Table of Contents
Advertisement
1
Important Safety Information
A...Appliance.Certification
Model:
Explorer II Medium Wood Stove
Laboratory:
Intertek
Report No:
10126132PRT
Type:
Safety
Standard:
UL 1482-07; ULC S627-00
The Quadra-Fire Explorer Series Wood Stove (ACC) meets
the U.S. Environmental Protection Agency's crib wood emis-
sion limits for wood heaters sold after May 15, 2015.
This wood heater needs periodic inspection and repair for
proper operation. It is against federal regulations to operate
this wood heater in a manner inconsistent with operating
instructions in this manual.
B...BTU.&.Efficiency.Specifications
EPA Certification #: 925
EPA Certified Emissions: 2.2 grams per hour
*LHV Tested Efficiency: 78.3 %
**HHV Tested Efficiency: 72.4 %
***EPA BTU Output: 11,200 to 35,900 / hr.
****Peak BTU/Hour Output: 61,000
Vent Size: 6 inches
Firebox Size: 2.42 cubic feet
Recommended Wood Length: 20 inches
Fuel Orientation: Side-to-Side
* Weighted average LHV efficiency using Douglas Fir dimension-
al lumber and data collected during EPA emissions test.
**Weighted average HHV efficiency using Douglas Fir dimen-
sional lumber and data collected during EPA emissions test.
***A range of BTU outputs based on EPA Default Efficiency and
the burn rates from the low and high EPA tests, using Douglas
Fir dimensional lumber.
****A peak BTU out of the unit calculated using the maximum first
hour burn rate from the High EPA Test and the BTU content of
cordwood (8600) times the efficiency.
C...Mobile.Home.Approved.(USA.ONLY).
• This appliance is approved for mobile home installa-
tions in the USA when not installed in a sleeping room
and when an outside combustion air inlet is provided.
• The structural integrity of the mobile home floor, ceil-
ing, and walls must be maintained.
• The appliance must be properly grounded to the frame
of the mobile home with #8 copper ground wire, and
chimney must be listed to UL103 HT or a listed UL-
1777 full length six inch (152mm) diameter liner must
be used.
• Outside Air Kit, part OAK-ACC must be installed in a
mobile home installation.
November 10, 2015
Fuel Seasoned Cord Wood
Fire.Risk.
Hearth & Home Technologies disclaims any
responsibility for, and the warranty will be voided
by, the following actions:
•
Installation and use of any damaged appliance.
•
Modification of the appliance.
•
Installation other than as instructed by Hearth & Home
Technologies.
•
Installation and/or use of any component part not approved
by Hearth & Home Technologies.
•
Operating appliance without fully assembling all
components.
•
Operating appliance without legs attached (if supplied with
it).
•
Do NOT Overfire - If appliance or chimney connector glows,
you are overfiring.
Any such action that may cause a fire hazard.
Improper installation, adjustment, alteration, service or
maintenance can cause injury or property damage.
For assistance or additional information, consult a qualified
installer, service agency or your dealer.
NOTE: Hearth & Home Technologies, manufacturer of
this appliance, reserves the right to alter its products, their
specifications and/or price without notice.
Hearth & Home Technologies WILL NOT warranty stoves
that exhibit evidence of over-firing. Evidence of over-firing
includes, but is not limited to:
• Warped air tube
• Deteriorated refractory brick retainers
• Deteriorated baffle and other interior components
D...Glass.Specifications
This stove is equipped with 5mm ceramic glass. Replace
glass only with 5mm ceramic glass. Please contact your
dealer for replacement glass.
E..Non-Combustible.Materials
Material which will not ignite and burn, composed of any
combination of the following:
- Steel
- Brick
- Concrete
- Glass
Materials reported as passing ASTM E 136, Standard
Test.Method.for.Behavior.of.Metals,.in.a.Vertical.Tube.
Furnace.of.750°.C..
F..Combustible.Materials
Material made of/or surfaced with any of the following ma-
terials:
- Wood
- Plant Fibers
- Plywood/OSB
Any material that can ignite and burn: flame proofed or not,
plastered or un-plastered.
7061-197H
Explorer II Medium Wood Stove
WARNING
- Plaster
- Iron
- Tile
- Slate
- Compressed Paper
- Plastic
- Sheet Rock (drywall)
3
Advertisement
Table of Contents
