Polaris Sportsman X2 850 Owner's Manual For Maintenance And Safety page 138

TROUBLESHOOTING
Engine Doesn't Turn Over
Possible Cause
Low battery voltage
Loose battery connections
Loose solenoid connections
Engine Turns Over, Fails to Start
Possible Cause
Out of fuel
Clogged fuel filter
Water is present in fuel
Old or non-recommended fuel
Fouled or defective spark plug(s)
No spark to spark plug
Water or fuel in crankcase
Low battery voltage
Mechanical failure
Engine Backfires
Possible Cause
Weak spark from spark plug
Incorrect spark plug gap or heat
range
Old or non-recommended fuel
Incorrectly installed spark plug wires
Incorrect ignition timing
Mechanical failure
Loose ignition connections
Water present in fuel
Leaking exhaust components
134
Solution
Recharge the battery to 12.8 VDC
Check all connections and tighten
Check all connections and tighten
Solution
Refuel, cycle key to ON position three
times for 5 seconds each, then start
See your dealer
Drain the fuel system and refuel
Replace with fresh recommended fuel
Inspect plugs and replace if neces-
sary
Inspect plugs, verify stop switch is on
Immediately see your POLARIS
dealer
Recharge the battery to 12.8 VDC
See your dealer
Solution
Inspect, clean and/or replace spark
plug(s)
Set gap to specs or replace plugs
Replace with fresh recommended fuel
See your dealer
See your dealer
See your dealer
Check all connections and tighten
Replace with fresh recommended fuel
See your dealer