Driving Safety ................................................................................................................................... 2-1

Fuel and Propane Gas ....................................................................................................................... 2-1

LP Gas Leaks .................................................................................................................................... 2-2

Propane Gas Leak Detector .............................................................................................................. 2-2

Carbon Monoxide Warning .............................................................................................................. 2-3

Carbon Monoxide Alarm .................................................................................................................. 2-3

Smoke Alarm .................................................................................................................................... 2-4

Fire Extinguisher ............................................................................................................................... 2-4

Electrical ........................................................................................................................................... 2-5

Loading ............................................................................................................................................. 2-5

Maintenance ...................................................................................................................................... 2-5

Emergency Exits ............................................................................................................................... 2-5

Power Sofas and Beds ....................................................................................................................... 2-6

Slideout Rooms ................................................................................................................................. 2-6

Formaldehyde Information ............................................................................................................... 2-7

Mold, Moisture, and Your Motor Home ........................................................................................... 2-7

Roof and Ladders .............................................................................................................................. 2-8

Roadside Emergency ........................................................................................................................ 2-8

Jump Starting .................................................................................................................................... 2-9

Engine Overheat ............................................................................................................................. 2-10

3 - DRIVING YOUR MOTOR HOME

Seats - Driver/Co-Pilot ..................................................................................................................... 3-1

Co-Pilot Footrest ............................................................................................................................... 3-2

Seat Belts .......................................................................................................................................... 3-3

Child Restraints ................................................................................................................................. 3-4

