Page 1
CDX-C6750/C7500 3 7 63 1515 0 SERVICE MANUAL US Model Canadian Model CDX-C6750 E Model CDX-C7500 Photo: CDX-C6750 SPECIFICATIONS Model Name Using Similar Mechanism CDX-C5750/C5850 CD Drive Mechanism Type MG-363T-121 AUDIO POWER SPECIFICATIONS (US, Canadian Model) Optical Pick-up Name KSS-521A...
NE REMPLACER CES COMPOSANTS QUE PAR DES PIÈCES REPLACE THESE COMPONENTS WITH SONY PARTS WHOSE SONY DONT LES NUMÉROS SONT DONNÉS DANS CE MANUEL PART NUMBERS APPEAR AS SHOWN IN THIS MANUAL OR OU DANS LES SUPPLÉMENTS PUBLIÉS PAR SONY.
Page 3
SECTION 1 GENERAL 3 7 63 1515 0 This section is extracted from CDX-C6750’s instruction manual. L 13942296513 u163 – 3 – http://www.xiaoyu163.com...
http://www.xiaoyu163.com 3 7 63 1515 0 2-3. SUB PANEL ASSY 5 claws 1 PTT 2.6x6 6 CNP800 4 claw 3 PTT 2.6x6 2 PTT 2.6x6 7 sub panel assy L 13942296513 2-4. CD MECHANISM BLOCK 6 PTT 2.6x6 1 PTT 2.6x6 7 bracket (M/D) 2 PTT 2.6x6 4 CD mechanism block...
http://www.xiaoyu163.com 3 7 63 1515 0 2-5. MAIN BOARD 4 ground point screws (PTT 2.6x6) 5 ground point screw (PTT 2.6x6) 3 PTT 2.6x8 6 MAIN board 2 PTT 2.6x8 1 PTT 2.6x8 L 13942296513 2-6. HEAT SINK 1 cord (with connector) (ANT) 2 PTT 2.6x8 u163 3 PTT 2.6x12...
http://www.xiaoyu163.com 3 7 63 1515 0 2-7. CHASSIS (T) SUB ASSY 4 P 2x3 3 P 2x3 5 chassis (T) sub assy 1 Unsolder the lead wires. 2 P 2x3 white black L 13942296513 2-8. LEVER ASSY 5 guide (disc) 6 lever (R) assy 3 tension spring (LR) 7 lever (L) assy...
http://www.xiaoyu163.com 3 7 63 1515 0 2-11. CHASSIS (OP) (O/S) ASSY 7 chassis (OP) (O/S) assy 8 compression spring (FL) 1 tension spring (KF1) 9 compression spring (FL) 2 tension spring (KR1) 5 Fit lever (D) in the direction of the arrow. 6 Turn loading ring in the direction of the arrow.
http://www.xiaoyu163.com SECTION 3 ELECTRICAL ADJUSTMENTS 3 7 63 1515 0 0 dB = 1 µV TUNER SECTION FM SENS/IF Adjustment Setting: SOURCE button : FMI Cautions during repair D-BASS switch : OFF When the tuner assy is defective, replace it by a new one Frequency Select switch (E model) : FM 200K because its internal block is difficult to repair.
Page 18
http://www.xiaoyu163.com 3 7 63 1515 0 AM Auto Scan/Stop Level Adjustment Setting: digital SOURCE n MODE button voltmeter : AM D-BASS switch : OFF Frequency Select switch (E model) : AM 10K S-METER OUT – AM RF signal level dummy antenna generator meter...
http://www.xiaoyu163.com 3 7 63 1515 0 Focus Gain Adjustment (Coarse adjustment) CD SECTION This adjustment is not required unless the following parts are replaced: • Optical pick-up Note: • 1. CD Block basically constructed to operate without adjustment. Therefore, check each item in order given. Procedure: 2.
http://www.xiaoyu163.com SECTION 4 DIAGRAMS 3 7 63 1515 0 4-1. IC PIN DESCRIPTION • IC801 MB90574PFV-G-192-BND (SYSTEM CONTROL) Pin No. Pin Name Pin Description LD ON Laser ON/OFF control output Focus OK signal detection input XLAT25 CD signal processing latch output DATA25 CD signal serial data output XRST...
Page 21
Destination select input 1 (Fixed at “L” in this set.) AREA2 Destination select input 2 (Fixed at “L” in this set.) AREA3 Destination select input 3 (Fixed at “L” (CDX-C6750) or “H” (CDX-C7500) in this set.) BAND Frequency select input (CDX-C7500 only) ACC IN...
