Adjusting The Shift Pedal; Checking The Final Gear Oil Level - Yamaha 2006 FJR1300A Service Manual

EC3P61029
CAUTION:
Make sure that the main switch is turned to
"OFF" before checking the operation of the
hydraulic unit.
k. After operating the ABS, repeat steps (e) to
(i), and then fill the brake master cylinder res-
ervoir or brake fluid reservoir to the proper
level with the recommended brake fluid.
l. Tighten the bleed screw to the specified
torque.
Brake caliper bleed screw
6 Nm (0.6 m·kg, 4.3 ft·lb)
m. Fill the brake master cylinder reservoir or
brake fluid reservoir to the proper level with
the recommended brake fluid.
Refer to "CHECKING THE BRAKE FLUID
LEVEL" on page 3-22.
EWA14020
WARNING
After bleeding the ABS, check the brake op-
eration.
L LLL L LLL L L LLL L
EAS21380

ADJUSTING THE SHIFT PEDAL

1. Check:
• Shift pedal position
Check that the center of the shift pedal end
"1" is aligned with the center of the middle
gear case cover bolt "2" as shown in the illus-
tration when viewed directly from the side.
Incorrect → Adjust.
2. Adjust:
• Shift pedal position
M MMM M MMM M M MMM M
a. Loosen both locknuts "1".
b. Turn the shift rod "2" in direction "a" or "b" to
obtain the correct shift pedal position.
L LLL L L LLL L L LLL L
M MMM M M MMM M M MMM M
Direction "a"
Shift pedal is raised.
Direction "b"
Shift pedal is lowered.
NOTE:
Check that the groove "c" in the shift pedal is be-
tween the projections "d" on the frame.
2
c. Tighten both locknuts to specification.
L LLL L LLL L
LLL
EAS21460

CHECKING THE FINAL GEAR OIL LEVEL

1. Stand the vehicle on a level surface.
NOTE:
• Place the vehicle on the centerstand.
• Make sure the vehicle is upright.
2. Remove:
• Final gear oil filler bolt "1"
3. Check:
• Final gear oil level
The final gear oil level should be to the bot-
tom brim "2" of the filler hole.
Below the bottom brim → Add the recom-
mended final gear oil to the proper level.
MMM
3-25
1
a
b
d
c
Locknut
7 Nm (0.7 m·kg, 5.1 ft·lb)
L LLL L L LLL L L LLL L
Type
Shaft drive gear oil (Part No.:
9079E-SH001-00)
CHASSIS
L LLL L LLL