Rev. 1225131217

Part No. 161500-12-020

Table of Contents

Troubleshooting

Summary of Contents for Winnebago Journey 34Y

Page 1: Table Of Contents
Engine Overheat ..........................2-10 3 – DRIVING YOUR MOTOR HOME Seats – Driver/Co-Pilot ........................3-1 Co-Pilot Footrest ..........................3-2 Seat Belts ............................3-3 Child Restraints ..........................3-4 Rev. 1225131217 Part No. 161500-12-020 Copyright 2011 Winnebago Industries, Inc. All rights reserved.
Page 2 Table Of Contents KeyOne™ Lock System ........................3-5 Power Door Locks ..........................3-5 Mirrors – Power Electric ........................3-6 Front Drop-Down Solar/Night Shade (12-Volt) ................3-8 Radio In-Dash/Rearview Monitor System ..................3-9 Infotainment Center/GPS ........................ 3-11 CB Radio Power Wiring ......................... 3-13 Parking Brake ..........................
Page 3 Table Of Contents Power Control System (PCS) ......................4-8 Power Control System (PCS) - Model 34Y ..................4-8 Water Heater - Gas/ Electric ......................4-9 MotorAid Water Heater ........................4-9 Pressure-Temperature Relief Valve ....................4-10 Electronic Thermostat ........................4-11 Air Conditioner Filters ........................4-13 Washer/Dryer - Combination ......................
Page 4 Table Of Contents Exterior Shower/Wash Station ......................7-8 Toilet ..............................7-8 Toilet - Electric Flush ........................7-9 Drainage System (P-Traps) ......................7-10 Waste Water System ........................7-10 WaterLine and Tank Drain Valves ....................7-12 Water Heater Bypass Valve ......................7-13 Winterizing Procedures ........................
Page 5 Table Of Contents Slideout Room Travel Locks - Electric ..................10-1 Slideout Room Retraction (with Power Lift Bed Option) .............. 10-2 Slideout Room Keylock ........................10-2 Slideout Room Operation – Electric ....................10-2 Slideout Room – Extreme Weather Precaution ................10-4 Slideout Room Troubleshooting .....................
Page 6 Table Of Contents Fireplace ............................12-5 Countertop Extension ........................12-6 Bi-Fold Door (Model 36M) ......................12-7 Entry Step – Electric ........................12-7 Tool and Ladder Storage ......................... 12-9 Roof Ladder ............................ 12-9 Storage Compartment Doors ......................12-9 Compartment Lights Switch ......................12-10 Power Awning ..........................
Page 7: Introduction
The instructions included in this manual are intended as a guide, and in no way extend the responsibilities of Winnebago Industries beyond the standard written warranty as presented in this manual. The descriptions, illustrations, and...
Page 8: 2012 New Vehicle Limited Warranty
Winnebago Industries, Inc. Except as noted in the paragraph entitled, “Factory Repair,” to (“Winnebago”) and provides coverage so long as the motor home is obtain warranty repairs, you must, at your own cost, present your used exclusively for recreational purposes in the U.S.A.
Page 9 Winnebago does not own or control, and shall not be warranty disputes for recreational vehicles. This program reviews...
Page 10: Safety Messages Used In This Manual
If you need warranty repairs while traveling, you may take your vehicle to any authorized ® Winnebago Industries dealership and request NOTICE their assistance. See the Service Dealer Directory in your NOTICE is used to address practices not InfoCase.
Page 11: Occupant And Cargo Carrying Capacity Label
SECTION 1 – INTRODUCTION National Highway Traffic Safety Administration (NHTSA) in addition to notifying Winnebago Industries, Inc. If NHTSA receives similar complaints, it may open an investigation, and if it finds that a safety defect exists in a group of vehicles, it may order a recall and remedy campaign.
Page 12: Vehicle Certification Label
These pressure levels must be maintained to assure proper handling, safety, 2. Chassis manufacture date. and fuel economy. 3. Month and year of manufacture at Winnebago ® 9. Rear Axle Wheel Configuration: Single or Industries Dual as it relates to the inflation.
Page 13: Specifications And Capacities
SECTION 1 – INTRODUCTION SPECIFICATIONS AND CAPACITIES ® ® ® ® Freightliner Freightliner Freightliner Freightliner Winnebago Journey Maxum Maxum Maxum 27,910 lb. 32,350 lb. 34,320 lb. 44,320 lb. Chassis Chassis Chassis Chassis Feature Number Length 34' 11.9" 36' 8.4" 40' 8.3"...
Page 14: Owner And Vehicle Information
Motor Home Serial Number __________________________________________________________ Chassis Vehicle Identification No. (VIN) ________________________________________________ Vehicle Mileage at Delivery __________________________________________________________ Selling Dealer Name ________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ ® YOUR WINNEBAGO INDUSTRIES DEALER /SERVICE CENTER Name ____________________________________________________________________________ Address __________________________________________________________________________ __________________________________________________________________________ Contact ____________________________________________Phone ________________________ CHASSIS SERVICE CENTER...
Page 15: Safety And Precautions
SECTION 2 – SAFETY AND PRECAUTIONS • Use care when accelerating or decelerating on GENERAL WARNINGS a slippery surface. Abrupt speed changes can cause skidding and loss of control. • Only seats equipped with seat belts are to be occupied while the vehicle is moving. •...
Page 16: Lp Gas Leaks
SECTION 2 – SAFETY AND PRECAUTIONS • All pilot lights must be extinguished and asphyxiation is greater when the appliance is appliances turned off while refilling the fuel used for long periods of time. Failure to comply tank or LP gas tank. could result in death or serious injury.
Page 17: Carbon Monoxide Warning
SECTION 2 – SAFETY AND PRECAUTIONS The best protection against carbon monoxide entry into the vehicle body is a properly WARNING maintained engine exhaust and ventilation system. It is recommended that the exhaust system and body be inspected by a qualified EXPLOSION HAZARD: DO NOT use an motor home service center: open flame to test for gas leaks.
Page 18: Smoke Alarm
InfoCase for further instructions. that is also listed for RV application. We Replacement recommend obtaining a replacement from your ® Winnebago Industries dealer. When replacing this alarm, we recommend replacing only with the same model, or with one Further Information that is also listed for RV application.
Page 19: Electrical
• Do not remove the radiator cap while engine your coach. We recommend obtaining a and radiator are still hot. Always check replacement only from your Winnebago coolant level visually at the see-through ® Industries dealer or a reliable RV parts supplier.
Page 20: Power Sofas And Beds
SECTION 2 – SAFETY AND PRECAUTIONS POWER SOFAS AND BEDS WARNING Keep people away from operating mechanism and pinch hazard areas during use. Failure to do so could cause injury. Escape Window (Lift latch handles upward to open) SLIDEOUT ROOMS Using Slider Windows As Emergency Exits WARNING...
Page 21: Formaldehyde Information
SECTION 2 – SAFETY AND PRECAUTIONS Mold is a plant and requires its own special FORMALDEHYDE environment to grow. That environment includes INFORMATION organic materials, nutrients, moisture, and proper temperature. Some of the materials used in this recreational vehicle emit formaldehyde. Eye, nose, and throat How Can I Avoid Mold? irritation, headache, nausea, and a variety of To reduce the ability for mold to grow, you...
Page 22: Roof And Ladders
® while in use. Never use the ladder when it is Winnebago Industries raining, snowing, or icy. The rungs can If Winnebago Industries determines that mold become slippery. Do not step onto the rungs if ® ® is present in the Winnebago...
Page 23: Jump Starting
We recommend that you ask for an underlift (wheel lift or frame lift) type towing assembly for safe towing. ® Winnebago Industries does not assume responsibility for damage incurred while towing this vehicle.
Page 24: Engine Overheat
SECTION 2 – SAFETY AND PRECAUTIONS ENGINE OVERHEAT If you see or hear steam escaping from the engine compartment or have any other reason to suspect an extreme engine overheating condition, pull the vehicle over to the roadside as soon as it is safe to do so, stop the engine, and get all passengers out of the vehicle.
Page 25: Driving Your Motor Home
SECTION 3 – DRIVING YOUR MOTOR HOME The information in this section refers only to Front Seats features installed or adapted to the dash and driver compartment area by Winnebago Turn Knob ® Industries . It also includes passenger seating in for Lumbar the living area of the coach.
Page 26: Co-Pilot Footrest
SECTION 3 – DRIVING YOUR MOTOR HOME Armrest Adjustment -If Equipped The armrests may be swung upward out of the way for easy exit or access to the front seats. A roller on the underside of the front of the armrest also lets you adjust the resting angle for personal comfort, whether the seat is upright or reclined.
