The use of a substitute replacement component which does Leakage 0.5mA current Device not have the same safety characteristics as the PIONEER tester under recommended replacement one, shown in the parts list in test this Service Manual, may create shock, fire, or other hazards.
Page 3
To protect products from damages or failures during transit, the shipping mode should be set or the shipping screws should be u163 installed before shipment. Please be sure to follow this method especially if it is specified in this manual. DV-588A-S http://www.xiaoyu163.com...
For the applying amount of lubricants or glue, follow the instructions in this manual. (In the case of no amount instructions, apply as you think it appropriate.) 2.1 PACKING SECTION L 13942296513 "Operating Instructions" u163 DV-588A-S http://www.xiaoyu163.com...
Page 7
Guarntee Cade J2G00202A Operating Instructions (English) J2G60101A • • • • • • • • • • Package.Pad 792WHA0604 Polyethylene Bag JB5KD200 Gift Sheet 791WHA0100 Package 792WHA0588 Gift Box 793WCD1614 NSP 16 Poly. Bag 791WHAA040 L 13942296513 u163 DV-588A-S http://www.xiaoyu163.com...
Applying positions AA, AB and AC for the u163 CLASS PART NO. MARK PART NAME grease are displayed for this section. GREASE GEM1018 G-478B Check if the correct grease is applied for each GYA1001 PN-397 position. GEM1036 ME-913A DV-588A-S http://www.xiaoyu163.com...
Page 15
: POWER PORT BLOCK J7301 S VIDEO OUT J8001 AUDIO OUT CP502(14P) Cord Connector 06C32E3504 J8102 COAXIAL DIGITAL AUDIO OS8101 1/2- OPTICAL POWER PCB ASSY (A2G601A240) u163 : POWER BLOCK CP501 : DIGITAL AUDIO BLOCK BLACK BLACK(L) AC IN WHITE(N) WHITE DV-588A-S http://www.xiaoyu163.com...
3.3 DVD MT PCB (1/6) ASSY 3 7 63 1515 0 DVD MT PCB ASSY (A2G601A130) MPEG/MICON/RF-AMP BLOCK (RF) (RF) (RF) L 13942296513 MPEG/MICON EEPROM u163 DV-588A-S http://www.xiaoyu163.com...
Page 17
: S VIDEO SIGNAL ROUTE (C ch) (R/CR) : VIDEO SIGNAL ROUTE (R/CR ch) (G/Y) : VIDEO SIGNAL ROUTE (G/Y ch) (B/CB) : VIDEO SIGNAL ROUTE (B/CB ch) : AUDIO DATA SIGNAL ROUTE (DA) : AUDIO SIGNAL ROUTE (Digital) RESET IC CP601 u163 DV-588A-S http://www.xiaoyu163.com...
MEMORY BLOCK L 13942296513 u163 NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST DURING PLAYBACK. AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE DV-588A-S http://www.xiaoyu163.com...
(RF) L 13942296513 NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. u163 NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE DV-588A-S http://www.xiaoyu163.com...
Page 21
3 7 63 1515 0 (RF) : RF SIGNAL ROUTE (RF) L 13942296513 u163 DV-588A-S http://www.xiaoyu163.com...
3.6 DVD MT PCB (4/6) ASSY 3 7 63 1515 0 DVD MT PCB ASSY (A2G601A130) AUDIO JACK BLOCK CP8001 (DA) : AUDIO DATA SIGNAL ROUTE (DA) : AUDIO SIGNAL ROUTE (Digital) : AUDIO SIGNAL ROUTE (L ch) L 13942296513 (DA) u163 DV-588A-S http://www.xiaoyu163.com...
Page 23
3 7 63 1515 0 NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. AUDIO LPF& AUDIO LPF& L 13942296513 AUDIO LPF& u163 DV-588A-S http://www.xiaoyu163.com...
: VIDEO SIGNAL ROUTE (CB ch) : AUDIO DATA SIGNAL ROUTE (DA) : AUDIO SIGNAL ROUTE (Digital) (SC) (SY) : AUDIO SIGNAL ROUTE (L ch) (CB) (CR) VIDEO DRIVER 6CH L 13942296513 (SC) (SC) (SY) (SY) (CB) (CB) (CR) (CR) u163 DV-588A-S http://www.xiaoyu163.com...
