Safety Rules - Generac Power Systems RV 45 SERIES Owner's Manual


DANGER: For fire safety, installation of a generator into a recreational vehicle must comply strictly with article 551, NFPA 70;
ANSI C1-1975; AND, ANSI A119.2-1975/NFPA 501C "Standard for Recreational Vehicles" (Part 3, "Installation of Electrical
Systems"). In addition, installation must comply with the manufacturer's instructions and recommendations.
NOTICE TO INSTALLER
These Installation Instructions have been published by the manu-
facturer to aid in the installation of the products described in this
manual. The manufacturer assumes that installation personnel
are familiar with the procedures for installing such products, or
similar products manufactured. The manufacturer also assumes
that personnel have been trained in the recommended installation
procedures for these products and that such training includes (a)
use of common hand tools, (b) use of special tools, and (c) use of
any tools and/or equipment from other suppliers.
The manufacturer cannot possibly know of and advise the rec-
reational vehicle trade of all conceivable methods, procedures or
techniques by which to perform an installation. Nor can the manu-
facturer anticipate every possible hazard that might result from
each installation method, procedure or technique. The manufactur-
er has not undertaken any such wide evaluation. Therefore, people
who use a method, procedure or technique that the manufacturer
does not specifically recommend must first completely satisfy
themselves that their safety, the safety of the vehicle's occupants
and the product's safety is not endangered by the method, proce-
dure or technique selected.
Information, illustrations, specifications, etc., contained in these
Installation Instructions are based on the latest information avail-
able at the time of publication. Every effort has been expended
to be sure that such data is both accurate and current. However,
the manufacturer reserves the right to change, alter or otherwise
improve this product at any time without prior notice.
DANGER

Despite the safe design of this generator,
operating this equipment imprudently, neglecting
its maintenance or being careless can cause
possible injury or death. Permit only responsible
and capable persons to operate or maintain this
equipment.

Potentially lethal voltages are generated by
these machines. Ensure all steps are taken to
render the machine safe before attempting to
work on the generator.

Parts of the generator are rotating and/or hot
during operation. Exercise care near running
generators.
18

Safety Rules

Recreational Vehicle Generators

GENERAL HAZARDS
• For safety reasons, the manufacturer recommends that the
installation, initial start-up and maintenance of this equipment
is carried out by an Authorized Service Dealer.
• The generator engine releases DEADLY carbon monoxide gas
through its exhaust system. This dangerous gas, if breathed
in sufficient concentrations, can cause unconsciousness or
even death. Never operate the generator set with the vehicle
inside any garage or other enclosed area. DO NOT OPERATE
THE GENERATOR IF THE EXHAUST SYSTEM IS LEAKING OR
HAS BEEN DAMAGED. SYMPTOMS OF CARBON MONOXIDE
POISONING ARE (a) inability to think coherently, (b) nausea,
(c) vomiting, (d) twitching muscles, (e) throbbing temples,
(f) dizziness, (g) headaches, (h) weakness, and (i) sleepi-
ness. IF EXPERIENCING ANY OF THESE SYMPTOMS, MOVE
INTO FRESH AIR IMMEDIATELY. IF SYMPTOMS PERSIST, GET
MEDICAL HELP . Shut down the generator and do not operate it
until it has been inspected and repaired.
• Never sleep in the vehicle while the genset is running unless the
vehicle has a working carbon monoxide detector. The exhaust
system must be installed in accordance with the genset instal-
lation manual. Make sure there is ample fresh air when operat-
ing the genset in a confined area.
• Keep hands, feet, clothing, etc., away from drive belts, fans,
and other moving or hot parts. Never remove any drive belt or
fan guard while the unit is operating.
• Adequate, unobstructed flow of cooling and ventilating air is
critical to correct generator operation and is required to expel
toxic fumes and fuel vapors from the generator compartment.
Without sufficient cooling airflow, the engine/generator quickly
overheats, which causes serious damage to the generator. Do
not alter the installation or permit even partial blockage of ven-
tilation provisions, as this can seriously affect safe operation of
the generator.
• When working on this equipment, remain alert at all times.
Never work on the equipment when physically or mentally
fatigued.
• Before performing any maintenance on the generator, discon-
nect its battery cables to prevent accidental start up. Disconnect
the cable from the battery post indicated by a NEGATIVE, NEG
or (–) first. Reconnect that cable last.