Page 27: Seat Belts
SECTION 3 – DRIVING YOUR MOTOR HOME To Fasten Be sure belt is not twisted. Grasp each part of the belt assembly and push tongue into buckle. Adjust to a snug fit by pulling the loose end away from the tongue. To Release Press button in center of buckle and slide tongue out of buckle.
Page 28: Child Restraints
SECTION 3 – DRIVING YOUR MOTOR HOME 2. Make sure that it will attach to your vehicle and restrain your child securely and WARNING conveniently so that you are able to install it correctly each time it is used. 3. Be certain that it is appropriate for the child's Never wear the shoulder belt in any height, weight, and development.
Page 29: Keyone Lock System
This feature allows you to our factory database, so if you ever lose your ® unlock or lock your entrance door from outside keys, any Winnebago Industries dealership can the coach by simply pressing the key ring remote. order a new key for you.
Page 30: Mirrors - Power Electric
SECTION 3 – DRIVING YOUR MOTOR HOME NOTE:Keys should always be removed when MIRRORS – POWER ELECTRIC leaving the vehicle. Since doors can be locked without keys, make sure they have Always adjust mirrors for maximum rear been removed from the ignition before visibility before driving.
Page 31 SECTION 3 – DRIVING YOUR MOTOR HOME Move Selector Switch L or R to select mirror. Mirror Head Pivot Lock Center “neutral” position disables arrows to avoid unintentionally moving a mirror Unscrew protective cap and Press Arrow Buttons to move loosen Allen head set screw mirror surface in direction indicated to pivot mirror head...
Page 32: Front Drop-Down Solar/Night Shade (12-Volt)
SECTION 3 – DRIVING YOUR MOTOR HOME Mirror Arm Mounting Base Mirror Arm Pivot Bolt on underside of mounting base - Shown with access plug removed (Torque nut to 75-100 in./lbs.) Unscrew protective caps and loosen Allen head set screws to pivot mirror arm. (Torque screws to 75-100 in./lbs.) FRONT DROP-DOWN SOLAR/ If mirror arm will not pivot with set screws...
Page 33: Radio In-Dash/Rearview Monitor System
• MENU - Press to access USER SETTING Should the Automatic Safety Retraction MENU. Press and Hold to access SYSTEM feature deploy, go to your nearest Winnebago SETUP MENU. ® Industries dealer for service before operating the shade again.
Page 34: Radio Remote Controls
SECTION 3 – DRIVING YOUR MOTOR HOME • USB - Connect a USB Jump Drive. NOT FOR IPOD CONTROLS. Rearview Monitor -Typical View The rearview monitor feature of this system lets you see what is directly behind your coach See the manufacturer’s information in your for safety and maneuvering assistance.
Page 35: Infotainment Center/Gps
SECTION 3 – DRIVING YOUR MOTOR HOME Basic Operating Instructions by house batteries. If the House/Coach Battery Disconnect switch is OFF, the Refer to the manufacturer’s owner manual speakers will not emit sound. and/or quick start guide provided in your InfoCase for a complete explanation of features and operating/set-up instructions.
Page 36 SECTION 3 – DRIVING YOUR MOTOR HOME manually. NOTE:If your Sirius tuner is not activated, follow the instructions in the radio owner’s manual provided in your The GPS navigation system can help you InfoCase for the phone number to call confidently chart your course through the most and procedure to access the Sirius Tuner dense concrete jungle or remote country...
Page 37: Cb Radio Power Wiring
SECTION 3 – DRIVING YOUR MOTOR HOME Radio Power Switch (Located on dash) • Press HOUSE to listen to the radio while parked without the ignition key on. USB Port • Press ENGINE (“ENG”) to listen while driving. (Located on dash) Further Information Radio Remote Controls See the manufacturer’s user guide provided in...
Page 38: Parking Brake
SECTION 3 – DRIVING YOUR MOTOR HOME The increased back pressure would normally PARKING BRAKE stop the engine except the forward momentum of ® the vehicle keeps the drivetrain and the engine Freightliner Chassis turning. This controlled back pressure helps to regulate a vehicle’s downhill speed, such as on mountainous or hilly roads.
Page 39: Tag Axle Suspension System
SECTION 3 – DRIVING YOUR MOTOR HOME Off Position TAG AXLE SUSPENSION • The Tag Dump mode is inactive when the Tag SYSTEM Axle switch is in the OFF position. ® Freightliner Chassis NOTE: If an override event occurs while the (Model 42E only) switch is held in the Tag Dump position, Your coach is equipped (Model 42E only)
Page 40: Signal Lever/Headlight High-Low Beam
SECTION 3 – DRIVING YOUR MOTOR HOME SIGNAL LEVER/HEADLIGHT HIGH-LOW BEAM The signal lever controls the turn signals and headlight high/low beams. Further Information See your chassis manual in your InfoCase for further information on this switch. STEERING COLUMN ADJUSTMENT The tilt/telescope adjustment pedal is located Turn Signals/High-Low Beams on the floor to the left of the steering column as...
Page 41: Battery Boost Switch
SECTION 3 – DRIVING YOUR MOTOR HOME WARNING Do not adjust the steering column or tilt wheel while the vehicle is in motion. Doing so may cause loss of vehicle control resulting in death or personal injury. Blower Temp Mode Control Control Selector...
Page 42: Air Horns
SECTION 3 – DRIVING YOUR MOTOR HOME There are also commercially available AIR HORNS products (typically called anti-gel additives) to add to diesel fuel while filling the tank to inhibit –If Equipped wax formation in freezing temperatures. Press the Air Horn switch (located on the dash or driver side trim panel, depending on model) to Further Information the ON (up) position - then use the horn button on...
Page 43: Engine Block Heater - Diesel Engine
SECTION 3 – DRIVING YOUR MOTOR HOME See also “Idle Speed Control” elsewhere in FRONT SERVICE ACCESS this section. (HOOD) The hood panel can be opened for access to service items such as: • Air Hose Connector • Windshield Washer Fluid Reservoir •...
Page 44: Engine Access Grille - Rear
SECTION 3 – DRIVING YOUR MOTOR HOME ENGINE ACCESS GRILLE – REAR The diesel engine is located behind the grille panel at the rear of the vehicle. Unlock the latches near the ends of the grille panel and swing it upward. With the grille panel open, you can access the following service points: •...
Page 45 SECTION 3 – DRIVING YOUR MOTOR HOME Take precautions to protect carpet and interior • Lift bed board and remove gas struts (one furnishings when removing engine covers. The located on each side of bed board). undersides of the engine covers could contain deposits of oil and fuel or other engine fluids and substances that could damage fabrics and interior furnishings.
Page 46 SECTION 3 – DRIVING YOUR MOTOR HOME (The bed board on your coach may be featured • Remove step cover and set aside. with gas struts. Therefore, propping the bed board is not necessary). NOTE: A falling bed board can injure. Assure the bed is properly supported.
Page 47: Fuel/Water Separator - Diesel Engine
SECTION 3 – DRIVING YOUR MOTOR HOME • Reverse steps to reinstall Engine Access Covers. Engine Top Access Cover (Beneath Lavatory Cabinet) In some cases, you may need further access of the rear engine (beyond removing the Engine Access Covers, as previously described.) A secondary Engine Access Cover is located beneath the lavatory cabinet.
Page 48: Diesel Exhaust Fluid Fill
SECTION 3 – DRIVING YOUR MOTOR HOME separator canister during normal periodic service DIESEL EXHAUST FLUID FILL and maintenance to keep the fuel filtration system working effectively. The Diesel Exhaust Fluid Fill is located in the The fuel/water separator is located at the passenger or driver side compartment behind the forward right side of the engine beneath the rear rear wheel, depending on model.
Page 49: Chassis Battery Disconnect Switch
SECTION 3 – DRIVING YOUR MOTOR HOME NOTE: The Chassis Battery Disconnect switch must be on to start the engine. NOTICE CIRCUIT BREAKERS AND FUSES – CHASSIS/DASH When refilling the coolant system of a vehicle equipped with a rear auxiliary AUTOMOTIVE 12-VOLT automotive heater and motoraid water heater, be sure to allow for additional...
Page 50: Windshield Washers And Wipers
SECTION 3 – DRIVING YOUR MOTOR HOME Automotive Fuses (cover removed) Always replace plug-in type fuses with those of the same amperage size. Windshield Washer Reservoir See the chassis manufacturer’s fuse allocation (Located behind front hood panel) chart on the inside of the fuse block cover. TIRES Improper tire pressure can result in tire overloading and abnormal wear and also affects...
Page 51: Lights
SECTION 3 – DRIVING YOUR MOTOR HOME Alignment can be affected by worn steering/ suspension parts or by incidents which happen during driving, such as hitting a curb, pothole, or railroad track, etc. Improper alignment can cause tires to roll at an angle and wear unevenly. It may also cause the vehicle to “pull”...
Page 53: Appliances And Systems
