Table of Contents
Advertisement
THERMISTOR CHART
''HINT''
PROCEDURE FOR DETERMING WHETHER THE FRONT MAGNETRON CIRCUIT OR REAR MAGNTRON
CIRCUIT IS DEFECTIVE.
SYMPTOM:One magnetron does not work giving less than normal heat.
Caution:
Make sure that cabinet(outer wrap) and rear plate are not removed from the oven for your safety.
1.Operate oven as follws.
1) Remove the lead wire on the primary winding of high voltage transformer for front magnetron.
2) Place a cup of water in the oven.
3) Close the door.
4) Touch " CLEAR" , "TIME", "5" , "0" and "
5) When water is warm, the circuit of rear magnetron is normal.
When water is still cool, the circuit of front magnetron is defective.
7. DISASSEMBLY INSTRUCTIONS
- THE OVEN MUST BE DISCONNECTED FROM THE
ELECTRICAL OUTLET WHEN MAKING REPLACE-
MENTS, REPAIRS, ADJUSTMENT OR CONTINUITY
CHECKS. BEFORE PROCEEDING WITH ANY RE-
PAIR, WORKS, WAIT AT LEAST 1 MINUTE, UNTIL
THE CAPACITOR IN THE HIGH VOLTAGE AREA HAS
FULLY DISCHARGED.
A. REMOVING INTER LOCK MONITOR SWITCH
(See Figure 1 on page 1)
(1) Disconnect all lead wires form the interlock switch.
(2) Remove 1 screw securing the interlock monitor switch.
(3) Make the necessary adujustments or replace ment
of the switch by reversing step (3) and check micro-
wave energy leakage according to "1. ADJUSTMENT
PROCEDURE FOR SWITCHES" on page 1. Check
proper operation according to "CHECKOUT PROCE-
DURE FOR SWITCHES" on page 6.
Duct
Magnetron
" key to operate the oven for 50 seconds with full power level.
B.REMOVENG DOOR SENSING SWITCH
(See Figure 1 on page 1)
(1) Disconnect all lead wires form the interlock
monitor switch and door sensing switch.
(2) Remove 2 screws securing the lever stopper.
(3) Remove 2 screws and nuts from the door
sensing switch.
(4) Make the necessary adujustments or replace
ment of the switch by reversing step (3) and
check microwave energy leakage according
to "1. ADJUSTMENT PROCEDURE FOR
SWITCHES" on page 1. Check proper operation
according to "CHECKOUT PROCEDURE FOR
SWITCHES" on page 6.
- 10 -
Advertisement
Table of Contents
