Advertisement
Table of Contents
- 1 Safety Notice
- 2 Section I: Flue System
- 3 Section II: Floor and Wall Protection
- 4 Section III: Freestanding Placement and Hook-Up
- 5 Section IV: the Function of the Add-On Furnace
- 6 SECTION V: HOT AIR HOOK-UP (See Fig. 3)
- 7 Section VI: Blower and Thermostat Installation
- 8 Section VII: Operating Instructions
- 9 Section VIII: Care and Maintenance
- 10 Section IX: Chimney and Flue Pipe Maintenance
- 11 Section X: Things that Could Cause the Unit to Smoke
- 12 Dealer Information
- 13 Unit Information
- Download this manual
INSTALLATION AND OPERATION MANUAL
MODELS: 28-3500 , 50-SHW35 & 50-TRW35
Thank you for purchasing this product from a fine line of heating equipment.
Please read this manual before attempting to move or install your unit.
We wish you many years of safe heating pleasure with your new heating appliance.
Visit our web site at
Please Note the Following Precautionary Statements:
England's Stove Works highly recommends the use of smoke detectors and Carbon
Monoxide detectors with any hearth product, including this unit. Follow all manufacturer's
instructions when using smoke and Carbon Monoxide detectors.
CAUTION:
This unit must be installed in accordance with these instructions and must comply with local
building and fire codes. Failure to do so could result in a chimney or house fire.
Keep children, furniture, fixtures and all combustible materials away from any heating appliance.
Maintain a minimum clearance of 18" (18 inches) from the flue pipe to any combustibles. Refer
to information in this manual and on the unit, and to all pipe manufacturers' instructions.
READ THESE INSTRUCTIONS CAREFULLY BEFORE INSTALLING THIS MODEL.
SAVE THESE INSTRUCTIONS FOR FUTURE REFERENCE.
INSTALLATION SHOULD BE PERFORMED BY A QUALIFIED INSTALLER.
NOTE: IF YOU HAVE A PROBLEM WITH THIS UNIT, DO NOT RETURN IT TO THE
DEALER. PLEASE CONTACT CUSTOMER SERVICE at (800) 245-6489.
FUEL: WOOD
HEATING CAPACITY: Approx. 3,000 SQ. FT (when fed into existing ductwork)
TESTED TO: UL 391, CSA-B366.1, ETLM 78.1
Rev: 2/12/2013
WOOD ADD-ON FURNACE
www.englanderstoves.com
questions, parts & accessory orders and more.
This unit is not mobile home approved.
Do not install this unit in a mobile home!
for helpful information, frequently asked
Advertisement
Table of Contents
Related Manuals for England's Stove Works 28-3500
Summary of Contents for England's Stove Works 28-3500
- Page 1 INSTALLATION AND OPERATION MANUAL MODELS: 28-3500 , 50-SHW35 & 50-TRW35 WOOD ADD-ON FURNACE Thank you for purchasing this product from a fine line of heating equipment. Please read this manual before attempting to move or install your unit. We wish you many years of safe heating pleasure with your new heating appliance.
- Page 2 A letter from our Technical Support department: Thank you for purchasing this fine product from England’s Stove Works! England's Stove Works was started, and is still owned by, a family that believes strongly in a "Do It Yourself" spirit – that’s one reason you found this product at your favorite “Do It Yourself”...
-
Page 3: Safety Notice
SAFETY NOTICE IF THIS UNIT IS NOT PROPERLY INSTALLED, A HOUSE FIRE MAY RESULT. FOR YOUR SAFETY AND PROTECTION, FOLLOW ALL OF THE INSTALLATION INSTRUCTIONS. INSTALLATION SHOULD BE PERFORMED BY A QUALIFIED INSTALLER. CONTACT YOUR LOCAL BUILDING OR FIRE OFFICIALS FOR RESTRICTIONS AND INSTALLATION INSPECTIONS REQUIRED IN YOUR AREA. - Page 4 C: Installation of a New Flue System 1. Masonry Flue: If you are considering a masonry flue (see Figure 1), you should contact your local building officials for the proper procedures required in the construction. We recommend that you consult with and have your flue built by a licensed, bonded contractor.
- Page 5 Installation Diagrams and Thermostat Wiring This appliance requires a masonry or pre-manufactured chimney listed to UL103HT, sized correctly. 18” Min. 18” Min. 18” Min. Figure 2 – Installation into a HT Pipe Flue System. LEFT – Through the Roof RIGHT – Through the Wall IMPORTANT NOTE: Do NOT connect this furnace to an external thermostat.