SECTION 4 – APPLIANCES AND SYSTEMS The appliances installed in your motor home ON position. This will ensure that water are manufactured by reputable RV appliance does not discharge from the water makers and have been tested by independent dispenser when power is reconnected to laboratories to meet all applicable standards and the appliance.
Page 54: Refrigerator
SECTION 4 – APPLIANCES AND SYSTEMS It is recommended to replace the water filter where it creates cooling by evaporation. The when the indicator light changes to red, or earlier ammonia circulates back into the water solution if the flow of water to your water dispenser or ice and the cooling cycle continues.
Page 55: Ice Maker
SECTION 4 – APPLIANCES AND SYSTEMS Basic Operation temperature in the freezer compartment, then adjust warmer as necessary after cold food has • Press the ON/OFF button to start the been added. refrigerator. NOTE: The refrigerator will retain temperature • If the display code reads “No”, there is no more efficiently if food is already cold electricity or gas available to operate the...
Page 56: Refrigerator Service Access Compartment
SECTION 4 – APPLIANCES AND SYSTEMS Refrigerator Access Compartment Residential Refrigerator Access Compartment -Typical View MICROWAVE OVEN/RANGE HOOD -If Equipped REFRIGERATOR SERVICE The range hood vent is built into the ACCESS COMPARTMENT microwave oven. The range hood fan carries (Exterior) cooking odors and gas fumes to the outside of the coach.
Page 57: Range And Oven
SECTION 4 – APPLIANCES AND SYSTEMS Avoiding Asphyxiation RANGE AND OVEN The following warning label has been located –If Equipped in the cooking area to remind you to provide an The range and optional oven in your motor adequate supply of fresh air for combustion. home operate on propane gas and will provide most of the functions of the range in your home.
Page 58: Oneplace® Systems Monitor Panel
SECTION 4 – APPLIANCES AND SYSTEMS ONEPLACE SYSTEMS ® MONITOR PANEL The OnePlace Systems Monitor Panel provides a convenient, central location for checking the condition of all utility systems in your coach. At the touch of a button, the monitor panel will display the fresh water and holding tank levels, propane gas tank level, plus the chassis Tank Levels Switch...
Page 59: Solar Charger Panel
SECTION 4 – APPLIANCES AND SYSTEMS Battery Levels Switch Water Pump Switch To get an accurate reading: Refer to Section 7 - Plumbing for additional information on the water pump and initial start- • Both the chassis engine and the generator engine must be shut off and 120-volt AC shoreline unplugged.
Page 60: Power Control System (Pcs)
SECTION 4 – APPLIANCES AND SYSTEMS Further Information NOTE: The solar battery charger is not intended to make the coach battery system Refer to the manufacturer’s user guide “maintenance free.” The solar panel will provided in your InfoCase for important not completely compensate for information on how this system operates under continuous low amperage draw from...
Page 61: Water Heater - Gas/ Electric
SECTION 4 – APPLIANCES AND SYSTEMS For Electric Operation WATER HEATER - GAS/ Press the Water Heater Electric switch to ON. ELECTRIC The shoreline must be connected or generator running for electric operation. The Gas/Electric Water Heater has a dual power feature.
Page 62: Pressure-Temperature Relief Valve
SECTION 4 – APPLIANCES AND SYSTEMS CAUTION NOTICE Hot water can escape from tank causing Any leak in the heat exchanger or its injury. Operate this valve only when the supply or return lines could cause loss of water heater and engine cooling system coolant and subsequent engine failure.
Page 63: Electronic Thermostat
SECTION 4 – APPLIANCES AND SYSTEMS ELECTRONIC THERMOSTAT LCD Display Screen Setpoint Buttons (Heating and Cooling) The Thermostat (located near the monitor panel) controls the propane furnace, as well as the roof air conditioners in your coach. The living area and galley are equipped with one or two air conditioners (depending on model), and the bedroom and bath area is equipped with one.
Page 64: Heat Pump
SECTION 4 – APPLIANCES AND SYSTEMS 5. Adjust the temperature setpoint to personal extract heat from the outside air on a cold day and preference if needed. See “Changing carry it to the inside of the coach to maintain a Temperature Setpoints.”...
Page 65: Air Conditioner Filters
See Vents produce airflow. The Return Vents are for ® your Winnebago Industries dealer for service air intake, in which the air goes back into the air and proper cleaning of the drain lines.
Page 66: Washer/Dryer - Combination
SECTION 4 – APPLIANCES AND SYSTEMS WASHER/DRYER - COMBINATION -If Equipped Model 34Y only Your coach may be equipped with a Combination Washer/Dryer for the luxury of home as you travel. Before using the Combination Washer/Dryer, please spend a few moments reading the manufacturer’s user guide provided in your InfoCase for complete operating instructions, troubleshooting and maintenance tips, as well as...
Page 67: Washer/Dryer - Stackable
SECTION 4 – APPLIANCES AND SYSTEMS Model 34Y Water Supply Faucets (Located behind an access door within the rear wardrobe) See “Winterizing Optional Appliances” in Water Supply Faucets Plumbing - Section 7 for steps in winterizing your Combination Washer/Dryer. The Washing Machine Water Supply Faucets are accessible beneath the bedroom lavatory Further Information cabinet (Model 36M), behind an access door...
Page 68: Washer/Dryer - Prep Package
Water Supply Faucets -Typical installation shown We recommend obtaining parts and service for the Washer/Dryer installation from your ® ® Winnebago or Itasca dealer. Water Supply Faucets (Located beneath rear bath lavatory cabinet) * Remove top lavatory cabinet drawer to access See “Winterizing Optional Appliances”...
Page 69: Propane Gas
SECTION 5 – PROPANE GAS PROPANE GAS SUPPLY The propane gas system supplies fuel for the gas range/oven, water heater, furnace, and refrigerator (while in gas mode). When used and handled properly, this system is safe and economical and provides modern living conveniences wherever you travel.
Page 70 SECTION 5 – PROPANE GAS phone directory yellow pages for locations of local propane gas refilling stations or bulk DAN GE R dealerships. NOTE: If you travel outside the U.S. with your DO NOT FILL CONTAINER TO MORE motor home, you may find butane or THAN 80 PERCENT OF CAPACITY.
Page 71: Propane Accessory Connection
SECTION 5 – PROPANE GAS Main Tank Valve Switch (Model 34Y) PROPANE ACCESSORY The main tank valve is located out of normal CONNECTION reach, so a switch is provided on the front of the tank compartment and on the monitor panel when Your coach is featured with a Propane you need to open or close gas flow from the Accessory Connection for your convenience, to...
Page 72: Safe Use Of The Propane Gas System
SECTION 5 – PROPANE GAS • Have the entire propane gas system inspected for possible leaks and missing or damaged parts at each tank filling. Also inspect before CAUTION and after each trip, and any time trouble is suspected. • Turn valve off when not in use.
Page 73: Propane Gas Pressure Regulator
SECTION 5 – PROPANE GAS • Regulators are equipped with a protective cover. Make sure that the regulator vent faces downward and that the cover is kept in place to minimize vent blockage, which could result in excessive gas pressure causing fire or explosion.
Page 74: Propane Vaporization In Cold Weather
SECTION 5 – PROPANE GAS tank control valve closed when not in use, even when tank is empty, to prevent moisture from collecting on the inside. If regulator freeze-up should occur, you may attempt to thaw the regulator using a light bulb. DO NOT USE AN OPEN FLAME OR HEAT LAMP.
Page 75: Electrical
SECTION 6 – ELECTRICAL Your coach is equipped with an electrical the power converter automatically changes a system consisting of two separate voltages: portion of the 120-volt current to 12-volt DC current. All equipment in the motor home that is •...
Page 76: Connecting The Power Cord
SECTION 6 – ELECTRICAL be used is designed to mate with the prongs of the power cord plug, the electrical connection can be expected to carry rated load. Connecting The Power Cord To connect to an external source, remove the cord from the utility compartment and plug it into a suitable 50-amp power receptacle to provide external power to the coach and converter/...
Page 77: Inverter/Charger Unit - 2800W (Pure Sine Wave)
SECTION 6 – ELECTRICAL INVERTER/CHARGER UNIT – 2800W (PURE SINE WAVE) NOTICE –If Equipped (For models equipped with Residential- Do not store items too closely around the Style Refrigerator) inverter unit in the storage compartment. The inverter generates heat while The 2800-watt inverter/charger has an AC operating and needs unrestricted airflow input circuit breaker to protect the inverter/...
Page 78: Inverter/Charger Unit - 2000W
SECTION 6 – ELECTRICAL maintenance, especially in cold weather. INVERTER/CHARGER UNIT – See “Battery Care” at the end of this 2000W section for additional information. –If Equipped Inverter/Charger Control Panel The 2000-watt inverter/charger has an AC The inverter/charger has a wall-mounted input circuit breaker to protect the inverter/ control panel that can be programmed for several charger from overloads.
Page 79: Charging Section
