Table Of Contents - Quadra-Fire MTVERNINSAE-PMH Installation Manual

MT VERNON AE INSERT
Safety Alert Key:
• DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury.
• WARNING! Indicates a hazardous situation which, if not avoided may result in death or serious injury.
• CAUTION! Indicates a hazardous situation which, if not avoided, may result in minor or moderate injury.
• NOTICE: Indicates practices which may cause damage to the appliance or to property.
Important Safety Information ............3
1
A. Appliance Certifi cation ......................................................3
B. BTU & Effi ciency Specifi cations........................................3
C. Glass Specifi cations .........................................................3
D. Electrical Rating................................................................3
E. Mobile Home Approved .................................................... 3
Getting Started ...................................4
2
A. Design, Installation & Location Considerations ..........................4
B. Thermostat Wall Control Location......................................5
C. Tools And Supplies Needed ..............................................5
D. Inspect Appliance and Components .................................5
E. Install Checklist ..................................................................6
Dimensions and Clearances .............7
3
A. Appliance Dimensions ......................................................7
B. Clearances to Combustibles (UL and ULC) .......................8
C. Masonry and Zero Clearance Fireplaces ..........................9
D. Floor Protection .................................................................9
E. Minimum Opening for Masonry &
Zero Clearance Fireplaces .................................................9
F. Mantel Projections ..............................................................9
G. Removing Metal Floor of Factory-Built Firebox .................10
H. Prefabricated Metal Chimney ............................................11
I. Altering the Factory-Built Fireplace .....................................11
2

TABLE OF CONTENTS

300 Watt Igniters come installed in brand new Mt. Vernon AE
units and are for pellet fuel only. The 380 Watt Igniter is required
for burning multi-grain fuels and is included in the component
pack. Multi-fuels include, corn, sunfl ower seeds, and wheat.
7036-188E
Vent Information ...............................12
4
A. Venting Termination Minimum Requirements ...................12
B. Avoiding Smoke and Odors ...............................................13
C. Negative Pressure ............................................................14
D. Draft..... ............................................................................. 14
E. Chimney and Exhaust Connection ...................................14
F. Equivalent Feet of Pipe ....................................................15
G. Pipe Selection Chart ........................................................15
Venting Systems ..............................16
5
A. Full Reline With Outside Air - Horizontal ...........................16
B. Full Reline With Outside Air - Vertical ...............................17
Appliance Set-Up .............................18
6
A. Leveling System ...............................................................18
B. Outside Air Kit Instructions ................................................18
C. Hearth Support .................................................................19
D. Removal of Cast Sides ....................................................19
E. Surround and Trim Set - Cast ...........................................20
F. Surround & Trim Set, Basic ...............................................20
G. Optional Log Set Placement Instructions .........................21
H. Wall Control Thermostat Installation .................................21
Mobile Home Installation .................22
7
Accessory List .................................23
8
May 5, 2015