DUAL BAND Mobile Cellular Phone ELECTRONICS SGH-R220E SERVICE Manual DUAL BAND MOBILE CELLULAR PHONE CONTENTS 1. Exploded Views and Parts List 2. PCB Diagrams 3. Electrical Parts List 4. Block Diagrams 5. Flow Chart of Troubleshooting and Circuit Diagrams...
1. Exploded Views and Parts List Main Main Parts List Travel Adapter Travel Adapter Parts List Ciger Light Adapter Ciger Light Adapter Parts List Test Jig EAR Microphone Data Kit 1-10 Battery Charger 2. PCB Diagrams Main Top Main Bottom 3.
Page 4
1. SGH-R220E Exploded Views and Parts List 1-1 Main Exploded Views and Parts List...
1-2 Main Parts List SEC CODE Location Remark Description Dark Gray Navy Blue Green GH75-01483B GH75-01483C MEC-FRONT COVER GH75-01483A 3001-001233 3001-001233 SPEAKER 3001-001233 GH59-00240B GH59-00240B GH59-00240B F1 KEY GH72-02782A GH72-02782A GH72-02782A KEY PAD GH75-01164A GH75-01164A GH75-01164A 3002-001098 3002-001098 BUZZER 3002-001098 MAIN PBA GH92-01333A GH92-01333A...
1-3 Travel Adapter 1-4 Travel Adapter Parts List TYPE SEC CODE REMARK GH44-00171A CHINA GH44-00184A EUROPE GH44-00171C UNITED KINGDOM Gh44-00171E TAIWAN Exploded Views and Parts List...
1-5 Ciger Light Adapter 1-6 Ciger Light Adapter Parts List DESCRIPTION SEC CODE REMARK Ciger Light Adapter Code GH44-00170A BLACK Exploded Views and Parts List...
1-7 Test Jig TEST JIG GH80-10508A TEST JIG CABLE GH39-00079A RF CABLE GH39-00090A Exploded Views and Parts List...
Page 9
1-7-1 Test Jig POWER SUPPLY 8922 or 8960 WIRELESS COMMUNICATIONS TEST SET RF CABLE TEST JIG CABLE 232 CABLE Note PC Exploded Views and Parts List...
3. Electrical Parts List 3-1 Main Parts List Top NO Refer Part Description Vendor Part No. ence CODE D441 0401-001033 DIODE-SWITCHING “MCL4154,25V,200mA,M-MELF,TP” MCL4154 D406 0406-001083 DIODE-TVS “-,6.1/-/7.2V,150W,SOT-323-5L” ESDA6V1W5 D407 0406-001083 DIODE-TVS “-,6.1/-/7.2V,150W,SOT-323-5L” ESDA6V1W5 D408 0406-001083 DIODE-TVS “-,6.1/-/7.2V,150W,SOT-323-5L” ESDA6V1W5 0406-001083 DIODE-TVS “-,6.1/-/7.2V,150W,SOT-323-5L”...
5. Flow Chart of Troubleshooting and Circuit Diagrams 5-1 Power ON 'POWER ON'does not work Check the Battery Voltage Charge the Battery is more than 3.2V When the "END" key is pressed, the voltage of "D304 pin1" Check the Dome sheet 3.6V? U474 pin 2,3 >...
Page 27
Flow Chart of Troubleshooting and Circuit Diagrams...
Page 28
5-2 Initial Initial Failure After power on, Downloading SW is OK ? check and repair the important (Is CSROM signal OK ?) signals of U618 as follows The node Check the circuit between R661 and C712 related to reset = "H" (RST) R348 = "H"...
Page 29
Flow Chart of Troubleshooting and Circuit Diagrams...
5-3 Charging Part Abnormal charging part Check the J403 pin 17,18 > 4.9 V ? Replace TA Check the U614 pin 3 > 4.9 V ? Resolder C710 R594(CHG_ON side) = "L" ? Resolder R594 Resolder components around Check the U614 pin 5 4.2V ? U614 Flow Chart of Troubleshooting and Circuit Diagrams...
Page 31
Flow Chart of Troubleshooting and Circuit Diagrams...
5-4 Sim Part Phone can't access SIM card Q402 pin4 = 3.0 V ? Check the circuit around U620 Replace Q402 or Q402 pin5 = "H" ? Replace PBA Replace Q402 or Q402 pin 2, 3 = 3.0 V ? Resolder C434 After Power ON, Resoldering C718 or...
Page 33
Flow Chart of Troubleshooting and Circuit Diagrams...
5-5 Microphone Part Microphone does not work U400 pin 4, 5 = short? Resolder U400 U619 pin 3 (AVCC) 2.5V? Check the circuit related to U619 Resolder the Check the circuit R444,R445,R446,R447, from U618 to MIC1 C446,C450,C451 Check the tension of MIC Module Replace the Mic or Mic Holder Flow Chart of Troubleshooting and Circuit Diagrams...
Page 35
5-10 Flow Chart of Troubleshooting and Circuit Diagrams...
5-6 Speaker Part Speaker does not work U400 pin 2, 3 = short Resolder U400 U400 pin 2, 3, 6 = 1.25 V ? Replace the PBA Check Modify the SPK pins the tension of the Speaker Is Speaker working? Replace the Speaker Flow Chart of Troubleshooting and Circuit Diagrams 5-11...
Page 37
5-12 Flow Chart of Troubleshooting and Circuit Diagrams...
5-7 Key Data Input Check Initial operation When one of the keys is pushed, Check the Dome sheet is it displayed on LCD Keypad is OK ? Replace the PBA Flow Chart of Troubleshooting and Circuit Diagrams 5-13...
5-8 Alert Tone Abnormal Alert tone Is there alert wave form on the ALERT by Test S/W R305 during alert tone test? Is there alert wave form on the Check the circuit related to Q300 Q300 pin 3 during alert tone test? U470 pin 5 3.0V? Check the circuit related to U470...
Page 40
Flow Chart of Troubleshooting and Circuit Diagrams 5-15...
5-9 Ring Indicator Ring Indicator LED does not work U621 pin 5 3.3V? Check the circuit related to U621 Is Green color of Check U651,R644,LED1 3 LEDs correctly work? Is Red color LED of Check U651,R642,LED1 3 LEDs correctly work? Is Blue color LED of Check Q411,R728,LED2 3 LEDs correctly work?
5-10 Back Light Backlight does not work Backlight "ON" mode Select backlight "ON" mode in the menu? R575 = "H" ? GPO1 by test S/W LCD BACKLIGHT KEY PCB LED Resolder R575,R579 Q403 pin 3 = "L" ? or replace Q403 LCD backlight on ? Replace LCD Resolder R575,R579...
Page 44
Flow Chart of Troubleshooting and Circuit Diagrams 5-19...