SECTION 6 – ELECTRICAL Inverter/Charger Control Panel The inverter/charger has a wall-mounted NOTICE control panel that can be programmed for several charging options. It will also display warnings for Do not store items too closely around the overload conditions or other operating failure inverter unit in the storage compartment.
Page 80: Inverter/Charger Unit - 1000W
SECTION 6 – ELECTRICAL Inverter Control Panel INVERTER/CHARGER UNIT - The inverter has a wall-mounted monitor/ 1000W control panel. It will also display warnings for (Model 34Y only) overload conditions or other operating failure –If Equipped conditions. The inverter unit is located on the wall of the utility compartment.
Page 81: Electrical Outlets - House 120-Volt Ac
SECTION 6 – ELECTRICAL • Push to Reset circuit after monthly testing or ground fault tripping. • Push to Test at least monthly. House Circuit Breakers Should break -Typical Installation circuit. Press Reset button to NOTE: Breakers are labeled on panel. reconnect.
Page 82: Automatic Power Transfer Switch
SECTION 6 – ELECTRICAL WARNING Do not plug the power cord into the generator receptacle while the generator is running. Electrical shock can cause personal injury. Automatic Power Transfer Switch AGS Control Pad (Located near monitor panel) –If Equipped Whenever the Generator is started, an Generator Operation automatic power transfer system automatically (if equipped with AGS)
Page 83: Generator Hourmeter
SECTION 6 – ELECTRICAL Generator Hourmeter The Generator hourmeter registers the total number of hours that the Generator has been operated. Press the GenSet Meter button once to get reading. Refer to the hourmeter to determine when periodic maintenance is due and to record services which have been performed.
Page 84: Electrical System - House 12-Volt Dc
SECTION 6 – ELECTRICAL • Park the vehicle so that the wind will carry the The house batteries supply power to 12-volt exhaust away from the vehicle. Also, note the equipment located in the living area of the motor position of other vehicles to be sure their home.
Page 85: House/Coach Battery Disconnect Switch
SECTION 6 – ELECTRICAL to start the engine if the automotive battery is discharged. (See “House/Coach Battery Disconnect switch” or “Battery Boost switch” in Section 3 - Driving Your Motor Home). The house batteries are automatically charged by the chassis alternator while the engine is running.
Page 86: Battery Care
SECTION 6 – ELECTRICAL Model 34Y The Chassis and House Batteries are located in the battery compartment toward the rear driver side of the coach. Removable Floor Panel (Access through mid-coach driver and passenger side compartment doors) • Unlatch the twist-locks and remove floor panel to access batteries.
Page 87 SECTION 6 – ELECTRICAL The two best defenses against sulfating • Make sure battery cable clamps are tight on and insufficient charge are to: the terminal posts and are free of corrosion. • Neutralize corrosion buildup or acid film on 1.
Page 88: Circuit Breakers - House 12-Volt
Chassis Batteries If your coach is going to be unoccupied for ® two weeks or more, Winnebago Industries recommends disconnecting the chassis batteries in your coach to avoid battery discharge. Turn the Chassis Battery Disconnect switch (located near the entrance door) to the OFF position to disconnect batteries.
Page 89: Plumbing
SECTION 7 – PLUMBING FRESH WATER SYSTEM The Fresh Water System provides water to the galley sink, shower, bathroom lavatory, toilet, and water heater. Water may be supplied by either of two sources: • A fresh water tank and water pump located within the motor home, or •...
Page 90: Utility Light
SECTION 7 – PLUMBING 5. Turn OFF city water supply and disconnect tank vent tube onto the ground and the from City Water Connection. water pump will run without delivering water to faucets. 6. Turn Fresh Water valve to Normal position to use the water pump.
Page 91 SECTION 7 – PLUMBING faucet is open. When you close the faucet, the • Remove the bowl and pull the strainer screen line pressure backs up to the pump, and it shuts out of the bowl to tap out any particles and itself off.
Page 92: Filtered Water Faucet
SECTION 7 – PLUMBING Models 36M, 40U, and 42E Filtered Water Faucet Water Pump -Typical View (Located in driver side front compartment) - Models 36M, 40U, and 42E Model 34Y Water Filter Assembly (Located below galley sink) -Typical View Replacing the Water Filter Water Pump Cartridge (Located in water service center)
Page 93: Ice Maker Water Filter
SECTION 7 – PLUMBING • Purge a new filter cartridge before using for drinking. Run a few gallons of water through the filter and discard the water (or use for Ice Maker Filter Assembly watering plants) to avoid ingesting carbon (Located below galley sink) dust or particles that may have been present in -Typical Installation...
Page 94: Full-Coach Water Filtration System
SECTION 7 – PLUMBING FULL-COACH WATER FILTRATION SYSTEM –If Equipped The full-coach water filtration system is connected to the cold water lines throughout the coach. It uses a flow-through filter that removes chlorine, cloudiness, and sediments, resulting in clear, odorless and taste-free clean water for drinking, cooking, and personal care.
Page 95: Disinfecting Your Fresh Water System
SECTION 7 – PLUMBING • Turn the Fresh Water Valve to Normal This solution will result in a residual chlorine position. Next open a faucet inside the coach concentration of approximately 50 ppm in the or the exterior shower, then turn city water on water system.
Page 96: Shower Hose Vacuum Breaker
SECTION 7 – PLUMBING 2. Remove the full-coach filter cartridge from SHOWER HOSE VACUUM the filter canister to avoid prematurely BREAKER “plugging up” the filter cartridge. Refit empty canister to filter head for procedure. After using the shower, you may notice water 3.
Page 97: Toilet - Electric Flush
SECTION 7 – PLUMBING Normal Flush Water Saver Flush Important “Don’ts” • Don't use facial tissue or regular toilet tissue in the RV toilet. These will not disintegrate LED Symbol sufficiently and will often cling to the sides of Wall Switch/Controller the holding tank.
Page 98: Drainage System (P-Traps)
SECTION 7 – PLUMBING Further Information 1. Remove the dust cap from the sewage drain outlet and connect the sewage drain hose. Be See the toilet manufacturer’s operation sure it is firmly attached. information provided in your InfoCase for complete operating, care, and maintenance NOTE: The sewage drain outlet swivels information.
Page 99 SECTION 7 – PLUMBING fully. this procedure. (If hose is not available, run Do not open holding tank waste valves several gallons of water into the sewage tank until the sewage drain hose end valve is through the toilet. Then open the Black Waste open.
Page 100: Waterline And Tank Drain Valves
SECTION 7 – PLUMBING 3. Attach a garden hose from a city water If the valve is left open, the liquids will drain hydrant to the Black Waste Tank Flush Inlet off, leaving solids in the tank. Should this fitting in the water service center. (This inlet is accidentally happen, disconnect the sewage drain clearly marked separate from the City Water hose, fill the tank about half full with water, and...
Page 101: Water Heater Bypass Valve
SECTION 7 – PLUMBING Model 34Y Drain Plug Water Heater Service Access Water Tank Drain Valve -Typical View (Located in water service center - pull to drain) WATER HEATER BYPASS VALVE Your coach may be equipped with a water heater bypass valve for easier winterization of waterlines using RV antifreeze.
Page 102: Winterizing Procedures
SECTION 7 – PLUMBING (If your coach is not equipped with a filtered WINTERIZING PROCEDURES water faucet or ice maker, proceed to the next numbered step). You can winterize the water and plumbing system of your coach using one of the following two methods –...
Page 103 A blow-out plug can be purchased refrigerator ice maker, dishwasher, or washer/ ® ® at any Winnebago or Itasca dealer. dryer, the waterlines for these appliances must also be drained. (See “Winterizing Optional Appliances”...
Page 104 SECTION 7 – PLUMBING 17. Pour about one cup of RV antifreeze down plumbing system. each drain for the galley sink, lavatory sink, This product is available from your and shower/tub. This fills the drain trap pipes dealer and from most RV supply stores to prevent holding tank odors from entering and national retail outlets.
Page 105 SECTION 7 – PLUMBING Winterization Valve 1 (See “Water System Drain Valve Locations” chart Filtered Water Faucet/Ice Maker at the end of this section for location on your coach) Filter Assembly 4. Turn Winterization Valve 2 to the “Winterize” (Located below galley sink) position.
Page 106 SECTION 7 – PLUMBING Drain Water Heater 12. Turn off the Water Heater power switch before draining the water heater tank to avoid damage to the heating element. • Drain the water heater by removing the plug from the base of the water heater tank, accessible from the outside of the coach.
Page 107: Winterizing Optional Appliances
SECTION 7 – PLUMBING instructions at the end of this section.) If not equipped with optional appliances, proceed to the next numbered step. Fill Drainage System P-Traps 14. Pour about one cup of RV antifreeze down each drain for the galley sink, lavatory sink, and shower/tub.