Page 25
3 7 63 1515 0 NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. (SY) (CB) L 13942296513 (SC) J7301 (CR) J7302 u163 DV-588A-S http://www.xiaoyu163.com...
Page 26
3.8 DVD MT PCB (6/6) ASSY 3 7 63 1515 0 DVD MT PCB ASSY (A2G601A130) POWER PORT BLOCK REG+1.8V IC L 13942296513 u163 DV-588A-S http://www.xiaoyu163.com...
Page 27
3 7 63 1515 0 L 13942296513 NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. u163 DV-588A-S http://www.xiaoyu163.com...
SW660 : STOP CP605 SW662 : +SKIP SW664 : - SKIP SW663 : PLAY L 13942296513 SW665 : PAUSE OPERATION 3 PCB ASSY CP604 (A2G501ADF0) CP603 CP602 OPERATION 3 PCB ASSY SW667 : POWER u163 B C G DV-588A-S http://www.xiaoyu163.com...
Page 29
FIP DRIVER IC CP601 u163 NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. NOTE : THIS SCHEMATIC DIAGRAM IS THE LATEST AT THE TIME OF PRINTING AND SUBJECT TO CHANGE WITHOUT NOTICE DV-588A-S http://www.xiaoyu163.com...
3 7 63 1515 0 POWER PCB ASSY (A2G601A240) POWER BLOCK L 13942296513 PHOTO COUPLER • NOTE FOR FUSE REPLACEMENT CAUTION - FOR CONTINUED PROTECTION AGAINST RISK OF FIRE. REPLACE WITH SAME TYPE AND RATINGS OF FUSE. u163 DV-588A-S http://www.xiaoyu163.com...
Page 31
3 7 63 1515 0 6V REG (DVD MOTOR) L 13942296513 NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. VOLTAGE u163 DV-588A-S http://www.xiaoyu163.com...
3.11 POWER PCB (2/2) ASSY 3 7 63 1515 0 POWER PCB ASSY (A2G601A240) DIGITAL AUDIO BLOCK : AUDIO SIGNAL ROUTE (L ch) (DA) : AUDIO SIGNAL ROUTE (Digital) L 13942296513 FROM/TO POWER P.CON+D5V {1} MMZ1608R102CT u163 DV-588A-S http://www.xiaoyu163.com...
Page 33
+-1% SPDIF TP8102 J8102 COAXIAL COAXIAL YLC21-3055N W802 OS8101 OPTICAL OFTG038101 (DA) INPUT D_GND L 13942296513 CAUTION: DIGITAL TRANSISTOR CAUTION: DIGITAL TRANSISTOR NOTE : THE DC VOLTAGE EACH PART WAS MEASURED WITH THE DIGITAL TESTER DURING PLAYBACK. u163 DV-588A-S http://www.xiaoyu163.com...
LOADING MOTOR LOADING MOTOR PCB ASSY PCB ASSY (INSERTED PARTS) (CHIP MOUNTED PARTS) L 13942296513 SIDE A SIDE B CD2302 CP2302 SW PCB ASSY M2603 LOADING MOTOR CD2301 M2602 u163 SLED MOTOR CD2301 M2601 SPINDLE CP2303 MOTOR DV-588A-S http://www.xiaoyu163.com...
• Soldering combination: Sn-3.0Ag-0.5Cu • When Soldering/Removing of solder, use the draw in equipment over the Pick Up Unit to prevent the Flux smoke from it. L 13942296513 Pick Up PCB Short circuit using a soldering iron. Fig. 1 u163 DV-588A-S http://www.xiaoyu163.com...
• The video signal and the audio signal are outputted during the test mode. • The SKIP key and the SCAN key are effective during the test mode. TEST MODE: OFF POWER u163 GGF1381 Test mode remote control unit DV-588A-S http://www.xiaoyu163.com...