-
Page 6: Section Ii: Floor And Wall Protection
SECTION II: FLOOR AND WALL PROTECTION A. Floor Protection There is no protection required if your floor is constructed of a noncombustible material such as concrete. If your floor is constructed of a combustible material such as hardwood, carpet or linoleum some type of floor protection will be required. -
Page 7: Section Iv: The Function Of The Add-On Furnace
Chimney Connector Pipe This black pipe must be 6” (6 inches) in diameter and a 24-gauge or heavier pipe. Do not use aluminum or galvanized steel, as they cannot withstand the high temperatures of a wood fire. Do not use single wall pipe as a chimney. -
Page 8: Section V: Hot Air Hook-Up (See Fig. 3)
SECTION V: HOT AIR HOOK-UP (See Fig. 3) NOTE: The warm air supply-duct system should be constructed of materials with a minimum temperature rating of 250 deg. F. Also, the plenums installed to the furnaces are to be constructed of metal. NOTE: The hot air supply outlet of this supplementary furnace should not be connected to the cold-air return inlet of the central furnace, since a possibility exists that components of the central furnace could overheat in... -
Page 9: Section Vii: Operating Instructions
B. Thermostat Installation The thermostat, blower and power cord are all prewired (see Figure 4 for thermostat instructions); however, the thermostat must be connected to the furnace after installation of the blower. Do this by inserting the probe portion into the stove (remove the cover first, to reveal the mounting plate) and fastening the thermostat to the unit with the four screws that are mounted on the furnace. - Page 10 Notice: The surface of your new furnace and the connector pipe may smoke for a short time, and this is no cause for alarm. This is called “cooking out,” and it is advisable to open doors and windows in your dwelling during the first two hours (approximately) of operation.
- Page 11 B. Draft Controls This unit has a draft control system that is used to determine the amount of combustion air that enters the stove. The more the controls are opened, the more air will enter the firebox and thereby increase the heat output of the unit.
- Page 12 3. Use a poker to rake the dead ashes through the grates into the ash pan. Be sure to leave some “live” ashes in the firebox. 4. Fill the firebox with dry seasoned wood and leave the door cracked approximately 1/2” (one-half inch). Allow the fire to burn in this manner for 15 to 20 minutes.
-
Page 13: Section Viii: Care And Maintenance
Refer to the list at the rear of this manual for part numbers. You may order parts by calling SECTION VIII: CARE AND MAINTENANCE (800) 516-3636 or logging on to (Unit must be cool and power unplugged www.englanderstoves.com before performing any maintenance) A. -
Page 14: Section Ix: Chimney And Flue Pipe Maintenance
E. Baffle Plate This furnace has a large baffle plate (Part IP-2835) that is located in the top of the firebox. This baffle plate lays on an angle iron track and can be removed by sliding it out of the unit. If the baffle becomes warped, it can be replaced by calling (800) 516-3636 or logging on to: www.englanderstoves.com Caution: Allow the furnace to cool down before removing the baffle... - Page 15 You may write your unit’s Manufacture Date and Serial Number in the blank spaces on this sample tag, for future reference. This sample tag also shows the safety info. such as UL testing standard, etc. for your local officials, or anyone else who may need reference information.
- Page 16 LIMITED 5 YEAR WARRANTY FROM THE DATE OF PURCHASE TO THE ORIGINAL OWNER The manufacturer extends the following warranties: Five Year Period: 1. Carbon steel and welded seams in the firebox are covered for 5 years against splitting. 2. The cast iron door, hasp and hinges are covered for 5 years against cracking. One Year Period: 3.
- Page 17 ADD-ON FURNACE PARTS / OPTIONS LIST (Check your model for paint color, trim color, etc. if ordering a replacement for an original part). AC-G9 GLASS (9” X 9”), with Gasket AC-GGK GLASS GASKET KIT (gasket only, no glass) AC-MBSP BLACK SPRAY PAINT AC-1339 THERMOSTAT AC-DGKC...
-
Page 19: Dealer Information
WARRANTY REGISTRATION for England’s Stove Works Purchased by (Name) ______________________________________________ Address _________________________________________________________ City ________________________ State __________ Zip _________________ Telephone _______________________________________________________ Email Address ___________________________________________________ DEALER INFORMATION Purchased From (Dealer) ___________________________________________ Address _________________________________________________________ City ________________________ State __________ Zip _________________ UNIT INFORMATION (Please be sure to refer to sticker on back of manual or box to complete this section) Model Number _____________________ Purchase Date _________________ Purchase Price ____________________ Serial Number _____________________ Mfg.