Page 108 SECTION 7 – PLUMBING 5. Ensure the ice bin is in place and the wire shut- off arm is lowered to the ON position. 6. Allow the refrigerator to cool down to ice making temperature. Remember, this can take up to 24 hours. NOTE: Discard the first two batches of ice cubes.
Page 109 SECTION 7 – PLUMBING Winterizing Washer/Dryer 6. Allow machine to run through the complete cycle to clean out any remaining antifreeze. (Combination - Model 34Y) Finished. –If Equipped Method 2 – Fill with RV Antifreeze Method 1 – Drain Water If you have decided to fill the coach waterlines If you have decided to completely drain the with RV antifreeze, follow these steps to...
Page 110: Water System Drain Valve Locations
SECTION 7 – PLUMBING 1. With machine power OFF, turn Wash Temp NOTE: Check water inlet hoses and pump knob to HOT. periodically (see manufacturer’s user guide for further information). 2. Advance Cycle Selector to “Position 3”. 2. Plug Washer/Dryer into electrical outlet or 3.
Page 111: Entertainment
SECTION 8 – ENTERTAINMENT To Watch Satellite TV (Dish) or HIGH DEFINITION VIDEO Auxiliary AV Component SELECTION SYSTEM -If Equipped • Connect satellite receiver to the accessory connection cable (satellite receiver.) This cable is located near the entertainment center cabinet. High Definition Video Selection Box (Located near entertainment center cabinet) -Typical View...
Page 112: Hdmi Video Selection System (Model 42E)
SECTION 8 – ENTERTAINMENT NOTE: There may be a slight delay when changing sources. Winnebago ® Industries recommends setting each component to a maximum video output resolution of 1080i for proper operation. TV Signal Amplifier Power Switch (Located near entertainment center cabinet)
Page 113 SECTION 8 – ENTERTAINMENT Accessory Connection Cables * Satellite Receiver 1 and Satellite Receiver 2 To Watch Broadcast TV (Antenna) (Located in front driver overhead cabinet) • Power “ON” the TV Signal Amplifier Power NOTE: Auxiliary AV Component Cable not provided. switch (located in overhead cabinet above entry door.) A green LED light will illuminate •...
Page 114: Front Tv Ignition Switch Interlock
SECTION 8 – ENTERTAINMENT To Watch Cable TV FRONT TV IGNITION SWITCH • Power “OFF” the TV Signal Amplifier Power INTERLOCK switch (located in overhead cabinet above –If Equipped entry door) and press the SOURCE or FUNCTION/TV SOURCE button on the TV If your coach is equipped with a front remote and select “TV”...
Page 115: Dvd Home Theater System (Model 42E)
SECTION 8 – ENTERTAINMENT The TV is connected to the Home Theater • Place remote into DVD System, which plays through theater speakers in Receiver mode - Press the lounge area of the coach. DVD Receiver/TV button twice, until button Set TV Video Input illuminates to amber color.
Page 116 SECTION 8 – ENTERTAINMENT TV Sound through Home Theater • Determine which TV you want to use (e.g. BEDROOM for bedroom TV) and select Speakers “Home Theater” from the HDMI Video (Lounge TV Only) Selection System (or the HDMI Video When watching TV programs (broadcast, Selector Control or Secondary Source cable, or satellite), the TV normally plays sound...
Page 117: Cd/Dvd Player - Bedroom
SECTION 8 – ENTERTAINMENT • The DVD may load directly to the main title/ menu screen or it may begin to play previews. You may be able to skip previews if desired by pressing the NEXT button until you see the main menu screen.
Page 118: Tv (Dining Buffet) - Power Lift
SECTION 8 – ENTERTAINMENT Cable The exterior entertainment center TV is connected to the exterior DVD player, video (Park cable input located in power cord selection box, the rooftop antenna, and the park compartment) cable input. • Turn OFF the TV Signal Amplifier switch. •...
Page 119: Tv - Bedroom (Swing-Out)
SECTION 8 – ENTERTAINMENT TV – BEDROOM (SWING-OUT) –If Equipped (Typical View - your coach may vary according to floorplan) Your coach may be equipped with a bedroom TV swivel/telescoping mechanism, which allows you to angle the TV to best suit your viewing needs.
Page 120: Tv Signal Amplifier
SECTION 8 – ENTERTAINMENT The digital antenna is equipped with a built-in NOTE: LED lights will illuminate from left to amplifier for maximum VHF and UHF right. All LED lights may not illuminate, programming. depending on signal strength. 5. Rotate Attenuator Dial COUNTER- CLOCKWISE until the last illuminated LED WARNING light flickers.
Page 121: Cable Tv And Satellite Connections
A second connection may be included inside a cabinet in the bedroom for the rear TV (if equipped). ® HDMI Cable See your authorized Winnebago Industries dealer for proper installation and sealing of roof High Definition Accessory mounted components. Connection Cables...
Page 122: Tv Digital Satellite System (Automatic/In-Motion)
SECTION 8 – ENTERTAINMENT TV DIGITAL SATELLITE SYSTEM (AUTOMATIC/IN- MOTION) –If Equipped The Automatic/In-Motion Digital Satellite System allows you to receive TV programs directly from satellite to your coach. We recommend that you read the manufacturer’s user guide provided in your InfoCase thoroughly to understand the system 1.
Page 123: Dish Network Satellite Receiver
SECTION 8 – ENTERTAINMENT 4. You are now ready to watch Dish Network satellite through your TV. Further Information See the Automatic Satellite System owner’s manual in your InfoCase for complete description of features and instructions. DISH NETWORK SATELLITE ® RECEIVER –If Equipped Automatic/In-Motion Satellite Dish Control...
Page 124: Exterior Entertainment Center
SECTION 8 – ENTERTAINMENT EXTERIOR ENTERTAINMENT CENTER –If Equipped The Exterior Entertainment Center contains an HDTV, Stereo Radio/CD/DVD Player (if equipped), and Audio/Video Connections for your outdoor listening or viewing pleasure. NOTE: Model 42E is not featured with an exterior Stereo Radio/CD/DVD Player. Refer to “HDMI Video Selection System (Model 42E)”...
Page 125: Furniture And Softgoods
SECTION 9 – FURNITURE AND SOFTGOODS LOUNGE CHAIR - SWIVEL –If Equipped (Typical View - Your coach may differ in appearance, depending on model) This chair is not equipped with a seat belt and is not intended for seating while the vehicle is in motion.
Page 126 SECTION 9 – FURNITURE AND SOFTGOODS Storing Buffet Chairs 1. Push chairs against opposite sides of the buffet table. Buffet Table Extension 2. Bind chairs together with the provided strap, 1. Grasp the edge of the buffet table and pull all ensuring the strap goes through the ring the way out.
Page 127: Sleeping Facilities
SECTION 9 – FURNITURE AND SOFTGOODS NOTE: The buffet table extension is typically 5. Reverse steps to store buffet table extension. located inside a galley storage cabinet. See following photo. SLEEPING FACILITIES WARNING Sleeping facilities are not intended for use while vehicle is in motion. For safety, passengers must use safety belted seating positions while vehicle is in motion.
Page 128 SECTION 9 – FURNITURE AND SOFTGOODS 6. Reverse steps to convert back into dinette seating. 3. Rotate lock rod counter-clockwise (right) to Extendable Dinette secure table in the lowered position. -If Equipped To Extend Dinette Table 1. Grasp the edges of the dinette table and pull all the way out.
Page 129: Extendable Sectional Dinette
SECTION 9 – FURNITURE AND SOFTGOODS 3. Align table extension pegs with table insert 5. Reverse steps to store dinette table extension. holes and push edge of dinette table in to NOTE: Be sure to store dinette back into adjoin with the table extension. standard position before converting dinette into additional bed space.
Page 130 SECTION 9 – FURNITURE AND SOFTGOODS 4. Push front of seat cushion rearward to secure into seated position, ensuring the bracket on the underside of the seat cushion engages with the metal catch on the front side of the dinette sectional extension.
Page 131 SECTION 9 – FURNITURE AND SOFTGOODS 5. Install seat back cushion, ensuring the back 10. Insert table extension to adjoin with dinette slip cover slides over top of the seat back to table. secure. NOTE: Table extension is stored beneath rear NOTE: Seat back cushions are stored in rear bed.
Page 132 SECTION 9 – FURNITURE AND SOFTGOODS • Retighten knobs beneath dinette table to secure. • Insert table extension to adjoin with dinette • Lift end of table up and loosen knobs beneath table. dinette table (one located on each side of table).
Page 133: Sofa/Bed Conversion
SECTION 9 – FURNITURE AND SOFTGOODS Bed to Sofa SOFA/BED CONVERSION • Push the front edge of the sofa seat toward the -If Equipped wall while lifting upward on the backrest until the sofa is fully seated against the wall and Sofa to Bed security latch “clicks”...
Page 134 SECTION 9 – FURNITURE AND SOFTGOODS 4. Unfold the bottom section of the sofa air bed and extend all the way down to the floor. 5. Unfold the air mattress so it is covering the sofa bed. 3. Rotate the lever lock (located on the bottom right-hand side of the sofa air bed) “clockwise”...