DVD : Press the [TEST] (A8-5E) and [1] (A8-01) keys in order, and turn on the laser diode (650n). : Press the [TEST] (A8-5E) and [4] (A8-04) keys in order, and turn on the laser diode (780n). L 13942296513 u163 DV-588A-S http://www.xiaoyu163.com...
• Place the unit on a workstation equipped to protect against static electricity, such as conductive mat. • Soldering iron with ground wire or ceramic type is used. • A worker needs to use a ground conductive wrist strap for body. u163 DV-588A-S http://www.xiaoyu163.com...
PAL system : [PAL] Automatic setting : [AUTO] Scart terminal output [SK – ∗ ∗] (Display only the WY model which can do the output setting u163 of scart terminal.) VIDEO : [00] S-VIDEO : [01] : [02] DV-588A-S http://www.xiaoyu163.com...
After you press the A.MON key while holding the ESC key pressed and then input the region number, if the number is different from that set in the unit, an error message is displayed, and the tray opens. u163 DV-588A-S http://www.xiaoyu163.com...
Display it according to model information set from the FL Driver IC. 2 Region No. L 13942296513 3 ROM number Rom display Version. 5 SUM CHK SUM value of E2P ROM displays with four places. 6 CHIP VERSION u163 DV-588A-S http://www.xiaoyu163.com...
7.0e -4 : NG 3 EDC/ID error history (ID Address, EDC/ID errors, last eight errors) Note: ∗ Error of AV1 is not supported in this player. L 13942296513 Indication plan contents Character in bold : Item name : Information display u163 DV-588A-S http://www.xiaoyu163.com...
Measure the voltage between the two ends of R2320 or R2322 on the DVDM Assy. If the voltage is 0.4 V or higher, the 780-nm LD is degraded. To OPTICAL PICKU DVD MT PCB ASSY L 13942296513 CP2301 Front side SIDE A u163 DV-588A-S http://www.xiaoyu163.com...
Check the video signal path between DVD IC (DVD MT Assy IC4002) displayed on the monitor Video circuit after DVD IC and video-out terminal (see the block diagram) (The FL display lights. The (IC4002) mechanism does not work.) u163 DV-588A-S http://www.xiaoyu163.com...
Page 62
Any kind of symptoms (no power, a failure in any of the servo, video and audio systems, etc.) may be (DVD MT Assy : IC4002) generated, because the DVD processing is performed by a single chip. u163 64M SDRAM No power. (DVD MT Assy : IC4005) Block noise is generated during playback. DV-588A-S http://www.xiaoyu163.com...
Up PCB and DVD PCB connector. 1-4: DVD PCB (Refer to Fig. 1-4) Power PCB Remove the 4 screws 1. Remove the 4 screws 2. Remove the DVD PCB in the direction of arrow. DVD PCB Fig. 1-2 u163 Fig. 1-4 DV-588A-S http://www.xiaoyu163.com...
Page 65
3 supports 1. between A and B. Fig. 2-3-D Remove the Plate Clamper, Magnet Clamper and Clamper. Check Hook Check Hook Plate Clamper Magnet Clamper Main Frame Clamper Loading Motor PCB Ass’y Check Hook Fig. 2-5-A Fig. 2-3-E u163 DV-588A-S http://www.xiaoyu163.com...
Page 66
Remove the Switch PCB Ass'y. 8.0 ± 0.2mm Remove the screw 4. Remove the Gear Feed. Feed Motor Remove the 2 screws 5. Remove the Feed Motor. Remove the Gear Motor. Safety surface for pressing of the insert. Fig. 2-7-C u163 DV-588A-S http://www.xiaoyu163.com...
Page 67
Fig. 2-8. NOTE L 13942296513 Do not make the folding lines except the specified positions for the FFC. [ 24 pin FFC ] Printing _Serface 85±1 mm Reinforcement Plat To Pick Up PCB Fig. 2-8 u163 DV-588A-S http://www.xiaoyu163.com...
Page 69
RF Amplifier Video DAC Servo IO Servo Motor Processor Video Drive Processor interlacer Spindle Control FLASH MPEG-1/2 Audio JPEG Memory Video Decoder Controller DRAM System Audio L 13942296513 Parser Audio Output CPPM/CPRM SPDIF System GPIO 32-bit RISC IR/VFD u163 DV-588A-S http://www.xiaoyu163.com...
