications Cards Dell™ Latitude™ D830 Service Manual Wireless Cards Subscriber Identity Module (SIM) Card (optional) Wireless Cards If you ordered a wireless LAN or WAN card with your computer, the card is already installed. CAUTION: Before you begin any of the procedures in this section, follow the safety instructions in the Product Information Guide.
Page 34 WLAN card metal securing brackets (2) c. Lift the card out of its connector. NOTICE: The connectors are keyed to ensure correct insertion. If you feel resistance, check the connectors and realign the card. NOTICE: Do not insert a WWAN (Mobile Broadband) network card into the WLAN card slot. NOTE: The WLAN card may have two or three connectors, depending on the type of card you ordered.
Page 35 WWAN card metal securing brackets (2) c. Lift the card out of its connector. NOTICE: The connectors are keyed to ensure correct insertion. If you feel resistance, check the connectors and realign the card. 6. Install the card: ...
Page 36 SIM card Back to Contents Page ...
Page 37 Back to Contents Page Modem Dell™ Latitude™ D830 Service Manual CAUTION: Before you begin the following procedure, see the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 38 Back to Contents Page Palm Rest Dell™ Latitude™ D830 Service Manual CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 39 12. Disconnect the touch pad connector and the speaker connector from the system board. NOTICE: When replacing the palm rest, ensure the cable for the internal card with Bluetooth wireless technology is properly placed on top of the palm rest to avoid damaging the cable. Back to Contents Page ...
Page 40 Back to Contents Page PC Card Reader Dell™ Latitude™ D830 Service Manual CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 41 Back to Contents Page Pin Assignments for I/O Connectors Dell™ Latitude™ D830 Service Manual USB Connector Video Connector S-Video TV-Out Connector Serial Connector USB Connector Signal USB5V+ USBP– USBP+ Video Connector Signal Signal CRT_R 9 CRT_G 10 CRT_B 11 MONITOR_DETECT–...
Page 42 S-Video Signal DLUMA-L DCRMA-L Serial Connector Signal Signal RXDA TXDA Back to Contents Page ...
Page 43 Back to Contents Page System Board Dell™ Latitude™ D830 Service Manual Removing the System Board Installing the System Board Removing the System Board CAUTION: Before performing the following procedures, follow the safety instructions in the Product Information Guide. NOTICE: To avoid electrostatic discharge, ground yourself by using a wrist grounding strap or by periodically touching a connector on the back panel of the computer.
Page 44 15. Remove the four hex screws on the back of the computer. 16. Lift the system board out and away from the base. Installing the System Board 1. Perform all the steps in Removing the System Board in reverse order. NOTE: When installing the system board, ensure that you align the wireless switch on the base with the switch on the system board.
Page 45 Reproduction in any manner whatsoever without the written permission of Dell Inc. is strictly forbidden. Trademarks used in this text: Dell, the DELL logo, and Latitude are trademarks of Dell Inc.; Bluetooth is a registered trademark owned by Bluetooth SIG, Inc. and is used by Dell under license.

Dell Latitude D830 Service Manual

Quick Links

Related Manuals for Dell Latitude D830

Summary of Contents for Dell Latitude D830

Table of Contents