Page 22
http://www.xiaoyu163.com 3 7 63 1515 0 Pin No. Pin Name Pin Description 112, 113 — Not used. (Open) CD LD Loading motor control output (Loading direction) CD EJ Loading motor control output (Eject direction) L SW Sled limit switch detection input IN SW/(PH1) Disc insertion detection input D SW...
Page 36
http://www.xiaoyu163.com 3 7 63 1515 0 • IC Block Diagrams IC1 CXD2507AQ SERVO AUTO DATA SEQUENCER XRST SENS SUB CODE MUTE PROCESSOR INTERFACE SQCK DIGITAL LOCK SQSO TEST EXCK SBSO FILO SCOR DIGITAL FILI DEMODULATOR WFCK EMPH AVSS CLTV ASYMMETRY AVDD CORRECTOR DIGITAL...
Page 37
http://www.xiaoyu163.com 3 7 63 1515 0 IC2 CXA1782BQ 27 26 25 LEVEL S MIRR SENS RF IV AMP1 DFCT C.OUT XRST RF IV AMP2 FE BIAS IIL DATA REGISTER INPUT SHIFT REGISTER DATA ADDRESS DECODER L 13942296513 OUTPUT DECODER TOG1-3 FS1-4 TG1-2 TM1-7...
Page 38
http://www.xiaoyu163.com 3 7 63 1515 0 IC401 TDA7462D SE3L SE3R MUTE PAUSE PAUSE DETECT FRONT INPUT TREBLE/ VOICE BANDPASS OUT FL LOUDNESS VOLUME FADER GAIN & SOFT BASS CONTROL SE1L CONTROL AUTO MUTE CONTROL CIRCUIT CIRCUIT SE1R ZERO CIRCUIT FRONT MD–...
Page 39
http://www.xiaoyu163.com 3 7 63 1515 0 IC601 TDA7427AD1 LPOUT VDD1 VDD2 LP FM SWITCH CHARGE PHASE 11 BIT PROG LP1/LP2 GND AM PUMP COMP COUNTER LP HC LP AM SWITCH SWITCH SWM/DIR SWM/DIR V REF AM IN SWITCH AM/FM INLOCK 6 BIT PROG PRE COUNTER DETECTOR...
http://www.xiaoyu163.com SECTION 5 EXPLODED VIEWS 3 7 63 1515 0 NOTE: • The mechanical parts with no reference • Color Indication of Appearance Parts The components identified by mark ! or dotted line with mark. number in the exploded views are not supplied. Example : ! are critical for safety.
http://www.xiaoyu163.com 3 7 63 1515 0 5-5. CD MECHANISM SECTION (3) (MG-363T-121) M901 M902 L 13942296513 The components identified by Les composants identifiés par une mark ! or dotted line with mark. marque ! sont critiques pour la ! are critical for safety. sécurité.
http://www.xiaoyu163.com SECTION 6 DISC IN SW DISPLAY ELECTRICAL PARTS LIST 3 7 63 1515 0 NOTE: • Due to standardization, replacements in • Items marked “*” are not stocked since The components identified by mark ! or dotted line with mark. the parts list may be different from the they are seldom required for routine service.
Page 46
http://www.xiaoyu163.com DISPLAY LIMIT SW LOAD SW MAIN 3 7 63 1515 0 Ref. No. Part No. Description Remark Ref. No. Part No. Description Remark R532 1-216-045-00 METAL CHIP 1/10W 1-659-837-11 LOAD SW BOARD R533 1-216-045-00 METAL CHIP 1/10W *************** R534 1-216-049-11 RES,CHIP 1/10W R535...
Page 54
CDX-C6750/C7500 3 7 63 1515 0 L 13942296513 u163 Sony Corporation 99B047038-1 9-926-442-11 Personal & Mobile Communication Company Printed in Singapore C1999. 2 – 66 – Published by Quality Assurance Dept. http://www.xiaoyu163.com...
Page 55
CDX-C6750/C7500 3 7 63 1515 0 US Model Canadian Model SERVICE MANUAL CDX-C6750 E Model CDX-C7500 SUPPLEMENT-1 File this supplement with the service manual. Subject : Change of Microcomputer (IC801) (ECN-CS804619, CSA00219) Page FORMER Ref. No. Part No. Description Remark Part No.
Page 56
3 7 63 1515 0 Page FORMER SERVO BOARD MAIN BOARD (SIDE A) L 13942296513 u163 Sony Corporation 9-926-442-81 99H0438-1 Mobile Electronics Company Printed in Japan C1999. 8 Published by Quality Assurance Dept. http://www.xiaoyu163.com...