Page 70
45 NC – – Version AD input port 0, or u163 DVDD3 – 3.3V power pin for internal digital circuitry GPIO FG(Diogital pin) – Motor Hall sensor input, or Version AD input 8 90 ALE Microcontroller address latch enable DV-588A-S http://www.xiaoyu163.com...
Page 71
DRAM data 9 185 NC – – 134 DVSS – 3.3V Ground pin for internal digital circuitry 186 NC – – u163 135 RD8 DRAM data 8 187 NC – – 136 DQS1 GPIO 188 NC – – DV-588A-S http://www.xiaoyu163.com...
Page 72
The positive input terminal of loop filter amplifier GPIO u163 237 LPFIN The negative input terminal of loop filter amplifier 212 DVDD3 – 3.3V power pin for internal digital circuitry 238 LPFOP The positive output of loop filter amplifier DV-588A-S http://www.xiaoyu163.com...
Page 73
RF ripple detect input (through AC-coupling) an external 15K resistor to this pin and 247 HRFZC High frequency RF ripple zero crossing AVSS 248 CRTPLP Defect level filter capacitor connecting 256 AVDD3 – Analog power 3.3V L 13942296513 u163 DV-588A-S http://www.xiaoyu163.com...
VIN4 – Channal 4 input operational amplifier – input. MUTE234 Controls the on/off state of channals 2, 3, and 4. MUTE1 Channal 1 output on/off control VCONT Loading block output high–level voltage setting S_GND Signal system ground u163 DV-588A-S http://www.xiaoyu163.com...
Page 77
High-Voltage Segment Output Pins 14 to SG1/KS1 to SG16/KS16 Also acts as the Key Source – Pull-Down Level 31 to SG17/GR12 to SG24/GR5 High Voltage Segment/Grid Output Pins 39 to GR4 to GR1 High-Voltage Grid Output Pins u163 DV-588A-S http://www.xiaoyu163.com...
Page 78
WMA files – do not use for other file types) product. – If you need further information about playability of DualDisc, please see ‘Service & Support’ on the Pioneer web site (www.pioneerelectronics.com) u163 DV-588A-S http://www.xiaoyu163.com...
Page 79
DivXNetworks, Inc. and are used format) are not compatible with this player. under license. u163 Check the DVD-R/RW or CD-R/RW software • Some external subtitle files may be disc boxes for additional compatibility displayed incorrectly or not at all. information. DV-588A-S http://www.xiaoyu163.com...
8.1 FRONT PANEL SECTION 3 7 63 1515 0 Front panel STANDBY/ON MENU L 13942296513 10 ENTER & cursor buttons 11 TOP MENU 12 Display OPEN/CLOSE RW Compatible 14 Disc tray HOME MENU 15 Remote control sensor RETURN u163 DV-588A-S http://www.xiaoyu163.com...
Indicates that the character display is showing a DVD title number. Lights during multi-angle scenes on a DVD disc. PRGSVE Lights when the player is set to output progressive scan video. Lights in any of the repeat play modes. u163 DV-588A-S http://www.xiaoyu163.com...
12 PLAY MODE Press to display the Play Mode menu. (You can also get to the Play Mode menu by pressing HOME MENU and selecting Play Mode). Press to jump to the beginning of the current u163 DV-588A-S http://www.xiaoyu163.com...
Page 83
18 MENU Press to change the zoom level. Press to display a DVD disc menu, or the Disc Navigator if a VR format DVD-RW, CD, Video CD , MP3, WMA or JPEG disc is loaded. L 13942296513 u163 DV-588A-S http://www.xiaoyu163.com...
Page 84
L 13942296513 Position to be cleaned Position to be cleaned Cleaning tools Cleaning tools Remark Remark Pickup leneses Cleaning liquid : GEM1004 Refer to "2.3 05 DVD MECHA SECTION" , "7.2 DISASSEMBLY SECTION". Cleaning paper : GED-008 u163 DV-588A-S http://www.xiaoyu163.com...