Page 135 SECTION 9 – FURNITURE AND SOFTGOODS Bed to Sofa Air Mattress Hand Control (Located on the back side of the sofa) 1. Press and Hold the DEFLATE button on the hand control OR open the Deflation Valve (for quick deflation) until air mattress is completely deflated.
Page 136 SECTION 9 – FURNITURE AND SOFTGOODS NOTE: Leaving the Deflation Valve open while converting back into sofa position will help remove any remaining air for more compact storage. 5. Grasp the pull strap and proceed to bring sofa all the way up. Once the sofa is back in original position, replace the sofa back 3.
Page 137: Rest Easy Multi-Position Lounge
SECTION 9 – FURNITURE AND SOFTGOODS REST EASY MULTI-POSITION ® LOUNGE • Press to • Press to return upright recline –If Equipped (Typical view - your coach may vary in appearance) Rest Power Easy Switch • Press the switch toward the inboard side of the lounge to recline.
Page 138: Extendable Sectional Sofa
SECTION 9 – FURNITURE AND SOFTGOODS The footrest will lock when in the fully extended position. You must squeeze the release latch to retract the footrest. NOTICE Tip for “Power Users” Do not recline the lounge completely flat unless the footrest trundle section is •...
Page 139 SECTION 9 – FURNITURE AND SOFTGOODS WARNING Stow sectional sofa extension before retracting slide rooms. Failure to observe can cause injury and will cause equipment damage. Extending Sectional Sofa 1. Release and Hold the black lever (located on the arm of the sectional) to release the 4.
Page 140: Digital Sleep Air Bed
SECTION 9 – FURNITURE AND SOFTGOODS NOTE: If your bed is equipped with the power lift feature, it is recommended to deflate the air mattress to 25 or below when elevating the bed into the fully upright position. This will help prolong the life of your air mattress.
Page 141: Roller Shades (Manual) - Solar Day/Night
Bed must be in the fully upright (vertical) ® position to fully retract slideroom. wood. At Winnebago Industries , our craftsmen work with the art found in each piece of wood to create cabinets of superior quality, backed by the ROLLER SHADES (MANUAL) - Winnebago Industries warranty.
Page 142 No matter which species you choose for your new Winnebago Industries motorhome cabinetry, please keep in mind that no two pieces of wood are exactly the same.
Page 143: Slideout Rooms And Leveling
SECTION 10 – SLIDEOUT ROOMS AND LEVELING To Release SLIDEOUT ROOM TRAVEL • Press and hold the UNLOCK side of the LOCKS - ELECTRIC Slideout Room Travel Lock switch for –If Equipped approximately 7 seconds. (You may be able to hear the lock motor sound stop).
Page 144: Slideout Room Retraction (With Power Lift Bed Option)
SECTION 10 – SLIDEOUT ROOMS AND LEVELING Further Information For further power bed operating instructions, refer to Section 9 - Furniture and Softgoods in this manual. SLIDEOUT ROOM KEYLOCK –If Equipped A master Slideout Room Keylock is located near the power switch for the front slideout room. This keylock must be turned ON to provide power to the slideout control switches.
Page 145 SECTION 10 – SLIDEOUT ROOMS AND LEVELING To Extend Slideout Room Rear slideout switches (if equipped) are located on a wall near the slideout room or the Before Extending! Systems Monitor Panel. Location varies by • Level the coach and set the Parking Brake. model and floorplan.
Page 146: Slideout Room - Extreme Weather Precaution
SECTION 10 – SLIDEOUT ROOMS AND LEVELING To Retract Slideout Room the slideout roof. Retract the slideout slowly, starting and stopping to allow water to drain off Before Retracting! room cover. • Be sure the coach is level and the Parking Brake is set.
Page 147: Slideout Room Troubleshooting
SECTION 10 – SLIDEOUT ROOMS AND LEVELING Problems Retracting the Room • Set the Park Brake if the Engage Park Brake light flashes while pressing the Retract (IN) button. • Light will flash fault • Light will flash if code if system park brake not set malfunctions Slideout Cover-Awning...
Page 148 SECTION 10 – SLIDEOUT ROOMS AND LEVELING Problems Extending the Room retraction method or the fully manual method. Both methods listed below are intended as a • Set the Park Brake if the Engage Park Brake means to retract the room to prepare the coach for light flashes while pressing the Extend (OUT) travel to the nearest authorized service center.
Page 149: Slideout Room Troubleshooting - Bedroom (Model 36M)
SECTION 10 – SLIDEOUT ROOMS AND LEVELING Further Information • Motor • Mode • Status See the slideout room operating guide Direction Button LED’s included in your InfoCase for further instructions and troubleshooting information. SLIDEOUT ROOM TROUBLESHOOTING - BEDROOM (MODEL 36M) Battery Voltage or Circuit Breaker Problems If the slideout room will not work:...
Page 150: Slideout Emergency Retraction
SECTION 10 – SLIDEOUT ROOMS AND LEVELING Crank-In Procedure • (9) - HALL POWER SHORT TO GROUND. Power to encoder has been • Disengage the motor brakes, which appear as shorted to ground. This is usually a wiring a flat “square” protrusion on the protective problem.
Page 151: Slideout Emergency Retraction - Bedroom
SECTION 10 – SLIDEOUT ROOMS AND LEVELING • Fasten slideout room travel latching device (if 1) Lift tab inside equipped) inside the coach before driving the protrusion on boot to vehicle. disengage motor brake • See your dealer for service of the slideout mechanism before using again.
Page 152: Slideout Emergency Retraction
SECTION 10 – SLIDEOUT ROOMS AND LEVELING SLIDEOUT EMERGENCY RETRACTION If the slideout mechanism is malfunctioning and the room will not retract using the interior control switch or exterior control panel, you may need to access the slideout motors and manually push the room in to the travel position.
Page 153: General Slideout Care
SECTION 10 – SLIDEOUT ROOMS AND LEVELING In addition, certain caulks and sealers may include chemicals that may adversely effect the performance of the seals. See your authorized dealer for caulks and sealers recommended for your coach. LEVELING SYSTEM The Hydraulic Leveling System makes selecting a parking site easier and faster by reducing the effect of uneven ground.
Page 154 SECTION 10 – SLIDEOUT ROOMS AND LEVELING The Auto Level Remote switch is located in the utility compartment. WARNING Auto Level Remote Switch • Keep all people clear of the coach (Located in utility compartment) -Typical View while the leveling system is operating. •...
Page 155: Checking Hydraulic Oil Level
SECTION 10 – SLIDEOUT ROOMS AND LEVELING CHECKING HYDRAULIC OIL LEVEL NOTICE See the Leveling System Operation Guide provided in your InfoCase for complete • Do not try to drive vehicle unless maintenance instructions and information. “TRAVEL” light is glowing with ignition All maintenance should be done as part of the switch on.
Page 156 SECTION 10 – SLIDEOUT ROOMS AND LEVELING NOTE: Overfilling the hydraulic reservoir can cause leakage of oil through the breather cap. Hydraulic Fluid Recommendation ® ® Dexron II or Mercon automatic transmission fluid is recommended for use in your Leveling System. DO NOT USE brake fluid or hydraulic jack oil, which can damage the seals and cause leaks.
Page 157: Maintenance And Storage
• Have the sealant replaced if you notice any of attention. Delaying these repairs may allow water the above. Your local Winnebago Industries leakage and result in damage to interior ceiling dealer has the correct and necessary parts and and body panels, upholstery, etc., which is not experience to help you maintain your sealants.
Page 158: Exterior Automotive Paint Finish
SECTION 11 – MAINTENANCE AND STORAGE weight to the vehicle. This, in effect, reduces the initial 60-day cure stage, a coat of wax or amount of cargo you can carry and remain within polish can help protect the surface from these GVWR and GAWR limits.
Page 159 SECTION 11 – MAINTENANCE AND STORAGE Bug Removal to clean heavy road films on semi trailers and are often dirty. They are not • Rinse the loose debris off with water and designed for custom painted RV’s and allow the remaining residues to soak and they will scratch the clearcoat finish.
Page 160: Exterior Graphic Care
SECTION 11 – MAINTENANCE AND STORAGE caused by routine cornering and turning, and by • Do not apply wax over the graphics, uneven road surfaces, such as bumps, potholes, especially wax containing petroleum railroad tracks and parking lot entrances. distillates. Wax that has dried along the edge of a graphic can be removed with cotton Inspect the exterior fiberglass shell swabs after softening it with isopropyl...
Page 161: Headlights And Exterior Lights
LIGHTS NOTICE Exterior Light Lenses Do not use citrus-based cleaners on ® Most Winnebago Industries vehicles have polycarbonate finishes. Citric compounds polycarbonate lenses on exterior lamps, which will damage the high-gloss surface, are very sensitive to a variety of chemical causing it to appear dull or “flat”.
Page 162: Interior Soft Goods
SECTION 11 – MAINTENANCE AND STORAGE resistance to soils and stains of vinyl fabrics. It is INTERIOR SOFT GOODS also tougher than real calfskin and has superior resistance to punctures, snags, and rips. We recommend a weekly routine of vacuuming all fabrics and carpet throughout the For most soils and stains, the fabric motor home to prevent an accumulation of dirt, manufacturer recommends spot treatment with a...
