Polaris Trail Blazer 2004 Owner's Manual page 74

MAINTENANCE AND LUBRICATION
Periodic Maintenance Schedule
Improperly performing the procedures marked with a
result in component failure and lead to serious injury or death.
Have an authorized Polaris dealer perform these services.
Item
Spark plug
Ignition Timing
J
Fuel system
J
Fuel filter
J
Clutches
J
(drive and driven)
Engine mounts
Oil filter
J
Shift selector box
J
Brake fluid
J
Spark arrestor
Front and rear
J
wheel bearings
Idle speed
Recoil housing
Toe adjustment
J
Headlight aim
More often under severe use, such as dirty or wet conditions
"
Dealer service item
J
WARNING
Hours/ Frequency Remarks
Miles
100 hrs. 12 months
100 hrs. 12 months
100 hrs. 12 months
100 hrs. 12 months
100 hrs. 12 months
100 hrs. 12 months
100 hrs. 12 months
200 hrs. 24 months
200 hrs. 24 months
300 hrs. 36 months
300 hrs. 36 months
As required Adjust
As required Drain moisture out after rid-
As required Periodic inspection; adjust
As required Adjust as needed
could
J
Inspect; replace as needed
Inspect; adjust as needed
Check for leaks at tank
cap, lines, fuel valve, filter,
pump and carburetor; re-
place lines every two years
Replace annually
Inspect; clean
Inspect
Replace
Change lubricant every two
years
Change every two years
Clean out
Inspect; replace as needed
ing in water
when parts are replaced
71