Page 163: Cabinetry - Cleaning
SECTION 11 – MAINTENANCE AND STORAGE Draperies, Curtains, and If a stain has dried on, allow the cleaner or soapy water time to soften the area, after which Bedspreads the stain will wipe off. These items may be woven from a variety of If the stain is not water-base or oil-base fabrics.
Page 164: Stainless Steel Appliances
SECTION 11 – MAINTENANCE AND STORAGE Coffee and Tea Stains replacement. If one of these materials does spill or drip onto the counter surface, wipe it up Prepare a sodium bicarbonate solution and hot immediately to avoid damage. water. Apply generously to stain and let sit for 15 minutes.
Page 165: Range And Refrigerator
SECTION 11 – MAINTENANCE AND STORAGE • Never use steel wool. Particles of steel from • Allow solution to dwell 1 to 2 minutes. the wool pad can embed into the sink surface, • Agitate with a natural-bristle brush or white then become rusty and unsightly.
Page 166: Doors And Windows
SECTION 11 – MAINTENANCE AND STORAGE General Cleaning. Rinse all food, beverage, or VEHICLE STORAGE – cosmetic residue from the sink as soon as PREPARATION possible. Some residues, if left to sit in the sink, may require the use of detergent or a mild liquid Properly preparing your vehicle for storage or gel abrasive cleaner.
Page 167: Vehicle Storage - Removal
SECTION 11 – MAINTENANCE AND STORAGE such as clocks, radio memory, and the 8. Sanitize the water system as outlined under engine computer. “Disinfecting Your Fresh Water System” in Section 7 - Plumbing, then open all drain 7. Have the vehicle chassis completely serviced valves and flush the waterlines thoroughly and lubricated.
Page 168: Chassis Service And Maintenance
SECTION 11 – MAINTENANCE AND STORAGE page in the Supplement Manual provided in your InfoCase. Also inspect weather seals around doors, etc., and if necessary, have a dealer replace immediately. Ice Maker Start-Up –If Equipped 1. Close all drain valves. 2.
Page 169: Chassis Diagnostic Connectors
SECTION 11 – MAINTENANCE AND STORAGE Diagnostic plug on rear engine compartment shroud -Typical View Towing Package Fuses (Located in driver side rear compartment) -Typical View • See chassis manufacturer’s information on inside of cover. CHASSIS DIAGNOSTIC CONNECTORS The chassis diagnostic connectors are located in on the steering column support plate beneath the dash and in the rear engine compartment as shown in the following photos.
Page 170: Coach Maintenance Chart
SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Propane Gas System ...
Page 171 SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Safety Equipment Check operation of the following items: ...
Page 172: Miscellaneous
SECTION 11 – MAINTENANCE AND STORAGE COACH MAINTENANCE CHART These recommendations apply for normal recreational use. Heavy duty or full-time use may require more frequent maintenance intervals. Always use specified sections or manufacturer’s guide for further information and instructions. Sealants ...
Page 173: Loading The Vehicle
SECTION 12 – MISCELLANEOUS NOTE: We recommend that you dump all LOADING THE VEHICLE holding tanks before traveling to avoid carrying unnecessary weight. NOTE: Your motor home’s load capacity is designated by weight, not by volume, so you cannot necessarily use all available space when loading your motor home.
Page 174 SECTION 12 – MISCELLANEOUS Corner Weighing (Side-to-Side) You will first drive only your front wheels onto the scale pad, then drive ahead so that the The most accurate method of weighing a whole vehicle is on the scale, then finally pull off motor home is to weigh each “corner”...
Page 175: Car Or Trailer Towing
SECTION 12 – MISCELLANEOUS axle is 12,000 lbs., then the load on each rear dual When towing a trailer or vehicle, do not set (left rear duals or right rear duals) should not exceed either the GVWR, the rear axle GAWR, exceed 6,000 lbs.
Page 176: Trailer Wiring Connector
SECTION 12 – MISCELLANEOUS Finally, do not forget to consider the actual tongue weight. This should not exceed the stated hitch vertical load for your vehicle. This weight NOTICE is typically defined as the tongue weight of a towed vehicle hitch, boat trailer tongue weight, Exceeding any of the recommended or a receiver-mounted carrier rack.
Page 177: Fireplace
GVWR above. For purposes of label limiting vertical tongue load to 350 this definition, the “trailer” can be a trailer, a lbs. All Winnebago Industries models vehicle towed on a dolly, or a vehicle towed by equipped with a Class IV hitch have a means of a tow bar.
Page 178: Countertop Extension
SECTION 12 – MISCELLANEOUS Indicator Panel • For temperature control, rotate Temperature Adjust dial to preferred setting. • LOW/HIGH INDICATORS • For dimming, rotate the Dimmer dial to preferred setting. Remote Operation • FIRE INDICATOR • ON-I/II • TIMER INDICATORS •...
Page 179: Bi-Fold Door (Model 36M)
SECTION 12 – MISCELLANEOUS Door Pull -Typical View • To retract galley countertop extension, pull release lever outward while pushing countertop extension back into stored position. NOTE: Ensure the countertop extension is in the stored position before retracting the slideout room to prevent possible property damage.
Page 180 SECTION 12 – MISCELLANEOUS The power switch for the electric entry step is located to the left of the main entry door as you enter the coach. Red Activation Lever • The red Activation Lever located on the entry step switch must be depressed in order to put the step switch in the ON position.
Page 181: Tool And Ladder Storage
SECTION 12 – MISCELLANEOUS Further Information • Never ignore warning labels or weight limits defined on your ladder. The following For additional information on the step, see the warning label is located on or near the ladder: manufacturer’s operators manual included in your InfoCase.
Page 182: Compartment Lights Switch
SECTION 12 – MISCELLANEOUS COMPARTMENT LIGHTS SWITCH The Compartment Lights switch powers the lights inside of the compartments. This switch is located near the entrance door. • Press the switch UP (On) to supply power to the compartment lights. • Press the switch DOWN (Off) to disable power to the compartment lights.
Page 183: Stepwell Cover
SECTION 12 – MISCELLANEOUS automatically closes the awning. You may want will only extend when the vehicle ignition key is to experiment first to find the setting that best in the Off position. The awning can retract suits your needs. anytime regardless of the ignition key position.
Page 184: Windows
SECTION 12 – MISCELLANEOUS Stepwell Cover shown in extended position Emergency Retract Lever -Typical View (Located underneath stepwell cover) • Press DOWN for stepwell cover to store CAUTION WINDOWS Crank-Out Windows Stay clear of the entrance step area when the step cover is being extended or •...
Page 185: Power Roof Ventilator
SECTION 12 – MISCELLANEOUS Vertical Window Catches • To close, crank the window in snugly (by turning the crank-out handle clockwise), then POWER ROOF VENTILATOR back off 1/4 turn to help avoid glass warping, which can result in wind noise. Lounge, Galley, or Bath Area •...
Page 186: Air Hose Connector
SECTION 12 – MISCELLANEOUS 2. The turbine fan will start automatically as the vent dome is raised and stop as the vent dome is lowered and closed. (Fan Speed knob up on the ventilator frame must be in a position other than 0-Off).
Page 187 SECTION 12 – MISCELLANEOUS Ventilate with outside air Partially open one or more windows and a roof vent to circulate outside air through the coach. In cold weather, this ventilation may increase use of the furnace, but it will greatly reduce the condensation inside the coach.
Page 189 INDEX 2012 New Vehicle Limited Warranty ..1-2 Countertop Extension ........ 12-6 About this Manual ........1-1 Defrost Fans ..........3-17 Air Conditioner Filters ....... 4-13 Diesel Exhaust Fluid Fill ......3-24 Air Conditioner/Heater – Automotive Digital Sleep Air Bed ......... 9-16 (Dash) ............
Page 190 Index Formaldehyde Information ......2-7 Mold, Moisture, and Your Motor Home ..2-7 Fresh Water System ........7-1 MotorAid Water Heater ....... 4-9 Front Axle Tire Alignment ......1-4 Occupant and Cargo Carrying Capacity Front Drop-Down Solar/Night Shade Label ............1-5 (12-Volt) ...........
Page 191 Index Seats – Driver/Co-Pilot ........ 3-1 TV Digital Satellite System Wiring ... 8-11 Service and Assistance ......... 1-4 TV Signal Amplifier ........8-10 Shower Hose Vacuum Breaker ....7-8 Undercarriage ..........11-1 Signal Lever/Headlight High-Low Beam .. 3-16 Utility Light ..........7-2 Sleeping Facilities ........

This manual is also suitable for:

Journey 40u Journey 42e Journey 36m

Winnebago Journey 34Y Owner's Manual

1 Introduction

2 Safety and Precautions

3 Driving Your Motor Home

4 Appliances and Systems

5 Propane Gas

6 Electrical

7 Plumbing

8 Entertainment

9 Furniture and Softgoods

10 Slideout Rooms and Leveling

11 Maintenance and Storage

12 Miscellaneous

Quick Links

TABLE OF CONTENTS

Troubleshooting

Related Manuals for Winnebago Journey 34Y

Summary of Contents for Winnebago Journey 34Y